User Manual

18
System Flush
6. Attachthecompressorblockadapter(fromthe
ushingkit)tothesystemsideofthecompressor
block.
7.Conguretheblockconnectorstoprovide
forward-orback-ushingoftherefrigerant.
Note: Refrigerant ows from the red high-side
connector to the blue low-side connector.
8.Opentheredservicecoupler.
9.Connectthelterhousingtothedesiredreturn
sideoftheadapterblockandtothebluelow-
sidehose.
10. Opentheblueservicecoupler.
11. Verifythataushinglteriscorrectlyinstalled
intheushinglterhousing.Opentheisolation
valveonthehose.
Operating Instructions
1.SelectSYSTEM FLUSH.
2.SelectSTART toacceptthedefaultushtimeof
10minutes,orenterthedesiredushtimeusing
thekeypadandselectSTART.
3.Thevacuumpumprunsforveminutesto
removeairfromtheA/Csystem,ifneeded.
4. Theunitushesthesystemforthedesignated
lengthoftime,andthenentersarecoverymode.
5. Oilthathasbeencollecteddrainsintothe
graduatedoildrainbottle.Removethebottleand
measuretheoil.
 Disposeofoilaccordingtothelawsinyour
jurisdiction.Itistheresponsibilityoftheuserto
determineifamaterialisahazardouswasteat
thetimeofdisposal.
6. WhentheunitdisplaysFLUSHCOMPLETE,
closeservicecouplers,removehoses,and
reassemblethevehicle’sA/Csystemtoits
originalstate.
7.Openthevalveonthesourcetank.
8.Evacuateandrechargethevehicleaccordingto
theinstructionsinthismanual.
WARNING: Do NOT disconnect
service couplers during the ushing
process. Refrigerant could spray out
of the ttings, and exposure may
cause personal injury.
Operating Tips
If the external ushing lter is plugged,
the unit displays
NOFLOWDETECTED.FLUSHFILTER
MAYBEBLOCKED.
CHECKCONNECTIONSANDVALVE
POSITIONS.
TOCLEARFILTERFOR
REPLACEMENT,CLOSEFLUSH
FILTERADAPTERVALVEAND
SELECTSTART.
SELECTEXITTOABORT
ORRETRYTOCONTINUEWITHOUT
REPLACINGFILTER.
The message repeats until the lter is
replaced.