SDS

ManualsBrandsRoberts ManualsAdhesivesQuick Bond 12 oz. Spray Adhesive

Safety Data Sheet

Revision Date: 03/08/2018

SECTION 1: Identification and Company Details

Product Name: 8200 Quick Bond Spray Adhesive

Product Code: 8200

Manufacturer/ Supplier: Roberts Consolidated Industries, Inc.

Address: 300 Cross Plains Blvd.

Dalton, GA 30721

Emergency Phone: (800) 424-9300 (24-hour Response / CHEMTREC)

Product Information: (706) 277-5294

SECTION 2: Hazard(s) Identification

OSHA / HCS Status: This material is considered hazardous by the OSHA Hazard.

Communication Standard (29 CFR 1910.1200)

Physical hazards: Flammable aerosols Category 1

Gases under pressure Liquefied Gas

Health Hazards Skin corrosion/irritation Category 2

Serious eye damage/eye irritation Category 2

Reproductive toxicity (fertility) Category 2

Specific target organ toxicity, single exposure Category 3 narcotic effect

Specific target organ toxicity, repeated exposure Category 2

Aspiration hazard Category 1

OSHA defined hazards: Not Classified

Signal Word: Danger

Hazard Statements: Extremely flammable aerosol

Contains gas under pressure; may explode if heated

May be fatal if swallowed and enters airways

Causes skin irritation

Causes serious eye irritation

May cause drowsiness or dizziness

Suspected of damaging unborn child

Suspected of damaging fertility

May cause damage to organs through prolonged or repeated exposure

Hazard Pictograms:

Precautionary Statements: Obtain special instructions before use.

Do not handle until all safety precautions have been read and understood.

Keep away from heat/sparks/open flames/hot surfaces. - No smoking.

Do not spray on an open flame or other ignition source.

Pressurized container: Do not pierce or burn, even after use.

Do not breathe gas. Use only outdoors or in a well-ventilated area.

Wear protective gloves/protective clothing/eye protection/face protection.

If swallowed: Immediately call a poison center/ doctor. Do NOT induce vomiting.

If on skin: Wash with plenty of water.

If inhaled: Remove person to fresh air and keep comfortable for breathing.

If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do.

Continue rinsing.

If exposed or concerned: Get medical advice/attention. Call a poison center/doctor if you feel unwell.

If skin irritation occurs: Get medical advice/attention.

If eye irritation persists: Get medical advice/attention.

Take off contaminated clothing and wash before reuse.

Storage: Store in a well-ventilated place. Keep container tightly closed. Store locked up. Protect from

sunlight. Store in a well-ventilated place. Protect from sunlight. Do not expose to temperatures

exceeding 50°C/122°F.

Summary of content (10 pages)

PAGE 1
Safety Data Sheet Revision Date: 03/08/2018 SECTION 1: Identification and Company Details Product Name: Product Code: Manufacturer/ Supplier: Address: Emergency Phone: Product Information: SECTION 2: 8200 Quick Bond Spray Adhesive 8200 Roberts Consolidated Industries, Inc. 300 Cross Plains Blvd.
PAGE 2
Disposal: Environmental hazards: Dispose of contents/container in accordance with local/regional/national/international regulations. Hazardous to the aquatic environment, acute Category 3 Hazardous to the aquatic environment, long term hazard Category 3 Hazard(s) not otherwise Classified (HNOC): None known. Supplemental information: None. SECTION 3: Composition / Information on Ingredients Weight % Acetone 20 – 40 Propane 20 – 40 Dimethyl Ether 10 - 20 n-Hexane 10 - 20 2-Methylpentane 2.
PAGE 3
General fire hazards: SECTION 6: Extremely flammable aerosol. Contents under pressure. Pressurized container may explode when exposed to heat or flame. Accidental Release Measures Personal Precautions: Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of low areas. Wear appropriate protective equipment and clothing during clean-up. Do not breathe gas. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing.
PAGE 4
US ACGIH Threshold Limit Values Components 2-Methylpentane (CAS 107-83-5) Acetone (CAS 67-64-1) n-Hexane (CAS 110-54-3 Type STEL TWA STEL TWA US NIOSH: Pocket Guide to Chemical Hazards Components Type Acetone (CAS 67-64-1) TWA n-Hexane (CAS 110-54-3 TWA Propane (CAS 74-98-6) TWA US.
PAGE 5
Relative Density: Odor Threshold: Solubility(ies): pH: Partition Coefficient: Melting Point: Freezing Point: Auto-ignition Temperature: Flash Point: Decomposition Temperature: Evaporation Rate: Viscosity: Flammability (Solid/Gas): Specific Gravity: Upper/Lower Flammability: Vapor Pressure: Initial Boiling Point and boiling range: VOC (weight %): SECTION 10: Not determined Not determined Not determined Not determined Not determined Not determined Not determined Not determined > 156° F (-104.
PAGE 6
2.2 ml/kg Dimethyl Ether (CAS 115-10-6) Acute Inhalation NOEL Rat n-Hexane (CAS 110-54-3) 2 ppm, 6 Hours Acute Dermal LD50 Rabbit > 2000 mg/kg, 4 Hours > 5 ml/kg, 4 Hours Inhalation LC50 Rat > 5000 ppm, 24 Hours > 31.
PAGE 7
Category: Aquatic Crustacea Fish EC50 LC50 Species Water flea (Daphnia magna) Striped bass (Morone saxatillis) Test Results 4.3 - 7.8 mg/l, 48 hours 10.302 - 16.743 mg/l, 96 hours COMPONENT - n-Hexane (CAS 110-54-3) Category Fish LC50 Species Test Results Fathead minnow (Pimephales 2.101 - 2.981 mg/l, 96 hours promelas) * Estimates for product may be based on additional component data not shown. No data is available on the degradability of this product.
PAGE 8
This product meets the exception requirements of section 173.306 as a limited quantity and may be shipped as a limited quantity. Until 12/31/2020, the "Consumer Commodity - ORM-D" marking may still be used in place of the new limited quantity diamond mark for packages of UN 1950 Aerosols. Limited quantities require the limited quantity diamond mark on cartons after 12/31/20 and may be used now in place of the "Consumer Commodity ORM-D" marking.
PAGE 9
Ensure valve protection device (where provided) is correctly fitted. Ensure adequate ventilation. Ensure compliance with applicable regulations. SECTION 15: REGULATORY INFORMATION US federal regulations: This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D): CERCLA Hazardous Substance List (40 CFR 302.4): Not regulated. Acetone (CAS 67-64-1) Listed. n-Hexane (CAS 110-54-3) Listed.
PAGE 10
US. Pennsylvania Worker and Community Right-to-Know Law 2-Methylpentane (CAS 107-83-5) Acetone (CAS 67-64-1) Dimethyl Ether (CAS 115-10-6) n-Hexane (CAS 110-54-3) Propane (CAS 74-98-6) US. Rhode Island RTK Acetone (CAS 67-64-1) Dimethyl Ether (CAS 115-10-6) n-Hexane (CAS 110-54-3) Propane (CAS 74-98-6) US. California Proposition 65 WARNING: This product contains a chemical known to the State of California to cause cancer.