Safety Light Curtains User Manual User guide

R
GuardShield™ Safe 4 Safety Light Curtain User Manual
27
Original instructions
Appendix
GuardShield Safe4 Specials—for existing
customers
Safety Light Curtain Systems
Content
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Systems without an Integrated Laser Alignment System (ILAS)
27
Systems with Connector Cap . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Cascaded Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Systems with Separated Controller . . . . . . . . . . . . . . . . . . . . . . . 29
Dimensional Drawings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Cascaded Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
System with Integrated Controller . . . . . . . . . . . . . . . . . . . . . . . 31
Special Systems. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Part List Safe 4 Specials . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Introduction
In addition to the GuardShield Safe 4 manual this appendix shows
some special systems e.g.:
• GuardShield Safe 4 without laser alignment system (ILAS)
• Systems with a hard-wired connection end cap
• Cascaded systems
• Systems with separated controller
• Other special systems
Systems without an Integrated Laser Alignment
System (ILAS)
The systems mentioned in the table below are not equipped with
an integrated laser alignment (ILAS) system. So the profile length
is reduced by 25 mm on each side of the protective field (see
Figure 22).
GuardShield Safe 4 Systems without Laser Alignment
Cascaded GuardShield Safe 4 Systems
Sensor Pair
Resolution
[mm (in.)]
Protective Heights
[mm (in.)]
Range
[m (ft.)]
445L-103000-0189 14 (0.55) 120 (4.7) 9 (29.5)
445L-103000-0044 14 (0.55) 240 (9.5) 9 (29.5)
445L-103000-0076 14 (0.55) 360 (14.2) 9 (29.5)
445L-103000-0130 14 (0.55) 480 (18.9) 9 (29.5)
445L-103000-0036 14 (0.55) 600 (23.6) 9 (29.5)
445L-103000-0157 14 (0.55) 720 (28.4) 9 (29.5)
445L-103000-0153 14 (0.55) 840 (33.1) 9 (29.5)
445L-103000-0140 14 (0.55) 960 (37.8) 9 (29.5)
445L-103000-0136 14 (0.55) 1080 (42.5) 9 (29.5)
445L-103000-0195 14 (0.55) 1200 (47.2) 9 (29.5)
445L-103000-0196 14 (0.55) 1440 (56.7) 9 (29.5)
445L-103000-0164 14 (0.55) 1560 (61.4) 9 (29.5)
445L-103000-0034 30 (1.18) 360 (14.2) 18 (59)
445L-103000-0139 30 (1.18) 480 (18.9) 18 (59)
445L-103000-0193 30 (1.18) 840 (33.1) 18 (59)
445L-103001-0199 30 (1.18)
1560 / 1320
(61.4 / 52)
445L-103001-0057 14 (0.55)
840 / 240
(33.1 / 9.5)
445L-103001-0121 14 (0.55)
600 / 120
(23.6 / 4.7)
445L-103001-0163 14 (0.55)
120 [120 + 240]
(4.7 [4.7 + 9.5])