Recommended Tools Hex Drivers (1.5mm, 2mm, 2.5mm) Cross Wrench Side Cutter Pliers Plastic cement/glue Modeling/Craft knife (non-whitening CA glue) Thread Lock Long Nose Pliers Tips for Assembly Use a good quality hex drivers to avoid stripping screw heads. Use thread lock when putting metal screws into metal parts. Use thread lock sparingly. Do not over tighten screws otherwise you may strip the thread.
RC4WD Limited Warranty All RC4WD products are warranted to be free of defects in materials and workmanship when new. Our limited warranty does not cover damages due to normal wear and tear, user error of assembly or installation, user modifications, user's failure to perform routine maintenance, addition of aftermarket parts or option parts. This warranty lasts 30 days after arrival for original purchaser.
Countersunk Flat Head Spacer Screw Z-S0648 M3X6 2X Z-S0649 M3X8 7X Z-S0860 M3X10 4X Z-S0746 M3X14 6X Z-S0809 1mm 2X Z-S0600 2mm 2X Z-S0806 3mm 4X Z-S0821 5mm 1X Z-S0629 M3 5X Z-S1265 M4 4X Set Screw Z-S0125 M3X5 2X Z-S0308 M3X10 6X Z-S0650 M3X15 14X Nut Z-S0804 M3 Driveshaft Screw Pin 4X Z-S0303 3 M2.
Button Head Screw Z-S0764 M2.5X6 Z-S0651 M3X6 Z-S0652 M3X8 Z-S0653 Cap Head Screw Z-S1253 M1.6X5 14X Z-S1255 M1.6X8 4X 19X Z-S1175 M1.6X10 4X M3X10 41X Z-S0593 M2X12 6X Z-S0654 M3X12 17X Z-S0855 M2.5X6 4X Z-S0655 M3X14 10X Z-S0829 M2.5X8 20X Z-S0656 M3X16 5X Z-S1380 M2.
Axle Z-S0794 2X Z-S0795 Z-A0080 Z-A0081 5
Connecting Rods Z-S0399 10X Z-S0807 Z-S0402 4X Z-S0398 4X Z-S0817 2X Z-S0819 Z-S0401 2X 2X Z-S0810 Z-S0805 4X Transmission Z-S0802 Z-U0028 Z-S0430 6
Chassis Z-C0040 Accessories 2X Z-S0792 2X 2X 2X Z-S1379 7 Z-B0016 4X
Accessories Z-S0042 2X Z--S0791 Z-S1381 Z-S1383 8
Accessories Z-S0592 Transfer Case Z-U0024 Z-U0027 Z-S0803 Driveshafts 2X Z-S0583 2X Z-S0443 4X Shock hoop Z-S0798 2X Z-S0799 9
Shock Z-D0039 4X Wheel Z-W0129 Tire Z-T0005 4X 10
Body 1 2 Z-B0061 Z-B0065 11
Body Z-B0079 Z-B0063 12
Body 1 8 7 6 2 9 5 3 4 Z-B0069 13 10
Body 4 1 3 2 Z-B0067 14
Body 1 6 5 2 3 4 Z-B0073 15
Body 16 2 1 15 3 14 4 6 5 7 13 12 9 10 8 11 Z-B0071 16
Body 1 2 16 6 12 17 3 7 8 4 13 9 18 14 11 10 5 15 19 20 21 22 Z-B0075 17 23 24
Body 1 2 5 3 13 6 7 4 8 10 9 11 12 Z-B0077 18
Body Z-B0083 Z-B0081 19
Assembly 1 Thread Lock Z-S0648 All the hardware should be taken from Bag L Parts can be found in Metal Parts Bag F M3X8 Z-S0794 Assembly 2 Thread Lock Z-S0652 M3x8 Z-A0080 Assembly 3 Thread Lock Z-S0795 Z-S0860 M3x10 Z-A0081 20
Assembly 4 Thread Lock Z-S0795 Z-S0655 M3X14 Assembly 5 Z-S0650 M3X15 Plastic parts can be found in parts Bag G Z-S0399 Z-S0402 Z-S0399 Assembly 6 Z-S0308 M3X10 Z-S0398 Z-S0401 21
Assembly 7 Thread Lock Z-U0028 Z-S0652 M3X8 Z-S0802 Assembly 8 Thread Lock Z-S0649 M3X8 Z-S0802 22
Assembly 9 Thread Lock Z-S0652 M3X8 Z-S0792 Assembly 10 Thread Lock Z-S1379 Z-S0652 M3X8 Z-B0016 Z-S1379 Z-S1379 Assembly 11 Thread Lock This step should be done on both frame rails Z-S0953 M2X12 Z-S0654 M3X12 Z-C0040 M2X12 23
Assembly 12 Thread Lock Z-C0040 Z-S0953 Note: This kit does not included inner fenders. Direction shown for example.
Assembly 15 Thread Lock Z-S0653 M3X10 Thread Lock Assembly 16 Z-S0653 M3X10 Z-S0654 M3X12 Z-S0953 Z-C0040 M2X12 Assembly 17 Thread Lock Z-S0652 M3X8 Z-S1381 25 M2X12 M3X12
Assembly 18 Thread Lock Z-S0653 M3X10 Z-S0798 Z-S0798 Assembly 19 Thread Lock Z-S0653 M3X10 Z-S0799 Z-S0799 26
Assembly 20 Thread Lock Z-S0791 Z-S0652 M3X8 Z-S0652 M3X8 Assembly 21 Thread Lock Z-S0653 M3X10 Z-S0794 27
Assembly 22 Thread Lock Z-S0804 M3 Drivehaft Screw Pin Z-S0803 Assembly 23 Z-U0024 28
Assembly 24 Thread Lock Z-S0651 M3X6 Z-S0653 M3X10 Assembly 25 Thread Lock Z-S0804 M3 Drivehaft Screw Pin 29
Assembly 26 Z-S1175 Z-B0077-11&12 M1.6X10 Z-B0075-2 Z-B0077-9&10 Z-S1253 Z-B0075-3 Z-B0075-4&5 M1.6X5 Z-S1381 M1.
Assembly 28 Thread Lock Z-S1255 M1.
Z-S0739 M3X25 Assembly 30 Z-S0629 M3 Nut 65.
Assembly 32 Thread Lock Z-S0653 M3X10 Z-S0655 M3X14 Z-S0656 M3X10 Assembly 33 M3X16 Z-S0629 M3 Nut Z-S0806 3mm Spacer 3mm Spacer 33
Thread Lock Assembly 34 Z-S0654 M3X12 59mm Link Assembly 35 Thread Lock Z-S0655 M3X14 73mm Links 34
Assembly 36 Thread Lock Z-S0654 M3X12 Z-D0039 2mm Spacer Assembly 37 Thread Lock Z-S0654 M3X12 1mm Spacer 35
Assembly 38 Thread Lock Z-S0653 M3X10 Z-S0655 M3X14 M3X10 Assembly 39 Thread Lock Z-S0656 M3X16 Z-S0629 M3 Nut Z-S0806 3mm Spacer 3mm Spacer 36
Assembly 40 Thread Lock Z-S0654 M3X12 70mm Link Assembly 41 Fit drive shaft rings Z-S0443 Z-S0583 37
Assembly 42 Thread Lock Fit both front and rear drive shafts Z-S0804 M3 Driveshaft Screw Pin Assembly 43 Thread Lock Z-S0125 M3X5 38
Assembly 44 Thread Lock Z-S0649 M3X8 Assembly 45 Thread Lock Z-S0592 Z-S0860 M3X10 39
Z-S0651 M3X6 Assembly 46 Z-S0592 Assembly 47 Thread Lock Note:Servo and servo horn are not included in this kit.
Assembly 48 Thread Lock Z-S0651 M3X6 Assembly 49 Thread Lock Z-S0656 M3X16 Z-S0821 5mm Spacer 5mm Spacer 41
Assembly 50 Insert the ring inside the tire 42
Assembly 51 Place the rear wheel half inside the ring Ensure that the tire bead is evenly captured in the wheel rim. The tire may need to be pulled out a little to make it sit properly.
Assembly 52 Place the front wheel half inside the ring. Ensure that the wheel design is aligned front and rear. Ensure that the tire bead is evenly captured in the wheel rim. The tire may need to be pulled out a little to make it sit properly.
Z-S1380 Assembly 53 M2.5x12 Place the wheel hub on the rear of the wheel and insert a long bolt (M2.5 x 12mm) through the wheel Z-S0303 M2.5 Nut Ensure that the tire bead is evenly captured in the wheel rim. The tire may need to be pulled out a little to make it sit properly.
Z-S1380 M2.5X12 Z-S0303 Assembly 54 Place the wheel hub on the rear of the wheel and insert a long bolt (M2.5 x 12mm) through the wheel M2.5 Nut Assembly 55 Z-S0829 M2.5X8 Z-S0303 Fit all of the remaining bolts and nuts. Swap the long bolt that was fitted for the shorter bolt M2.
Assembly 56 2mm Pin Fit all four wheels Assembly 57 Z-S1265 M4 Nut 47
Assembly 58 Z-S1383 Z-S1383 Assembly 59 Z-S0125 M3X5 Note: Motor is not included in this kit.
Z-S0651 Assembly 60 M3X6 Assembly 61 Note: Battery, ESC and Receiver are not included.
Assembly 62 Note: Use Heavy Duty Nylon for Strap Lock to stable the Battery.
Assembly 64 Z-S1253 M1.
Assembly 66 Z-S0651 M3X6 Z-B0061 Assembly 67 Z-B0075-21&22 Z-B0077-3&4 52
Assembly 68 Z-S0083 M5X6.
Assembly 70 Z-S1253 M1.
Assembly 72 Plastic cement/glue Z-B0071-15&16 Z-B0071-2&3 Assembly 73 Plastic cement/glue Z-B0071-6&7 55
Assembly 74 Plastic cement/glue Z-B0075-6&7 Assembly 75 Plastic Z-B0067-2 cement/glue Z-B0077-13 56
Assembly 76 Plastic cement/glue Z-B0071-12&13 Z-S0651 M3X6 Assembly 77 57
Z-S0653 M3X10 Assembly 78 Z-B0065 Z-B0079 Assembly 79 Plastic cement/glue Z-B0075-18 58
Z-S0653 M3X10 Assembly 80 Assembly 81 Plastic Z-B0063 cement/glue Z-B0071-14 Z-B0071-10 Z-B0071-11 59
Assembly 82 Z-S0764 M2.
Assembly 84 Plastic cement/glue Z-B0067-3 Assembly 85 Z-S0653 M3X10 61
Assembly 86 Plastic Z-B0069-8 cement/glue Z-B0069-10 Assembly 87 Z-B0069-1 Z-B0069-3 Z-B0069-2 Z-B0069-4 62
Assembly 88 Plastic cement/glue Assembly 89 Z-B0069-7&9 Plastic cement/glue 63
Assembly 90 Plastic Z-B0071-1 cement/glue Assembly 91 Z-B0061-1 Plastic cement/glue 64
Assembly 92 Z-B0073-1&2 Z-B0069-5&6 Assembly 93 Plastic cement/glue 65
Z-S0654 M3X12 Assembly 94 Z-B0073-5 Z-S0653 M3X10 Assembly 95 66 Z-B0073-3&4
Z-S0652 Assembly 96 M3X8 Z-S0593 M2.
Spare Parts Z-A0080 Z-A0081 Z-S0792 Z-S0793 Z-S0794 Z-S0795 Z-C0040 Z-U0027 Z-S0798 Z-S0799 Z-S0802 Z-U0028 Z-S0803 Z-S0804 Z-S0809 Z-S0806 Z-S0821 Z-D0039 Z-S0807 Z-S0817 Z-S0805 Z-S0819 Z-S0810 Z-W0129 Z-T0005 Z-S0592 Z-S0583 Z-S0443 Z-S0399 Z-S0402 Z-S0398 Z-S0401 Z-U0024 Yota2 Front Axle Yota2 Rear Axle G2 Battery Deck G2 Electronics Deck G2 Front 3 Link + Panhard Mount G2 Rear 4 Link Mount G2 Chassis Set G2 Tcase Mount G2 Front Shock Hoops G2 Rear Shock Hoops R3 Single Speed Mounts R3 Single Speed Tra
Recommended Equipment Z-E0032 Z-E0007 Z-E0004 Z-S0820 Z-S0822 Z-R0006 Z-E0552 Twister High Performance Waterproof Servo Electronic Speed Controller(ESC) 540 Crawler Brushed Motor G2 24T Servo Horn G2 25T Servo Horn XR4 4-Channel 2.4Ghz Transmitter/Receiver Radio Heavy Duty Nylon for Strap Lick Optional Parts Z-S0734 1.9" 5 Lug Steel Wheel Hex Hub Z-S0532 1.9 5 Lug Steel Wheel Hex Hub with Brake Rotor Z-W0008 Land Rover Disco Freestyle 1.9" Wheels Z-W0037 Land Rover Disco Freestyle 1.
70
