Illustrated Owners and Parts Manual Made In The USA ROKON International Inc. 50 Railroad Avenue Rochester, NH 03839 Tel: 603 335-3200 Fax: 603 335-4400 e-mail:parts@rokon.com web site: www.rokon.com ©2005 Rokon International, Inc. Printed in U.S.A. ROKON® and its logo are registered trademarks. Rev.
Welcome to the growing group of ROKON owners. All operators must read and familiarize themselves with this owners manual and the safety information. The ROKON Warranty Statement is enclosed with this manual. For it to be validated, the complete ROKON Utility Vehicle Registration Card must be signed and returned to ROKON within 10 days of the date of purchase. We congratulate you on your decision to purchase a ROKON Utility Vehicle.
BEFORE YOU OPERATE YOUR NEW ROKON, THE FOLLOWING IMPORTANT POINTS MUST BE OBSERVED. 1. Children under 16 should not operate a ROKON. 2. Carefully read and follow the instructions in the safety section of this manual. 3. Carefully read and follow the setup procedure on the yellow card attached to your ROKON (See yellow card instructions, also on page 56 of this manual). 4. Follow the Pre-Operation Checklist. TABLE OF CONTENTS SECTION: Page 1. Safety Information 3-4 2.
Section 1 Safety Information Always wear an approved motorcycle helmet that fits properly, eye protection (goggles or face shield), gloves, sturdy boots, long sleeve shirt, jacket and pants while operating a ROKON. Never consume alcohol or drugs before or while operating a ROKON. The ROKON is a go slow vehicle. Never operate at speeds too fast for your skills or the conditions. Always operate at a speed that is appropriate for the terrain, visibility and operating conditions and your experience.
Section 1 Continued Safety Information WARNING: Potential bodily injury. Never operate a ROKON without the chain guards and side covers in place and securely attached with all fasteners properly tightened. Never exceed the stated load capacity. Cargo should be properly distributed and securely attached. Reduce speed and follow instructions in this manual for carrying cargo or pulling a trailer. Be careful to allow greater distances for braking when carrying cargo or operating with a trailer.
Section 2 Description and Machine identification Record the Vehicle Identification number and Engine Number in the spaces below to facilitate ordering spare parts or for reference if the vehicle is stolen VIN Engine Number The Engine number is on the front of the engine facing the front wheel. The Vehicle identification number is on the center frame tube beneath the driver seat. ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 3 Control Functions The Shut Off Switch is black in color and is located on the left hand side of the handlebar. Pressing the “kill” switch will shut off the engine. This is a safety feature and will allow the operator to immediately shut off the engine in an emergency. The Fuel Petcock located on the right hand side under the fuel tank shuts off fuel flow to the engine. The down position is for fuel flow. The up position shuts fuel off. Shut the fuel off when storing or transporting your ROKON.
Section 3 Continued Control Functions Recoil Starter. Firmly grasp the handle and pull slightly until engagement can be felt. Then pull forcefully, being careful not to pull the rope all the way out. Return the starter rope gently. Rider Seat Suspension. The seat suspension spring can be adjusted to suit the rider’s weight and riding conditions. Adjust the spring per load as follows: To increase the spring preload, turn the adjuster clockwise.
Section 4 Pre-operation Checks Before using this machine, check the following points. Front and Rear Brake. Check brake action. Check pucks to see that they are not over worn. There should be visible brake material on both sides of the brake disc. See Section 6. Fuel Tank. Check fuel level. Fill as necessary. Use super unleaded for altitudes above 10,000 ft. Engine Oil. The engine holds .6 qt. of SAE10W30/40 motor oil. Fill to the dipstick “full” line. Miter Box and Transmission.
Section 5 Operating Your ROKON When starting your ROKON, place the range selector in neutral. Stand on left hand side, put the front brake on with two fingers of your left hand, throttle closed, reach over the Rokon and pull the starter handle. For a cold start put the choke on. Once the engine turns over, set the choke off. Pull on the starter again and the vehicle will start. Engage the three-range selector in the desired gear range. Put the ball of the foot, rather than the instep on the footrest.
Section 5 Continued Operating Your ROKON The ROKON can be used to cross slow moving shallow water of up to a maximum of 24 inches in depth. Before entering the water, choose your path carefully. Enter where there is no sharp drop off, and avoid rocks or other obstacles which may be slippery or upset the ROKON. Drive slowly and carefully. Never change your course in the middle of a stream or you will find that slippery rocks and currents might throw you out of balance.
Section 6 Periodic Maintenance and Adjustment Routine care of your ROKON vehicle is easily done and is important for rider safety and vehicle longevity. 1. Inspect all fasteners for tightness. 2. The drive chains require adjustment at intervals, depending on the mileage and the care which the operator has given the chains. Initial wear must be taken up by adjustment after the first few hours of use.
Section 6 Continued Periodic Maintenance and Adjustment Storing your ROKON 1. Close the gasoline shut-off valve, this will prevent fuel leakage when transporting or storing your ROKON. This is a key item when transporting your ROKON for example on the wheel free carrier. 2. Start the engine and allow it to run until it stops from lack of fuel. This will use up all the fuel in the carburetor and prevent the formation of deposits due to evaporation of fuel. 3.
Periodic Maintenance and Adjustment Section 6 Continued Trouble Shooting SYMPTOM PROBABLE CAUSE 5. Noisy driveline. Driveline improperly seated. Worn or broken override spring. Worn, broken or loose carrier bearing or bearing retainer. Worn bosses leading into override spring. Worn universal joint. 6. Noisy front miter box. Low oil level. Loose gearbox mounting bolts. Worn or broken bevel gears. Worn shaft bearings. Improper gear mesh. 7. Rear wheel won’t drive. Wheel chain off sprocket.
Periodic Maintenance and Adjustment Section 6 Continued Trouble Shooting Engine SYMPTOM 14 PROBABLE CAUSE 1. Engine will not start. No fuel in tank or shut-off valve closed. Spark plug not firing. Fuel not being delivered to combustion chamber. Engine flooded. Too much fuel in combustion chamber. Improper spark plug gap. Plugged fuel filter. 2. Engine hard to start. Water or dirt in fuel or stale fuel mixture. Weak ignition spark. Plugged air filter. Engine over or under choked.
Periodic Maintenance and Adjustment Section 6 Continued Trouble Shooting Engine SYMPTOM PROBABLE CAUSE 6. Engine overheats. Engine overloaded. Oil too low in crankcase. Incorrect spark plug. Ignition timing over-advanced. Scored piston or cylinder wall. Lean Mixture. Dirty air filter / blocked air intake. 7. Engine noisy or knocking. Loose flywheel. Worn bearings. Broken or loose parts inside engine. Lack of oil in crankcase. 8. Engine stalls under load. Fuel line restricted or tank vent closed.
Periodic Maintenance and Adjustment Section 6 Continued Care and Adjustment of ROKON Brakes General: Rokon all wheel drive vehicles have individual front and rear disc brakes. They are cable operated by hand levers on the handlebars. The left lever controls the rear brakes and, in the forward direction, stops the rear wheel. The overrunning clutch in the driveline allows the front wheel to continue rotating. The right lever operates the front brake and stops both wheels.
Section 6 Continued Periodic Maintenance and Adjustment Maintenance: Cables are plastic lined and do not require lubrication though it is OK to do so. Be aware that a drop of water in a cable may freeze and prevent braking. Use boots and lubricants to prevent this. Test before riding off in freezing weather. Replace pucks when they are down to 1/4 inch thick. The moveable puck is loose, but the stationary puck is secured to the caliper with a small slotted head screw. Locktite this screw.
Section 7 Repair Procedures I. TRANSMISSION AND DRIVELINE REMOVAL PROCEDURE Section 1, Procedure for transmission removal: 18 1. Elevate and secure the bike firmly to a non-moving stand. Bike should be elevated so that the rear wheel is not touching the ground. 2. Remove all fiberglass side covers from the bike. 3. Shut fuel valve. Disconnect fuel line and plug, if necessary. Remove fuel tank. 4. Remove front seat.
Section 7 Continued 12. Repair Procedures Remove all four transmission attaching bolts, three on the frame mount, and one next to the upper cross shaft. (Two should already be removed from the brake bracket as described in step 11). At this point: Transmission can be removed, by moving left to right to loosen it from the Driveline clutch, sliding back into fender well, and carefully turning sideways and pulling upward.
Section 7 Continued Repair Procedures II. Front Miter Box and Universal Joint Removal Procedure 20 1. Remove front chain guard and front chain. Use a 1/2-inch wrench or socket to remove chain guard. Then find master link and loosen chain. Remove master link. Take chain off. 2. Remove headlight. Using 1/2 inch wrench loosen and remove nut that attaches light to fender. Unplug power lead & disconnect ground that is attached at miter box mounting bolt. Set aside. 3. Remove brake caliper and disc.
Repair Procedures Section 7 Continued III. FRONT DRIVE LINE SYSTEMS CHECK 1. Elevate bike so wheels are not touching the ground. 2. Apply front brake. 3. Rotate rear tire in forward direction. 4. While rotating rear tire (in forward direction), check front universal joint for rotation. If the universal joint is spinning, check roll pin that attaches front drive sprocket. If roll pin is not damaged, then the internal miter box roll pin is sheared.
Section 8 Torque and other Specification Charts Torque and Threadlocking Specifications For Fasteners On Rokon 2WD Vehicles Fastener Size 10-32 Location Foot Rest Tube Thread locking Lock Washer Torque In. lbs. Ft. lbs.
Section 9 Limited Warranty ROKON WARRANTY SYSTEM ROKON International Inc. warranties to the original purchaser, new ROKON Utility vehicles to be free of defects that are the result of faulty workmanship or material, for a period of one year from the date of purchase for new year model ROKONs only. In the case of competition machines, no warranty is expressed or implied. The entire risk to the quality and performance of competition machines is with the buyer.
Section 10 Illustrated Parts Manual Index of Illustrations Page 25 26 27 28 29 30 & 31 32 & 33 34 35 36 37 38 & 39 40 41 42 43 44 45 46 47 48 & 49 50 51 52 53 54 24 Nomenclature Brakes Chain Parts Decals Electrical Engine Honda Engine Kohler Frame Front fork Cargo Rack Assembly Fuel Tank Assembly Muffler Handlebar Assembly Pullstarter Front Seat Rear Seat Torque Converter Drive Pulley Torque Converter Driven Pulley Tow Bar Transmission Complete Transmission with Attachments Transmission in Sequence Miter
Section 10 Continued 18 Brake 17 2 5 7 6 1 4 10 16 16 11 5 14 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 Part Number 108023 108024 108025 108026 108027 108028 108029 108030 108031 108032 108033 108002 100788 100509 100169 100202 108982 101673 100481 108002 100254 21 15 Name Live Side Housing Compression Spring Lever Arm Locking Nut Actuating Pin Back Plate Dead Side Housing Dead Side Puck Flat Head Screw Hex Head Bolt Live Side Puck Caliper Assembly Brake Spring Brake HH Bol
Chain Section 10 Continued 1 2 3 4 Item 1 2 3 4 5 6 26 Part Number 100356 100355 100354 108984 101568 101570 Name Master Link Offset Link Full Link Chain Length Front Chain 107P Rear Chain 117P Description Qty 2 as needed as needed as needed not shown not shown ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Decals 7 10 9 1 4 6 8 5 Item 1 2 3 4 5 6 7 8 9 10 11 Part Number 108039 101595 108041 108040 108043 108990 108991 101626 108057 108988 108972 2 3 Name Decal "Trail-Breaker" in Black Decal "Scout" in Black Decal "Ranger" in Black Decal "Trail-Breaker" in Red Decal "Scout" in Red Decal "Rokon" Oval in Red Decal "Rokon" Oval in Brown Decal "Shift Instructions" Decal Made in USA Decal Oil Warning Decal Handlebar “Rokon” ROKON INTERNATIONAL, 50 Railroad Ave.
Section 10 Continued Electrical 4 2 3 8 1 9 7 6 5 Item 1 2 3 4 5 6 7 8 9 10 11 28 Part Number 108177 108178 104315 104313 108126 100190 101135 100170 100169 100448 100449 Name Wiring Harness Front Wiring Harness Rear Rear Tail Light Headlight Voltage Regulator Kill Switch Assembly Brake Light Mounting Plate Bolt Nut Cable Tie (Long) Cable Tie (Short) 10 Description HH Bolt 1/4-28 x 1 1/2 Lock Nut 1/4-28 As Necessary As Necessary ROKON INTERNATIONAL, 50 Railroad Ave.
Honda Engine Section 10 Continued 1 4 2 6 Item 1 2 3 4 5 6 7 Part Number HONGX160 100369H HON5247408 101548H 108253 108254 108256 7 3 5 Name Honda Engine Spark Plug Air Filter Crank Key E Clip Screw Cable Holder Description GX160 Qty 1 1 1 1 1 M4 Size, 6 mm length, .7mm pitch 1 1 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Kohler Engine Section 10 Continued 1 23 19 18 3 7 6 5 10 12 11 8 4 9 16 17 14 30 15 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 Kohler Engine Part Number KOH PA911512 KOH PA911513 100369K KOH6308306-S 108235 108253 108254 108246 108256 100034 100037 100165 100884 100885 108137 108123 108983 KOH6304121-S KOH6334005-S KOH6385304-S KOH6375704-S KOH Air Box Assy 108968 Name Description Qty 6.6 Hp Kohler Command PS 1 6.6 Hp Kohler Command ES not shown 1 Spark Plug 1 Air Filter 1 Throttle Bracket 1 E Clip 1 Screw M4 Size, 6 mm length .
Frame Section 10 Continued 2 4 21 22 5 21 22 1 23 19 24 13 26 9 10 11 17 25 16 6 18 8 7 14 12 15 32 3 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 Part Number 105066 108243 108994 108995 108996 100386 100223 100285 100290 108272 108271 100343 101572 101629 101630 100126 100255 100573 100036 108087 100273 100275 100034 100037 108123 100551 Frame Name Frame Rear Fender Kohler Fairing LHS Fairing RHS Front Fairing RHS Rear Kickstand Kickstand Spring Clevis Pin Cotter Pin Foot Rest RHS Cleated Foot Rest LHS Cleated Passenger Foot Rest (Set of 2) Rubber Chain
Section 10 Continued Front Fork 6 5 4 2 1 15 11 14 12 5 17 7 16 13 3 9 10 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 34 Part Number 105064 100453 100935 103136 100772 107026 107025 100573 100036 100427 108106 101629 101630 100035 100037 100167 100169 8 8 9 Name Front Fork Weldment Front Fender Pop Rivet Snap Ring Bearing Upper Fork Bolt Lower Fork Bolt Wheel Adjuster Bolt Nut Front Mud Flap Front Chain Guard Stud Receptacle Screw Nut Bolt NutLock Description Sealed Use Locktite 242 Us
Section 10 Continued Front Cargo Rack 3 1 2 6 5 4 Item 1 2 3 4 5 6 7 Part Number 100423 100167 100281 100170 100255 100169 100892 Name Front Cargo Rack Screw Washer Screw Washer Nut Front Cargo Rack Kit Description HH 1/4-20 x 1/2 1/4" Lock Washer HH 1/4-28 x 1 1/2 1/4 x 28 Locking Includes all items above ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Fuel Tank 1 5 7 8 6 2 4 3 9 5 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 36 Part Number 103120-GR 102843 102766 101295 100122 102594 102593 102590 101969 101970 102589 103120-RED 103120-OD 103120-BLK 11 5 10 Name Fuel Tank Forest Green Fuel Cap Fuel Filter Shut off Valve Fuel Line O Ring Nut Fuel Tank Fitting Rubber Fuel Tank Washer Bolt Flat Washer Fuel Tank Red Fuel Tank Olive Drab Fuel Tank Black Description Qty 1 1 1 1 3 1 1 1 1 1 1 9/16"-18 HH 1/2-20 x 3/4 not shown no
Section 10 Continued Muffler 1 4 3 5 4 1 Item 1 2 3 4 5 6 Part Number 108236 108150 108998 108997 100255 KOH6331402-S Name Muffler Kohler Muffler Honda Sandwich Mount Nut Washer Muffler Guard Description not shown 1/4-20 Jam Nut Nylock Qty 1 1 2 4 2 not shown ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Handle Bar 2 12 16 4 1 21 21 3 3 15 14 17 18 17 14 15 18 19 20 6 5 11 11 7 10 10 7 13 8 38 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 Part Number 100466 100071 100820 107036 100015B 100014HB 108002 108234 108001 100610 100788 100559 100043 104309 107033 103113 108173 108174 108115 108116 103116 Handle Bar Name Handlebar Grip Set Brake Lever Throttle Cable Front Brake Cable Rear Brake Cable Brake Caliper Rear Brake Bracket (Kohler Only) Rear Brake Bracket (Honda Only) Brake Disc Brake Spring Throttle Spring Woodruff Key Brake Switch Boot Twist Grip Handleba
Section 10 Continued Pullstarter 7 1 5 9 3 8 4 6 Item 1 2 3 4 5 6 7 8 9 10 40 Part Number KOH6308619-S KOH6316502-S KOH6308105-S KOH6316601-S KOH6308921-S 15585 KOH6309302-S KOH6375706-S KOH6308652-S KOH6310902-S Name Screw, hex flange Starter, retractable Housing Assembly Starter, handle Recoil Spring Pull Rope Pulley Kit, pawl repair Screw Starter Cup Description Qty 3 1 1 1 1 1 1 1 1 1 includes 3-9 includes 9 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Front Seat 1 2 9 10 7 6 5 8 3 6 7 Item 1 2 3 4 5 6 7 8 9 10 11 11 Part Number 100451H 109002S 108063 108062 101629S 100208 101970 108999 101181 100212 100168 100169 4 5 Name Front Seat Shock Seat Base Plate Lower Shock Mount Bolt Washer 1/2 Flat Bolt Bolt Bolt Nut Bolt Nut Description Qty 1 1 1 1 Lag 5 2 HH Bolt 1/2-20 x 3/4 2 1 HH Bolt 3/8-24 x 1 3/4 1 Lock Nut 3/8-24 1 Not Pictured for Lower Shock Mount 2 Not Pictured for Lower Shock Mount 2 ROKON INTERNATIONAL, 50 Rai
Section 10 Continued Rear Seat 1 2 3 3 4 Item 1 2 3 4 42 Part Number 100340 100343 100281 105037 Name Rear Seat Passenger Foot Peg Set Locking Washer Hex Head Bolt Description Lock Washer 1/4 Spring HH Bolt 1/4-20 x 1 3/8 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Torque Converter Drive Pulley 1 2 5 8 6 9 7 4 10 3 12 11 13 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 Part Number 703209 601319 690144 690146 703128 703116 703127 703129 703151 703211 108123 108983 100885 Name Fixed Face and Hub Assy Moveable Face Assy Spring Kit Roller Arm Kit Liner Spline Bearing Washer Retractor Plate Washer Clutch Bolt Locking Clip Torque Converter Drive Complete Description not shown not shown Idler Bearing Ramp Plate Retaining Includes 1-10 ROKON INTE
Section 10 Continued Torque Converter Driven Pulley 4 5 2 1 6 7 3 8 Item 1 2 3 4 5 6 7 8 44 Part Number 601311 703110 703109 703111 703305 601406 901709 100884 Name Hub Fixed Face Bearing Movable Face Spring Button Shoe Ramp Torque Bracket Set Screw Driven Pulley Description Includes Items 5 & 7 Rear Includes 1-7 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Tow Bar 9 1 8 7 2 11 6 5 7 4 8 5 6 9 3 Item 1 2 3 4 5 6 7 8 9 10 11 Part Number 100349 100007 103181 100166 100255 100169 100848 100208 100551 100893 100170 Name Tow Bar Chain Rigid Tow Bar Bolt Washer Nut Bolt Washer Nut Tow Bar Kit Bolt Description Accessory HH 1/4-28 x 1 Lock Nut 1/4-28 HHCS 5/16-24 x 3/4 Flat Washer 3/8 Locknut 5/16-24 Hex Includes all except 3 HH 1/4-28 x 1 1/2 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Transmission Complete Fill Plug Fill Level Drain Plug 46 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Transmission with Attachments 1 3 4 6 5 2 6 Item 1 2 3 4 5 6 Part Number 101680 100884 100610 100040 100270 100043 Name Transmission Assembly Rear Driven Clutch Brake Disc 11 Tooth Sprocket Roll Pin Woodruff Key Description ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Transmission in Sequence Section 10 Continued 41 1 2 37 38 3 4 38 37 5 6 7 2 4 17 43 2 12 7 14 11 8 5 6 37 9 11 10 5 13 20 8 42 6 5 21 23 5 18 16 15 6 26 25 10 5 27 28 33 29 34 5 31 30 48 2 6 22 24 2 19 40 32 35 ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Section 10 Continued Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 Part Number 101502 101523 103142 103134 100158 103136 100160 100045 101519 100043 101506 103143 101517 105082-2 101511 101637 101633 101634 101632 101528 101527 101530 101541 101631-3 101631-2 101631-1 101516 107039 101505 101548 101510 100047 101509-3 101509-2 101509-1 100163 101525 101524 101939 105082 108987 101615 100163 Transmission in Sequence Name Descri
Section 10 Continued Miter Box 6 18 7 5 10 11 16 17 8 4 2 15 9 7 8 1 5 13 14 10 12 11 3 5 15 5 8 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 50 Part Number 103131 100040 108053 103132 100158 108987 100160 101523 100270 100045 103136 101615 101616 100043 101505 100108 100853 100100 Name Miter Box Assembly 11 T Sprocket Miter Box Drive Shaft Miter Box Driven Shaft Bearing Pressure Relief Vent Miter Gear Oil Seal Roll Pin Roll Pin Snap Ring Shim ID 3/4" OD 1 1/8" .
Section 10 Continued 2 1 Transmission to Miter Box 12 18 11 11 5 16 6 14 3 10 2 15 7 2 17 4 8 9 8 Part Number 101680 100039 100038 100307 108079 100314 100252 100281 100043 108054 100046 100100 100312 100047 101655 101656 100002 101529 100045 101640 Name Transmission Case Assembly Lock Washer Screw Snap Ring Drive Shaft Drive Line Bearing Screw Lock Washer Drive Line Key Universal Joint Roll Pin Miter Box Assembly Bearing Retainer Roll Pin Drive Line Boss Retaining Pin Override Spring Scre
Section 10 Continued Aluminum Wheels 1 2 4 15 14 10 9 11 10 11 9 14 12 6 7 13 15 8 3 5 17 18 16 19 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 52 Part Number 100519 100836 100542 100521 108156 108129 100405 105030 100772 100522 100208 100756 100758 101181 100288 108112 100036 100523 100516 Name Tire 5.
Section 10 Continued Steel Wheels 2 1 4 14 10 13 9 7 9 13 10 14 12 12 11 11 6 8 5 3 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 Part Number 100519 100836 100541 100521 100116 100117 100405 105030 100772 100522 100208 101181 100853 100288 Name Tire 5.
Section 10 Continued 54 Wiring Diagram ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
Service/Maintenance Log DATE DESCRIPTION OF SERVICE ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.
IMPORTANT – PLEASE COMPLY WITH THE FOLLOWING OWNER PREPARATION STEPS PRIOR TO OPERATION OF YOUR NEW ROKON: 1) READ AND BECOME THOROUGHLY FAMILIAR WITH THE MATERIAL IN YOUR OWNERS MANUAL. 2) REDUCE THE TIRE PRESSURE TO 31/2 PSI IN THE FRONT TIRE AND 21/2 PSI IN THE REAR TIRE. 3) HANDLEBAR INSTALLATION: HANDLEBAR HAS BEEN DISASSEMBLED FOR SHIPMENT. REINSTALL AND POSITION HANDLEBAR AND TORQUE HANDLEBAR MOUNTING BOLTS TO 20 FT/LBS.
