Specifications

TM031 Integrity 24L Service Instructions REV: A
D.O.I: 30/10/2007
This document is stored and maintained electronically by Service. All printed copies not bearing this statement in RED are deemed “uncontrolled”
75
Replacement Parts List Exploded View 6 - 871024-C & 875024-C Models
Fitted with solenoid operated bypass
Item No Description 875024-C 871024-C
133 Silicone Tube (Insulator) 20-43376-00
134 Silicone Tube (Insulator) 20-43376-00
705 Anti-Frost Heater (Heater A) 31-71644-00
706 Anti-Frost Heater Assembly (Heater B) 31-71643-00
708 Anti-Frost Heater Clamp WH0020049
710 Anti-Frost Heater “C” Clamp (for Heater A) WH0020050
711 Anti-Frost Heater Clamp (for Heater B) WH0020051
712 Ambient Air Temp Thermistor Assembly N/A use *31-76655-00
713 Outlet Thermistor (Thermistor B) *20-64774-00
714 Anti Frost Thermostat Assembly 20-57072-00
715 Heat Exchanger (HX) Thermistor N/A use *31-76655-00
716 O-ring – Thermistor WH0020055
717 Inlet Thermistor (Thermistor A) *20-64773-00
723 Hall Effect I.C. Assembly *20-43805-00
728 Combustion Fan WH0020057
729 Fan Case Assembly 10-88629-00
735 Ignition Pack 31-76722-00
737 Flame Sensor Loom 31-76721-00
745 PCB Assembly 31-76623-0S
Gas Type Connector - NG 31-76594-00 31-76592-00
751
Gas Type Connector - LP 31-76593-00 31-76591-00
757 100 volt loom 31-76653-00
758 Signal Loom (inc amb air & HX thermistor) *31-76655-00
768 Terminal Block Assembly WH0020068
771 Noise filter holder assembly 31-23360-00
773 Power filter *31-71642-00
775 Fuse – In line Note: PCB fuses not fitted WH0020069
780 Power Cord With Clamp *31-76652-00
781 Clamp – Power Cord WH0020072
783 240 -110 Volt Transformer Assembly *31-71646-00
784 Connecting cord *31-71641-00
Lower Burner Assy 31-76241-00
Gas Type Connector 31-76594-00 31-76592-00
Nozzle Plate 31-76238-00
Not Shown
Gas Conversion
- LP to NG
Nozzle Plate Bind Screw
(3 required)
09-46131-00
Lower Burner Assy 31-76240-00
Not Shown
Gas Conversion
- NG to LP
Gas Type Connector 31-76593-00 31-76591-00
*When installed in 871024 & 875024 model heaters these parts will require the replacement of
other interconnecting components. Refer to ‘Product Changes’ on page
10 and ‘Parts
Replacement Scenarios’ on page
11 for more information.
Note: For controller and controller cable part numbers refer to page 20.