Specification Sheet

ManualsBrandsRheem ManualsFurnaceRheem Classic Series: 80% AFUE R801S Downflow

Rheem Classic

Series

Downflow Gas Furnace

FORM NO. G11-547 REV. 1

R801S (Downflow) Series

80% A.F.U.E.†

Input Rates 50-150 kBTU

Air

Gas Furnaces

R801S (DF) Series

✝A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance with

Department of Energy test procedures.

• 80% residential Gas Furnace CSA certified

• PlusOne

™

Diagnostics — 7 Segment LED all units

• PlusOne

™

Ignition System – DSI for reliability and longevity

• Heat exchanger is removable for improved serviceability.

Aluminized steel construction provides maximum corrosion

resistance and thermal fatigue reliability.

• Low profile 34" cabinet ideal for space constrained

installations

• Integrated Control board features dip switches for easy

system set up

• QR code for quick access to product information from your

smart phone or tablet

Summary of content (12 pages)

PAGE 1
Air Gas Furnaces R801S (DF) Series Rheem Classic® Series Downflow Gas Furnace R801S (Downflow) Series 80% A.F.U.E.† Input Rates 50-150 kBTU ✝ A.F.U.E. (Annual Fuel Utilization Efficiency) calculated in accordance with Department of Energy test procedures. • • • • 80% residential Gas Furnace CSA certified PlusOne™ Diagnostics — 7 Segment LED all units PlusOne™ Ignition System – DSI for reliability and longevity Heat exchanger is removable for improved serviceability.
PAGE 2
Air Table of Contents R801S (DF) Series TABLE OF CONTENTS Standard & Optional Equipment ......................................................................3 Model Features/Physical Data & Specifications..................................................4 Model Number Identification ............................................................................5 Dimensional Data............................................................................................6 Blower Performance Data .............
PAGE 3
Air Standard & Optional Equipment R801S (DF) Series HEAT EXCHANGER INTEGRATED FURNACE CONTROL DRAFT INDUCER MOTOR DIRECT SPARK IGNITOR WITH REMOTE SENSE IN-SHOT BURNERS STANDARD EQUIPMENT OPTIONAL EQUIPMENT Completely assembled and wired; induced draft; pressure switch; redundant main gas control; blower compartment door safety switch; solid state time on/time off blower control; limit control; manual shut-off valve, pressure regulator for natural and L.P.
PAGE 4
Air Model Features/Physical Data & Specifications R801S (DF) Series Model Features • • • • 80% residential Gas Furnace CSA certified PlusOne™ Diagnostics — 7 Segment LED all units PlusOne™ Ignition System – DSI for reliability and longevity Heat exchanger is removable for improved serviceability. Aluminized steel construction provides maximum corrosion resistance and thermal fatigue reliability.
PAGE 5
Air Model Number Identification R801S (DF) Series Model Number Identification—Downflow Models R 80 Rheem 80 = 80% AFUE 1 S A 1 = Single Stage S = Standard Design Series PSC A = 1st Design 075 Input BTU/HR [kW] 050 = 50,000 [15] 075 = 75,000 [22] 100 = 100,000 [29] 125 = 125,000 [37] 150 = 150,000 [44] 4 3 = Up to 3 Ton 4 = Up to 4 Ton 5 = Up to 5 Ton 17 Z S A Cabinet Width 14 = 14".0 17 = 17.5" 21 = 21".0 24 = 24.
PAGE 6
Air Dimensional Data R801S (DF) Series Downflow Dimensions Dimensions and Clearance to Combustible Material (inches) [mm] MODEL R801S (DOWNFLOW) SERIES 050 075 100317 100421 100521 125 150 REDUCED CLEARANCES (IN.) [mm] A B C D E LEFT SIDE RIGHT SIDE BACK TOP FRONT VENT SHIP. WGTS. (LBS.
PAGE 7
Air Blower Performance Data R801S (DF) Series Blower Performance Data—Downflow Models MODEL R801S BLOWER SIZE [mm] MOTOR H.P.
PAGE 8
Air Accessories R801S (DF) Series DOWNFLOW ACCESSORIES DOWNFLOW WARNING: Unit design is certified for installation on non-combustible floor. A special factory supplied combustible floor sub-base is required when installing on a combustible floor. Failure to install the sub-base may result in fire, property damage and personal injury.
PAGE 9
Air Limited Warranty R801S (DF) Series GENERAL TERMS OF LIMITED WARRANTY* Rheem will furnish a replacement for any part of this product which fails in normal use and service within the applicable period stated, in accordance with the terms of the limited warranty. Heat Exchanger ......................................Twenty (20) Years Conditional Parts (Registration Required) ........
PAGE 10
Air 10 Notes R801S (DF) Series
PAGE 11
Air Notes R801S (DF) Series 11
PAGE 12
The new degree of comfort.™ In keeping with its policy of continuous progress and product improvement, Rheem reserves the right to make changes without notice. Rheem Heating, Cooling & Water Heating • P.O. Box 17010 Fort Smith, Arkansas 72917 • www.rheem.com Rheem Canada Ltd./Ltée • 125 Edgeware Road, Unit 1 Brampton, Ontario • L6Y 0P5 PRINTED IN U.S.A 7/14 QG FORM NO. G11-547 REV.