RZR ® DASH KIT FOR PMX COMPACT DIGITAL MEDIA RECEIVER RFRZ-PMX2DK Serial Number: Date of Purchase: Installation & Operation
Introduction Dear Customer, Congratulations on your purchase of the world’s finest brand of audio products. At Rockford Fosgate we are fanatics about musical reproduction at its best, and we are pleased you chose our product. Through years of engineering expertise, hand craftsmanship and critical testing procedures, we have created a wide range of products that reproduce music with all the clarity and richness you deserve.
Specifications 7.7” (96mm) 2.1” (54mm) 5.7” (146mm) FRONT VIEW SIDE VIEW Fig. 1 Mounting Screw Source Unit (Not Included) Existing storage pocket (Not Included) Spring Clip Panel Knockout Dash Kit Shoulder Head Bolt Fig.
Installation Contents • Dash Kit • (4) Mounting Screws • Allen Wrench • Installaton Guide 2014 and up RZR® XP/XP4 1000 2016 and up RZR® XP/XP4 Turbo *2015 and up RZR® XP/XP4 900 * Must purchase storage pocket from Polaris® for a 2014 and up RZR® XP/XP4 1000 to utilize this dash kit on 2015 and up RZR® XP/XP4 900 models.
Installation Lift off the panel once the bolts are removed. This will give you access to the center pocket support bracket. Step 5 - Remove the Center Pocket Protective Cover Turn the center pocket upside down to provide access to the protective cover pins. Using a pry tool, simply pry the two pins loose so you can remove the cover. Step 3 - Remove the Center Pocket Brace Using a Torx screwdriver, remove the bolt that attaches the brace to the rear of the pocket.
Installation Step 6a - Optional Knockout Panels for Accessory Switches Step 7 - Mount the Source Unit to the Dash Kit Before mounting the source unit to the dash kit, make sure that trim bezel that is included with the source unit is NOT attached. If it is attached, you will need to remove it. It will NOT be used. This dash kit also offers additional space to mount up to two rocker panel switches for accessories.
Installation Step 8 - Attach the Dash Kit to the Center Pocket On the rear of the pocket, you will need to remove one of the circular knockout panels providing an access hole to route wiring from your source to your vehicle. Step 9 - Attach the Dash Kit to the Center Pocket NOTE: Make sure the speed clips are lined up correctly or the screw will not be able to be tightened. Step 10 - Reinstalling the Dash Kit Slide the dash kit, source unit and wiring back into the dash.
Installation Step 11 - Reinstalling Instrument Panel Place the instrument panel back on top of the dash. Secure the panel with factory screws. Step 12 - Attach Hood Place the hood back on the vehicle and rotate the mounting clip to the lock the hood back into place.
Warranty Rockford Corporation offers a limited warranty on Rockford Fosgate products on the following terms: Length of Warranty POWER Amplifiers – 2 Years BMW® Direct Fit Speakers – 2 Years All other products - 1 Year Any Factory Refurbished Product – 90 days (receipt required) What is Covered This warranty applies only to Rockford Fosgate products sold to consumers by Authorized Rockford Fosgate Dealers in the United States of America or its possessions.
Installation assistance available at: 120315 1230-60386-01-A Printed in China www.rockfordfosgate.com/rftech 600 South Rockford Drive • Tempe, Arizona 85281 United States Direct: (480) 967-3565 • Toll Free: (800) 669-9899 R O C K F O R D F O S G AT E .
DIGITAL MEDIA RECEIVER PMX-2
Introduction Dear Customer, Congratulations on your purchase of the world’s finest brand of audio products. At Rockford Fosgate we are fanatics about musical reproduction at its best, and we are pleased you chose our product. Through years of engineering expertise, hand craftsmanship and critical testing procedures, we have created a wide range of products that reproduce music with all the clarity and richness you deserve.
Specifications Model Operating Voltage Fuse Rating Power Output Max. RCA Output Voltage Output Impedance PMX-2 10.5V - 16V 20A 25 W X 4 @ 4 Ohms RMS 50 W x 4 @ 2 Ohms Peak 4V 500Ω Frequency Response 20 - 20kHz FM Frequency Range 87.5MHz - 107.9MHz AM Frequency Range 530kHz - 1710kHz WB Frequency Range 162.40 - 162.55 (US & Canada) Tuner Presets Clock Display Bluetooth 18 FM / 12 AM / 6 WB No Clock 2.7” Color TFT 3.0+EDR, A2DP 1.3 USB Compatibility 2.
Design Features Rotary Encoder This knob is for adjusting main volume, zone volumes, menu navigation and setting adjustments. REV / FWD button Use this button to skip back and forward through channels or tracks with a short press. Long pressing will activate manual seek mode. MENU button This button gives you access to the main settings of the unit by long pressing. Short pressing will give you access to the settings for the active source.
Wiring Diagram BLACK USB BLACK BLACK RED (REAR LINE OUT RIGHT OR SUB-W OUT) WHITE (REAR LINE OUT LEFT OR SUB-W OUT) GREY RED (FRONT LINE OUT RIGHT) WHITE (FRONT LINE OUT LEFT) RED RED (AUX IN RIGHT) WHITE (AUX IN LEFT) FILTER & FUSE BOX IN 20A FUSE RADIO ANTENNA OUT BLACK WIRED REMOTE 13DIN FEMALE B B ORIENTATION PIN NO.
Installation / Mounting Contents Mounting (Using Mounting Plate) • Source Unit • Screws • Trim Bezel • Power / Speaker Harness • Mounting Plate • Installation & Operation Manual • U Bracket Installation Considerations The following is a basic list of tools needed for installation: • Volt/Ohm meter • Hand held drill w/ assorted bits • Wire strippers • Heat shrink tubing • Wire crimpers • Soldering iron • Wire cutters • Solder • #2 Phillips screwdriver • Heat gun • Battery post wrench • 7mm
Settings AUX INPUT RENAME – To rename AUX, short press the encoder button to set the first letter of the new name. Once active, rotate encoder to adjust letters. Short press the encoder button again to set the next letter. Repeat until AUX has been renamed. Short press MENU to exit and go back up one level. ENABLE - Short press the encoder button to access options. Rotate the encoder button to select if unit is discoverable.
Settings ADJUSTING THE SUBWOOFER OUTPUT Press the SUB + or SUB- buttons to adjust the output level (0-20). ADJUSTING THE SCREEN BRIGHTNESS Short press the SCREEN BRIGHTNESS button to adjust the brightness level. There are two brightness levels. SELECTING A SOURCE TO PLAY Short press the SRC button to show the different source options (FM TUNER>AM TUNER>WB TUNER>USB>AUX>BLUETOOTH>PANDORA>SIRIUSXM). Use the rotary encoder or short press the SRC button to scroll through sources.
Operation ADD PRESETS Short press the encoder button on the ADD PRESETS option. You will need to be on both the station you want to add first. Using this feature allows you to save stations to the unit. Once selected, use the rotary encoder to select the PRESET number (1-6) you want the station saved to. REMOVE PRESETS Short press the encoder button on the REMOVE PRESETS option. You will need to be under the PRESET group you want to adjust first (AM1>AM2).
Operation Pandora® This feature allows you to control the Pandora® app from the source unit directly (Android users will have to use Bluetooth only, iOS users can use both USB and Bluetooth). You will need to start the Pandora® app on your device first, then select the Pandora® source option on the source unit. To use the “Thumbs Up” feature, long press the SUB+ button. To use the “Thumbs down” feature, long press the SUB - button. To play or pause a song, short press the PLAY/PAUSE button.
Troubleshooting Symptom Diagnosis Remedy Basic Blown fuse Check fuse of the unit, replace with correct rating. Vehicle’s ignition is off If connected following the instructions, the unit will not operate with ignition off. Voltage applied to Red wire is not between 10.5 & 16 volts or there is no voltage present Check battery, connections and fuses and repair or replace as necessary. If voltage is above +16 volts, have the electrical system inspected by an authorized service center.
Warranty Rockford Corporation offers a limited warranty on Rockford Fosgate products on the following terms: Length of Warranty POWER Amplifiers – 2 Years BMW® Direct Fit Speakers – 2 Years Source Units – 1 Year All other products – 1 Year Any Factory Refurbished Product – 90 days (receipt required) What is Covered This warranty applies only to Rockford Fosgate products sold to consumers by Authorized Rockford Fosgate Dealers in the United States of America or its possessions.
Installation assistance available at: 061115 1230-59187-01-D Printed in China www.rockfordfosgate.com/rftech 600 South Rockford Drive • Tempe, Arizona 85281 United States Direct: (480) 967-3565 • Toll Free: (800) 669-9899 R O C K F O R D F O S G AT E .
RZR ® FRONT SPEAKER ENCLOSURES RFRZ-FSE Serial Number: Date of Purchase: Installation & Operation
Introduction Dear Customer, Congratulations on your purchase of the world’s finest brand of audio products. At Rockford Fosgate we are fanatics about musical reproduction at its best, and we are pleased you chose our product. Through years of engineering expertise, hand craftsmanship and critical testing procedures, we have created a wide range of products that reproduce music with all the clarity and richness you deserve.
Enclosure Assembly DRIVER SIDE (LEFT) PASSENGER SIDE (RIGHT) TYPICAL ASSEMBLY (Passenger Side Shown) Mounting Screw Speaker (Not Included) Speaker Wire Access Hole Threaded Mounting Stud Mounting Screw Speaker Enclosure Fig.
Installation Contents • (1) Passenger Side Front Speaker Enclosure • (1) Driver Side Front Speaker Enclosure • (2) Foam Tape • (2) Threaded Studs • (4) Mounting Screws w/ Washers • (2) Mounting Bolts w/ Washers • Installation Guide Installation Tools The following is a list of suggested tools needed for installation: • Ratchet • 5/32” Allen Wrench • 15mm Socket • 13mm Socket Installation Considerations This section focuses on some considerations for installing your Polaris® RZR® Front Speaker Pod Enclo
Installation The speaker pods are designed to work with Rockford Fosgate’s RFRZ-PMXWH1 and RFRZ-K4D wire kits. After the front speaker wire is run threw both down tubes, you are ready to start the process of mounting the enclosure. Step 2 - Attach Threaded Stud Once the bolt is removed, install the threaded stud back into the hole where the bolt was removed. This provides a new mounting point for the speaker enclosure.
Installation Step 4 - Mount the Speaker Enclosure Position the enclosure over the threaded stud and plastic bosses. Be sure to line up the holes before inserting mounting screws and tightening. Step 6 - Mount Speaker Into Enclosure Connect the front speaker wires to the speaker by sliding the connectors over the speaker terminals. Be sure to maintain proper polarity when wiring up the speaker. NOTE: There are (2) mounting screws with washers, (1) mounting bolt that hold each speaker enclosure in place.
7
Warranty Rockford Corporation offers a limited warranty on Rockford Fosgate products on the following terms: Length of Warranty POWER Amplifiers – 2 Years BMW® Direct Fit Speakers – 2 Years All other products - 1 Year Any Factory Refurbished Product – 90 days (receipt required) What is Covered This warranty applies only to Rockford Fosgate products sold to consumers by Authorized Rockford Fosgate Dealers in the United States of America or its possessions.
Installation assistance available at: 010216 1230-60158-01-A Printed in China www.rockfordfosgate.com/rftech 600 South Rockford Drive • Tempe, Arizona 85281 United States Direct: (480) 967-3565 • Toll Free: (800) 669-9899 R O C K F O R D F O S G AT E .
PMX-2 RZR ® WIRE KIT RFRZ-PMXWH1 Serial Number: Date of Purchase: Installation & Operation
Introduction Dear Customer, Congratulations on your purchase of the world’s finest brand of audio products. At Rockford Fosgate we are fanatics about musical reproduction at its best, and we are pleased you chose our product. Through years of engineering expertise, hand craftsmanship and critical testing procedures, we have created a wide range of products that reproduce music with all the clarity and richness you deserve.
Rear Right Speaker Rear Left Speaker Front Left Speaker GND Front Right Speaker Switched B+ ional RFRZ-RSW16 (Not Included) ional RFRZ-RSW16 (Not Included) Wire Harness Schematic PMX-2 Source Unit 3
Installation Contents Applicable Models: 2014 and up RZR® XP/XP4 1000 2016 and up RZR® XP/XP4 Turbo 2015 and up RZR® S/ XC / 4 900 • (1) PMX-2 Wire Harness • Plastic Wire Tie Wraps • Plastic Wire Clamps • Installation Guide Installation Tools The following is a list of suggested tools needed for installation: • Ratchet • 5/32” Allen Wrench • 15mm Socket / Wrench • Small Flat Blade Screwdriver • 13mm Socket / Wrench • Wire Cutters • Torx - T40 Installation Considerations This section focuses on som
Installation Using your hands, pull the top dash piece toward the interior of the vehicle to release it from the dash. Disconnect all of the wires connectors and set aside. After the brace is disconnected from the center pocket, pull the pocket out of the dash. Step 4 - Remove Center Console After all of the seats have been removed, you will need to remove the center consoles on the vehicle. This is necessary to route the wire harnesses down the vehicle.
Installation Next remove the bolts and plastic retaining clips. Use a small flat blade screwdriver to pry the plug out of the retainer so it can be removed. Remove the existing rubber grommet in the fire wall and cut along the score lines to open it up for the wire harness. Place the grommet over the wire harness. Next, remove the rear console if equipped (4 seater). Step 5 -Routing Wire Harness Now that the center console is out of the way, take the wire harness and place it through the fire wall.
Installation NOTE: It is recommended to run both front speaker harnesses through the down tubes when installing Rockford Fosgate’s RFRZFSE front speaker pods. Pull the wire harness through the fire wall. Step 7 - Route Source Unit Connector Next you will need to route the source unit connector through the thought the center pocket opening. NOTE: This harness is designed to work with Rockford Fosgate’s PMX-2 Source Unit. Connect the ring terminals to the factory accessory power distribution block.
Installation Continue routing the wire harness on top of the center console supports. Insert the plastic wire ties into the holes on the support bracing to secure in place. Step 10 - Install Center Pocket After you have the PMX-2 dash kit installed onto the pocket, it can go back in the vehicle. NOTE: Be careful to mount the wire harness on top of the center console supports so it will be clear of moving drive line components. Be sure to slide the pocket support onto the rear brace for a secure fit.
9
10
11
Warranty Rockford Corporation offers a limited warranty on Rockford Fosgate products on the following terms: Length of Warranty POWER Amplifiers – 2 Years BMW® Direct Fit Speakers – 2 Years All other products - 1 Year Any Factory Refurbished Product – 90 days (receipt required) What is Covered This warranty applies only to Rockford Fosgate products sold to consumers by Authorized Rockford Fosgate Dealers in the United States of America or its possessions.
Installation assistance available at: 010716 1230-60387-01-A Printed in China www.rockfordfosgate.com/rftech 600 South Rockford Drive • Tempe, Arizona 85281 United States Direct: (480) 967-3565 • Toll Free: (800) 669-9899 R O C K F O R D F O S G AT E .
SPEAKERS Serial Number: RM0652 • RM0652B RM1652 • RM1652B Date of Purchase: Installation & Operation
Introduction Dear Customer, Congratulations on your purchase of the world’s finest brand of audio products. At Rockford Fosgate we are fanatics about musical reproduction at its best, and we are pleased you chose our product. Through years of engineering expertise, hand craftsmanship and critical testing procedures, we have created a wide range of products that reproduce music with all the clarity and richness you deserve.
Specifications Model RM0652 RM0652B RM1652 RM1652B Nominal Diameter - inch (mm) 6.5 (165) 6.5 (165) 6.5 (165) 6.5 (165) Description 2-Way 2-Way 2-Way 2-Way 4Ω 4Ω 4Ω 4Ω Frequency Response (Hz) 52-20k 52-20k 49-20k 49-20k Voice Coil Diameter - inch (mm) 1.0 (25.4) 1.0 (25.4) 1.0 (25.4) 1.0 (25.4) Power Handling - Watts (RMS/Peak) 50/100 50/100 75/150 75/150 Fs - Free Air Resonance (Hz) 70.0 70.0 64.5 64.5 Qts 1.08 1.08 0.93 0.93 Vas - cu. ft. (Liter) 0.38 (10.
Specifications RM0652/RM0652B 6.8” (172mm) 4.4” (111mm) 5.4” Dia. (138mm) 3.5” (88mm) 45 ° 2.5” (63mm) 5.4” (138mm) RM1652/RM1652B 6.8” (172mm) 4.4” (111mm) 5.4” Dia. (138mm) 3.6” (90mm) 45 ° 2.5” (63mm) 5.4” (138mm) illus.-1.
Installation Contents Example of standard installation • (1) Pair Marine Grade Speakers • (8) Socket head stainless screws RM0652/RM0652B • (1) Socket head driver bit Installation Considerations Before beginning any installation, follow these simple rules: 1. Be sure to carefully read and understand the instructions before attempting to install these speakers. 2. For safety, disconnect the negative lead from the battery prior to beginning the installation. 3.
Français Considérations Concernant L’installation Español Consideraciones para la instalación Avant de commencer l’installation, suivez les règles ci-dessous: Antes de comenzar cualquier instalación, siga estas simples normas: 1. Veillez à bien lire et comprendre les instructions avant d’essayer d’installer les haut-parleurs. 1. 1. Asegúrese de leer cuidadosamente y de entender las instrucciones antes de tratar de instalar estos altavoces. 2.
Deutsch Einbauüberlegungen Befolgen Sie vor dem Einbau diese einfachen Regeln: 1. 1. Lesen Sie die Anleitung sorgfältig, bevor Sie versuchen diese Lautsprecher einzubauen. 2. Entfernen Sie vor dem Einbau aus Sicherheitsgründen das negative Kabel von der Batterie. 3. Um die Montage zu erleichtern, empfehlen wir alle Kabel vor der Befestigung Ihrer Lautsprecher zu verlegen. 4. Verwenden Sie nur Qualitätsstecker, um einen zuverlässigen Einbau zu gewährleisten und Signal- und Stromverlust zu minimieren. 5.
Warranty Rockford Corporation offers a limited warranty on Rockford Fosgate products on the following terms: Length of Warranty POWER Amplifiers – 2 Years BMW® Direct Fit Speakers – 2 Years All other products - 1 Year Any Factory Refurbished Product – 90 days (receipt required) What is Covered This warranty applies only to Rockford Fosgate products sold to consumers by Authorized Rockford Fosgate Dealers in the United States of America or its possessions.
Installation assistance available at: 121514 1230-58876-01 Printed in China www.rockfordfosgate.com/rftech 600 South Rockford Drive • Tempe, Arizona 85281 United States Direct: (480) 967-3565 • Toll Free: (800) 669-9899 R O C K F O R D F O S G AT E .
