Instruction Manual

© 2007 Roberts-Gordon, LLC
All rights reserved. No part of this work covered by the copyrights herein may be reproduced
or copied in any form or by any means - graphic, electronic, or mechanical, including
photocopying, recording, taping or information storage and retrieval systems - without the
written permission of Roberts-Gordon, LLC.
TABLE OF CONTENTS
SECTION 1: Before You Begin ............................................... 1
1.1 Read This Manual ........................................................ 1
1.2 Questions, Comments or Suggestions......................... 1
SECTION 2: Heater Safety...................................................... 2
SECTION 3: Introduction........................................................3
3.1 About Roberts-Gordon ................................................ 3
3.2 About the Heater.......................................................... 3
3.3 Unpacking the Heater ..................................................3
3.4 Components Identification ........................................... 4
3.5 Where Can the Heater Be Installed? ........................... 5
3.6 Where Can't the Heater Be Installed?..........................5
3.7 Installer's Responsibility ..............................................5
SECTION 4: Before Using The Heater...................................6
4.1 System Requirements..................................................6
4.2 Gas Service Requirements:......................................... 6
4.3 Electrical Service Requirements..................................6
4.4 Venting Requirements.................................................. 7
4.5 Non-Residential Installations ....................................... 7
4.6 Heater Location ........................................................... 8
SECTION 5: Using The Heater ...............................................9
5.1 Required Safe Distances from Combustibles...............9
5.2 Protective Grille.......................................................... 13
5.3 Rear Movable Hanger Limits ..................................... 14
5.4 Operating Instructions................................................ 15
5.5 To Turn Off Gas To Heater ......................................... 15
5.6 Sequence of Operation.............................................. 16
5.7 Venting....................................................................... 16
SECTION 6: Caring For The Heater ..................................... 18
6.1 Annual Inspection ...................................................... 18
6.2 Monthly Inspection..................................................... 18
6.3 Maintenance Checklist............................................... 18
6.4 Basic Heater Care...................................................... 19
6.5 Replacement Parts .................................................... 19
SECTION 7: The ROBERTS GORDON
®
CARIBE
®
LIMITED
Warranty.............................................................21
Printed in the U.S.A.