Operating instructions

ManualsBrandsRasmussen ManualsDomestic AppliancesYellow Flame

AGA YF 99

AGA "YELLOW FLAME"

12028 E. Philadelphia St. Whittier , CA 90601 U.S.A.

(562) 696-8718 FAX (562) 698-3510

E-Mail: gaslogs@riwinc.com Web http://www.riwinc.com

APPROVED

A s s e m b l y , I n s t a l l a t i o n , a n d O p e r a t i o n

I n s t r u c t i o n s f o r R a s m u s s e n " Y E L L O W F L A M E "

Natural and Propane Hearth Kit Models:

A18 Manual/Switch/Remote Control: (XF,PR,WS,LS 18)(EXF,ELS,EC 20)

(XF,WS,LS 21)-A18-M,S,R-(N,L)

A24 Manual/Switch/Remote Control: (EXF,XF,PR,WS,ELS,LS,EC 24)-

A24-M,S,R-(N,L)

A30 Manual/Switch/Remote Control: (EXF,XF,PR,WS,ELS,LS,EC 30)(PR 36)-

A30-M,S,R-(N,L)

THIS BURNER IS FOR USE FOR USE IN A FULLY

FUNCTIONING WOOD BURNING FIREPLACE

WITH THE DAMPER WIDE OPEN.

THE FLUE MUST VENT ALL PRODUCTS OF COMBUSTION.

THESE INSTRUCTIONS CONFORM TO ANSI Z21.60-1996/CGA 2.26-M96

WARNING: If the information in this manual is not followed exactly, a fire or explosion may result

causing property damage, personal injury or loss of life.

WARNING:

Improper installation, adjustment,

alteration, service or maintenance can cause

property damage, personal injury or loss of life. Read

these instructions thoroughly before installation. For

assistance or additional information, consult your

gas log dealer, qualified installer, service agency or

gas supplier.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use

any phone in your building.

• Immediately call your gas supplier from a

neighbors phone. Follow the gas supplier's

instructions.

• If you cannot reach your gas supplier,

call the fire department.

FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors

and liquids in the vicinity of this or any other appliance.

INSTALLATION AND SERVICE: Installation and service must be performed

by a qualified installer, service agency or the gas supplier.

IMPORTANT INFORMATION

1. This gas log set must be installed only in a solid-fuel burning fireplace with a working flue and constructed of non

combustible material. The flue must exhaust all products of combustion.

2. The minimum permanent free opening of the fireplace chimney or chimney damper must be at least (*Square

Inches - see ITEM 5 below) based on a minimum chimney height of at least 10 feet. The area of the flue must not

be less than 1/10 the area of the fireplace opening.

3. Solid fuels shall not be burned in a fireplace where a decorative appliance is installed.

4. The chimney damper must be fixed in a manner to maintain permanent free opening as outlined in item 2 above at

all times. To accomplish this, install the damper clamp (provided) on the edge of the damper blade to prevent its

closing or drill a hole or holes in the damper.

Summary of content (8 pages)

PAGE 1
AGA YF 99 AGA "YELLOW FLAME" 12028 E. Philadelphia St. Whittier , CA 90601 U.S.A. (562) 696-8718 FAX (562) 698-3510 E-Mail: gaslogs@riwinc.com Web http://www.riwinc.
PAGE 2
IMPORTANT INFORMATION (Continued) 5. The minimum size (in inches) of the fireplace in which the log set is to be installed must be as follows: *MINIMUM LOG CHIMNEY MODEL NO. SIZE HEIGHT DEPTH WIDTH OPENING A-18 18/20/21 INCH 18 16 30 39 SQ IN A-24 24 INCH 18 16 36 51 SQ IN A-30 30/36 INCH 18 16 42 64 SQ IN 6. A fire place screen must be in place when the log set is in operation and, unless other provisions for combustion air are provided, the screen shall have opening(s) for introduction of combustion air.
PAGE 3
ASSEMBLY AND INSTALLATION ATTENTION THIS LOG SET I S FOR USE ONLY WITH THE GAS TYPE INDICATED ON THE RATING PLATE. READ INSTRUCTIONS CAREFULLY BEFORE ASSEMBLY REQUIRED TOOLS AND MATERIALS: Screw Driver, Adjustable Wrench, Pipe Wrench, Pipe Sealing Compound, Matches. PREPARATION: 1. This Gas Log set must be INSTALLED IN A FULLY V E N T E D METAL OR MASONRY FIREPLACE WITH A WORKING FLUE THAT IS SAFE FOR BURNING A WOOD FIRE. The Flue MUST BE FREE OF ANY OBSTRUCTIONS. 2.
PAGE 4
LOG LOCATION: Depending on the log style and size, log sets contain from 6 to 10 individual logs and pine cones. The largest logs will be either the rear log or front log (NOTE: EXF, E L S and E C have two separate front logs which simulate a charred effect burnt between the two halves). The large top logs are placed on the front and rear logs with the larger top logs going on first.
PAGE 5
SWITCH OR REMOTE LIGHTING AND OPERATING INSTRUCTIONS: CONTROL SELECTOR SWITCH PILOT LIGHTING (Switch or Remote) 1. Place the Control Selector Switch in the O F F position (see Figure 8). Accessory Controls must also be turned "OFF". For units equipped with Remote Control, place the Remote Receiver Switch in the "OFF" position (see Figure 11). For Thermostat Controlled models, turn temperature dial to "OFF" or the lowest temperature setting. 2. Slightly push in Valve Knob and turn clockwise to "OFF".
PAGE 6
OPERATING ACCESSORY CONTROL (Switch Model On-Off Function with Accessory Control-Remote Control, Wall Switch, Wall Thermostat or Wall Timer): Place manual switch in the "REMOTE ACCESS ON" position (see Figure 8). Burner "ON" or "O F F" is now controlled by the status of the accessory control being used with the burner. Individual operating instructions for each Accessory Option are included with the individual accessory.
PAGE 7
HOW TO ORDER PARTS: CONSUMER RECORD CARD Parts can be ordered through the supplier from whom you purchased your YELLOW FLAME HEARTH KIT. When ordering parts, always specify (From information available on name plate attached to grate) the following: 1. Model number of the BURNER. 2. Serial number of the BURNER. 3. Type of gas (natural or propane Gas). 4. The name of the part and part number from parts list. Save these instructions Manufactured By: RASMUSSEN IRON WORKS, INC. 12028 E.
PAGE 8
LIMITED LIFETIME CONSUMER PRODUCT WARRANTY The following warranty has been drafted to comply with the MAGNUSON-MOSS WARRANTY ACT applicable to products manufactured after July 4, 1975. It replaces and supersedes any warranty in this package or in any printed literature. LIMITED WARRANTY: RASMUSSEN IRON WORKS INC, 12028 E. Philadelphia Street, Whittier California, U.S.A..