SDS

MSDS - Page 4 of 6
RJS
RJS
RJS
RJS STANDARDS
STANDARDS
STANDARDS
STANDARDS TESTING
TESTING
TESTING
TESTING &
&
&
& CERTIFICATION
CERTIFICATION
CERTIFICATION
CERTIFICATION CENTER
CENTER
CENTER
CENTER
141-04 14th Avenue, Whitestone, N ew York 11357 , USA.
NIOSH
NIOSH
NIOSH
NIOSH -
-
-
- REL 1 . 0mg/m
3
Respiratory
Respiratory
Respiratory
Respiratory Protection
Protection
Protection
Protection (Specify
(Specify
(Specify
(Specify Type)
Type)
Type)
Type) :
:
:
:
Provide general dilution ventilation to keep exposure to vapors as low as possible. Can wear the mask for
organic solvent when get in touch with high density of vapor.
Ventilation
Ventilation
Ventilation
Ventilation :
:
:
:
LOCAL EXHAUST: Good general ventilation should be used. Use local exhaust ventilation as needed so that
exposure limits are met .
MECHANICAL (GENERAL): Provide general ventilation in possessing and storage areas so that exposure limits
are met .
Engineering
Engineering
Engineering
Engineering Controls:
Controls:
Controls:
Controls: General room ventilation is sufficient during normal use and handling. Do not install
these batteries in sealed, unventilated areas.
Personal
Personal
Personal
Personal Protective
Protective
Protective
Protective Equipment
Equipment
Equipment
Equipment (In
(In
(In
(In the
the
the
the Event
Event
Event
Event of
of
of
of Battery
Battery
Battery
Battery Case
Case
Case
Case Breakage):
Breakage):
Breakage):
Breakage):
Hand
Hand
Hand
Hand protection:
protection:
protection:
protection: R ubber or neoprene gloves.
Skin
Skin
Skin
Skin and
and
and
and Body
Body
Body
Body Protection:
Protection:
Protection:
Protection: Wear acid resistant boots, apron or clothing . Use decontamination facilities ( eye
bath, safety shower, washing facilities ) .
Protective
Protective
Protective
Protective Gloves:
Gloves:
Gloves:
Gloves: Rubber or neoprene gloves.
Eye
Eye
Eye
Eye Protection
Protection
Protection
Protection :
:
:
: Safety glasses with side shields and avoid eye contact.
Other
Other
Other
Other Protective
Protective
Protective
Protective Clothing
Clothing
Clothing
Clothing or
or
or
or Equipment
Equipment
Equipment
Equipment :
:
:
: Protective clothing is required where repeated or prolonged skin
contact may occur.
Work/Hygienic
Work/Hygienic
Work/Hygienic
Work/Hygienic Practices:
Practices:
Practices:
Practices: Remove jewelry, rings, watches and any other metallic objects while working on
batteries. All tools should insulate to avoid the possibility of shorting connections. DO NOT lay tools on top of
battery. Be sure to electricity from tools and individual person by touching a grounded surface in the vicinity of
the batteries, but are heavy. Serious injury can result from improper lifting or installation. DO NOT lift, carry,
install or remove pulling the terminal posts for safety reasons and because terminal posts and post seals may be
damaged. DO KEEP a fire extinguisher and emergency communications the work area.
General
General
General
General Physical
Physical
Physical
Physical Form:
Form:
Form:
Form: The battery is s olid. Sulfuric Acid is a liquid.
Odor:
Odor:
Odor:
Odor: The battery is odorless.
Solubility
Solubility
Solubility
Solubility in
in
in
in Water:
Water:
Water:
Water: Lead, Lead Oxide and Lead Sulfate are insoluble in water. Sulfuric Acid is 100% soluble in
water.
Stability:
Stability:
Stability:
Stability: Stable under normal conditions.
Conditions
Conditions
Conditions
Conditions to
to
to
to Avoid:
Avoid:
Avoid:
Avoid: Sparks and other sources of ignition. Prolonged overcharge. Fire or explosion hazard due
to possible hydrogen gas generation.
SECTION
SECTION
SECTION
SECTION 9
9
9
9 -
-
-
- PHYSICAL
PHYSICAL
PHYSICAL
PHYSICAL AND
AND
AND
AND CHEMICAL
CHEMICAL
CHEMICAL
CHEMICAL PROPERTIES
PROPERTIES
PROPERTIES
PROPERTIES
SECTION
SECTION
SECTION
SECTION 10
10
10
10 -
-
-
- STABILITY
STABILITY
STABILITY
STABILITY AND
AND
AND
AND REACTIVITY
REACTIVITY
REACTIVITY
REACTIVITY