SDS
_____________________________________________________________________________________________________________________________________________________________________________________________________________________________________________
------------------------------------------------------------------------------------------------------------------
ATL confidential
Page 9 of 20
5
Ensure that the equipment cannot be moved in the outer packing; If there are more than one piece of
equipment in the package, it must be packed tightly together to prevent damage caused by contact with
other equipment in the package.
6
Do not damage or mishandle this package. If package is damaged, batteries must be quarantined,
inspected, and repacked.
7
Cells and batteries identified by the manufacturer as being defective for safety reasons, or that have been
damaged, that have the potential of producing a dangerous evolution of heat, fire or short circuit are
forbidden for transport.
8
Waste lithium batteries and lithium batteries being shipped for recycling or disposal are prohibited from
air transport unless approved by the appropriate national authority of the State of origin and the State of
the operator.
9
The lithium battery should pass the UN38.3 test, if the battery cannot pass the testing, it cannot transport,
should redesign.
10
The new lithium battery operating mark allows to be 100mm x 100mm square, the minimum mark size is
100mm x70mm.
丨 Ocean shipping
Transportation refers to the IMDG CODE 39-18 Edition, which are managed according to UN
NO 3480/3481 and packaged in the second category. Firm installation, isolation from each
other, short circuit prevention, packages with more than 24 lithium cells or 12 lithium batteries:
special procedures to be followed when damaged must be marked; special procedures
document to be followed when damaged is available on board.
The clause 188 of IMDG CODE 39-18 Edition required:
(1) The watt-hour rating of lithium ion cell is less than 20 Wh and the watt-hour rating of
lithium-ion battery is less than 100 Wh is not classified as dangerous cargo,but each package
shall be marked with below lithium battery mark.
(2) Must be packed in inner packagings that completely enclose the cell and battery(not applicable
when contained in equipment), inner packagings shall be packed in strong outer packagings
that in accordance with < Model Regulation>4.1.1.1、4.1.1.2、4.1.1.5.
(3) Must be protected so as to prevent short circuits, including preventing short circuits caused by
contact with conductive materials in the same container.
The clause 230 of IMDG CODE 39-18 Edition required:
(1) The model of each lithium ion cell and battery should meets all testing requirements under Part
III, subsection 38.3 of <UN Manual of Tests and Criteria>.
Issue: 2021-A
Doc No.: 2621040084 Issue Date: 2021-04-27
_____________________________________________________________________________________________________________________________________________________________________________________________________________________________________________
SAFETY DATA SHEET
Dongguan PowerAmp Technology Ltd.
Rechargeable Li-ion Battery pack: BPR-1P6S-3600A1 ,22.2V,3468mAh,76.98Wh