Safety Data Sheet 1 IDENTIFICATION Product identifier Rapid Set Waterproofing Mortar Other means of identification 144010050 Product code Recommended use Industrial use Recommended restrictions Workers (and your customers or users in the case of resale) should be informed of the potential presence of respirable dust, and respirable crystalline silica as well as their potential hazards.
Hazard statement Causes skin irritation. Causes serious eye damage. May cause cancer. May cause respiratory irritation. May cause damage to organs (Lungs) through prolonged or repeated exposure. Precautionary statement Prevention Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Do not breathe dust. Wash thoroughly after handling. Use in a well-ventilated area. Wear protective gloves/protective clothing/eye protection/face protection.
Eye contact Do not rub eyes. Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medical attention immediately. Ingestion Immediately rinse mouth and drink plenty of water. Call an ambulance and take these instructions. Get medical attention if symptoms occur. Most important symptoms/effects, acute and delayed Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred vision.
Methods and materials for containment and cleaning up Stop the flow of material, if this is without risk. If sweeping of a contaminated area is necessary use a dust suppressant agent which does not react with the product. Collect dust using a vacuum cleaner. Minimize dust generation and accumulation. Prevent entry into waterways, sewer, basements or confined areas. Following product recovery, flush area with water. For waste disposal, see section 13 of the SDS.
Appropriate engineering controls Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation, or other engineering controls to maintain airborne levels below recommended exposure limits. If exposure limits have not been established, maintain airborne levels to an acceptable level.
Flammability limit – upper (%) Not applicable Vapor pressure Not applicable Vapor density Not applicable Relative density 1.8 – 2.
Eye contact Causes serious eye damage. Prolonged contact with wet cement/mixture may cause burns. Ingestion Swallowing may cause gastrointestinal irritation. Symptoms related to the physical, chemical, and toxicological characteristics Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred vision. Permanent eye damage including blindness could result. Upper respiratory tract irritation. Coughing. Discomfort in the chest. Shortness of breath. Wheezing.
Specific target organ toxicity – single exposure May cause respiratory irritation. Specific target organ toxicity – repeated exposure May cause damage to organs (Lungs) through prolonged or repeated exposure. Aspiration hazard Due to the physical form of the product it is not an aspiration hazard. Chronic effects Prolonged or repeated exposure may cause lung injury. May cause skin disorders if contact is repeated or prolonged.
Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Not applicable 15 REGULATORY INFORMATION US federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed CERCLA Hazardous Substance List (40 CFR 302.
US. New Jersey Worker and Community Right-to-Know Act Chemical name Silica quartz Limestone CAS number 14808-60-7 1317-65-3 Concentration 20 – 60 5.0 – 15 US. Pennsylvania Worker and Community Right-to-Know Law Chemical name Silica quartz Limestone CAS number 14808-60-7 1317-65-3 Concentration 20 – 60 5.0– 15 US. Rhode Island RTK Chemical name Silica quartz Limestone CAS number 14808-60-7 1317-65-3 Concentration 20 – 60 5.0 – 15 US.
