User manual

General Operating Information
Important!
 Themotorcontainedinthesetisonlysuitableforoperationwitha2-cellLiPobattery(nominal
voltage7.4V)ora4-to6-cellNiMHbattery(nominalvoltage4.8-7.2V).
 Ifyouconnectabatterywithmorecellstothespeedcontroller,thespeedcontrollerand/orthe
motorwillbedamaged.Thewarrantywillbevoid!
 Ifyouconnectadifferentmotorthatissuitableformorecellstothespeedcontroller,always
payattentiontotheturnsofthemotor;seetable.Furthermore,youmustreplacethefanonthe
speedcontrolleragainstanotherversionthatcanfunctionwithhighervoltages.Non-adherence
willcausedamagetothefanand/orspeedcontroller!Thewarrantywillbevoid!
• Whenthespeedcontrollerisswitchedon,thegreenLEDashescorrespondingtothenumberofcellsof
theconnectedLiPobattery(e.g.,2-cellLiPobattery=2xashes).Asoundsignalisemittedasoftenas
theLEDashes.ThespeedcontrollerisreadyforoperationwhennoneoftheLEDsashesafterwards.
• Ifthespeedcontrollerdetectsanunusualvoltageafterswitchingon,itwillemitacorrespondingwarning
sound(2beeps,1secondpause,2beeps,1secondpause,etc.).
Inthis case, check the battery (voltage, charge) and the plug connection between battery and speed
controller.
• Ifthespeedcontrollerdetectsanerroneouscontrolsignalfromthereceiverafterswitchingon,itwillemita
correspondingwarningsound(1beep,2secondpause,1beep,2secondpause,etc.).
Checkthetrimofthethrottleleverorleavethethrottleleverinthemiddleposition(idleposition)when
switchingonthespeedcontroller.
• TheredLEDashesduringforwardsandreversemovementsorforthecorrespondingcontrolsignalofthe
transmitter.ThegreenLEDisalsoonwhendrivingforwardsat100%throttle.
If100%brakeeffectissetinmenuitem5,thegreenLEDalsoashesbriey.
• Whenchangingbetweenforwardsandreverse,thethrottlemustbeputbrieyintotheneutralposition
(about2seconds).Ifthethrottleisshifteddirectlyfromforwardstoreverse,thespeedcontroller'sbrake
willbeactivated(thevehiclewillNOTgobackwards!).
• Ifthedriveorbrakefunctionisoppositetothemovementofthethrottleleveratthetransmitter,activatethe
reversefunctionatthetransmitterorswapanytwoofthethreemotorcables.
• Ifthespeedcontrollerisusedwitha3-cellLiPobattery(or7-to9-cellNiMHbattery),thefactory-tted
fanmustbereplacedbyahigh-voltagetype(seeoptionalaccessoriesontheproductwebpage).Non-
adherencewillcausedamagetothefanand/orspeedcontroller!Thewarrantywillbevoid!
• Thefunctionofthefanmustbecheckedbeforeandaftereachdrive.Thisappliesinparticularwhenthe
vehiclecameincontactwithwater.Ifindoubt,thefanmustbedismountedandcleaned.
• Thespeedcontrollerswitchesoffthemotorforsafetyreasons,ifitgetstoohot.Inthiscase,stopdriving
andchecke.g.,thegeartransmissionandthefunctionofthefanonthespeedcontroller.
• Ifthespeedcontrollerdoesnotdetectarotationspeedsignalforlongerthan0.2secondsduringdriving,
themotorisswitchedoff.Inthiscase,checkthepositionofthereceiverantenna,theconnectionbetween
speedcontrollerandtransmitterandthetransmitterbatteries.
Ending the Operation
Firstswitchoffthecontrolunit(bringswitchintothe"OFF"position).Then,disconnectthebatteryfromthe
speedcontroller.Onlynowdoyouturnoffthetransmitter.
Disposal
 Electronicdevicesarerecyclablematerialanddonotbelonginthehouseholdwaste.Disposeof
anunserviceableproductinaccordancewiththerelevantstatutoryregulations.
Technical Data
Important!
 Themotorcontainedinthesetisonlysuitableforoperationwitha2-cellLiPobattery(nominal
voltage7.4V)ora4-to6-cellNiMHbattery(nominalvoltage4.8-7.2V).
 Ifyouconnectabatterywithmorecellstothespeedcontroller,thespeedcontrollerand/orthe
motorwillbedamaged.Thewarrantywillbevoid!
 Ifyouconnectadifferentmotor(suitableformorecells)tothespeedcontroller,alwayspayat-
tentiontotheturnsofthemotor;seetable.Furthermore,youmustreplacethefanonthespeed
controlleragainstanotherversionthatcanfunctionwithhighervoltages.Non-adherencewill
causedamagetothefanand/orspeedcontroller!Thewarrantywillbevoid!
a) Speed controller
NumberofcellsNiMH 4-9(however,themotorcontainedinthesetisonlysuitablefor
4-6cells,seenoteabove)
NumberofcellsLiPo 2-3(however,themotorcontainedinthesetisonlysuitablefor
2cells,seenoteabove)
Low-voltagedetectionLiPo 2.6V/2.8V/3.0V/3.2V/3.4Vpercell/canbeswitchedoff
Continuouscurrent(max.5min.) 60A
Current(max.1sec.) 390A
SBEC(timed) 6V/DC,3A
Fan suitableupto2SLiPo(or6cellsNiMH)
over-temperatureswitch-off yes
Min.turnsat2S+onroad ≥5.5turns
Min.turnsat3S+onroad ≥8.5turns
Min.turnsat2S+offroad ≥9turns
Min.turnsat3S+offroad ≥13turns
Suitablemotorsize 3650/3660
Plug-systemformotor 4mmgoldcontact
Plug-systemforreceiver JR
Dimensions(LxWxH) 48.5x38x32mm
Weightwithcableapprox. 90g
b) Motor
Itemno. 1456606 1456607
NumberofcellsNiMH 4-6 4-6
NumberofcellsLiPo 2 2
Momentarycurrentat2S 60A 46A
Consumption max.440W max.340W
Revolutionspervolt(KV) 3700 4000
Numberofpoles 4 4
Numberofturns 9 8
Plug-systemfor 4mmgoldcontact 4mmgoldcontact
Shaftdiameter 5mm 3.175mm
Usableshaftlength approx.18mm approx.14mm
Dimensions(WxL) 36x60mm 36x52mm
Weightwithcableapprox. 252g 207g
ThisisapublicationbyConradElectronicSE,Klaus-Conrad-Str.1,D-92240Hirschau(www.conrad.com).
Allrightsincludingtranslationreserved.Reproductionbyanymethod,e.g.photocopy,microlming,orthecaptureinelectronicdataprocessing
systemsrequirethepriorwrittenapprovalbytheeditor.Reprinting,alsoinpart,isprohibited.Thispublicationrepresentthetechnicalstatusat
thetimeofprinting.
©Copyright2016byConradElectronicSE. 1456606_07_V1_0816_02_VTP_m_en