Safety Data Sheet 1 IDENTIFICATION Product identifier Rapid Set Ultra-Fast Anchoring Adhesive (Part A) Other means of identification Product code 196131010 Recommended use Industrial use Recommended restrictions Appropriate training in the proper use and handling of this material should be provided as required under applicable regulations.
Precautionary statement Prevention P201: Obtain special instructions before use. P202: Do not handle until all safety precautions have been read and understood. P261: Do not breathe dust/fume/gas/mist/vapors/spray. P264: Wash thoroughly after handling. P270: Do not eat, drink or smoke when using this product. P272: Contaminated clothing should not be allowed out of the workplace. P280: Wear protective gloves/protective clothing/eye protection/face protection.
Most important symptoms/effects, acute and delayed Remove affected person from area. Treat symptomatically. Indication of immediate medical attention and special treatment needed Provide general supportive measures and treat symptomatically. Keep victim under observation. Symptoms may be delayed. General information If you feel unwell, seek medical advice (show the label where possible). Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves.
7 HANDLING AND STORAGE Precautions for safe handling Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Provide well ventilated areas. Keep away from heat and open flames. Avoid prolonged inhalation of heated vapor or mists. Avoid prolonged skin contact. Conditions for safe storage, including any incompatibilities Store between 40°F and 100°F. Protect from frost and direct sunlight. Store in dry location.
General hygiene considerations When using, do not eat, drink or smoke. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants.
10 STABILITY AND REACTIVITY Reactivity The product is stable and non-reactive under normal conditions of use, storage, and transport. Chemical stability Material is stable under normal conditions. Possibility of hazardous reactions No dangerous reaction known under conditions of normal use. Conditions to avoid Avoid elevated temperatures. Incompatible materials None known. Hazardous decomposition products Decomposition products None known.
Germ cell mutagenicity Not classified based on available information. Carcinogenicity May cause cancer. In 1997, IARC (the International Agency for Research on Cancer) concluded that crystalline silica inhaled from occupational sources can cause lung cancer in humans. However in making the overall evaluation, IARC noted that "carcinogenicity was not detected in all industrial circumstances studied.
Toxicity Aquatic Toxicity: No data on the product itself Acute Toxicity to FishComponents Ethylene Dimethacrylate Methacrylic Acid Monoester LC50 (96 HRS): 15.95 mg/l LC50 (48 HRS): 493 mg/l SPECIES: Danio Rerio SPECIES: Leuciscus Idus Acute Toxicity to Aquatic Invertebrates: Components Ethylene Dimethacrylate Methacrylic Acid Monoester EC50 (48 HRS): 0.11 mg/l EC50 (48 HRS): 380 mg/l SPECIES: Daphnia Magna SPECIES: Daphnia Magna EC50 (72 HRS): 97.
IATA Not regulated as dangerous goods. IMDG Not regulated as dangerous goods. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Not applicable 15 REGULATORY INFORMATION US federal regulations This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated. OSHA Specifically Regulated Substances (29 CFR 1910.
US. California Proposition 65 US - California Proposition 65 - Carcinogens & Reproductive Toxicity (CRT): Listed substance WARNING: This product contains chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.
Safety Data Sheet 1 IDENTIFICATION Product identifier Rapid Set Ultra-Fast Anchoring Adhesive (Part B) Other means of identification Product code 196131010 Recommended use Industrial use Recommended restrictions Workers (and your customers or users in the case of resale) should be informed of the potential presence of respirable dust. Appropriate training in the proper use and handling of this material should be provided as required under applicable regulations.
Hazard statement H242: Heating may cause a fire H317: May cause an allergic skin reaction H320: Causes eye irritation H350: May cause cancer H400: Very toxic to aquatic life H412: Harmful to aquatic life with long lasting effects Precautionary statement Prevention P201: Obtain special instructions before use. P202: Do not handle until all safety precautions have been read and understood.
4 FIRST-AID MEASURES Inhalation Remove the affected person immediately to fresh air. If breathing remains or becomes worse, seek medical attention. Give assisted respiration if breaking has stopped or is labored (Call a physician). Skin contact Remove product and flush affected area with water for 15 minutes. If irritation persists get medical attention. Eye contact Immediately flush eyes with plenty of water for at least 15 minutes. Get medical attention immediately.
6 ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Wear appropriate protective equipment and clothing during clean-up. Cover spills with absorbent materials. Place in metal containers for recovery or disposal. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8 of the SDS.
Appropriate engineering controls No special controls needed. General and local exhaust recommended. Individual protection measures, such as personal protective equipment Eye/face protection Splash proof googles or chemical safety glasses. Skin protection Hand protection Wear appropriate chemical resistant nitrile rubber gloves. Other Wear long sleeved shirts and trousers. Emergency showers and eye wash stations should be readily accessible.
Solubility (water) <1% Partition coefficient (noctanol/water) No applicable information available Decomposition temperature No data Viscosity No data Other information Bulk density No data Partition coefficient (oil/water) Not applicable VOC (weight %) 0% 10 STABILITY AND REACTIVITY Reactivity The product is stable under normal conditions of use, storage, and transport. Chemical stability Material is stable under normal conditions.
Components Dibenzoyl Peroxide (Oral) Dipropyleneglycol Dibenzoate (Oral) Zinc Distearate (Oral) Species Rat Rat Rat Test Results LD50: >5000 mg/kg LD50: 3914 mg/kg LD50: >5000 mg/kg Dipropyleneglycol Dibenzoate (Dermal) Zinc Distearate (Dermal) Rat LD50: >2000 mg/kg Rat LD50: >2000 mg/kg Dibenzoyl Peroxide (Inhalation) Dipropyleneglycol Dibenzoate (Inhalation) Rat Rat LD50 (4HR): >24.3 mg/l LD50 (4HR): >200 mg/l OECD Test Guideline 403 Skin corrosion/irritation Slight irritation.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed Reproductive toxicity No data. Specific target organ toxicity – single exposure No data. Specific target organ toxicity – repeated exposure No data. Aspiration hazard Due to the physical form of the product it is not an aspiration hazard. Chronic effects Prolonged or repeated exposure may cause lung injury and may result in delayed lung disease (silicosis). May cause skin disorders if contact is repeated or prolonged.
Other adverse effects No data available. 13 DISPOSAL CONSIDERATIONS Disposal instructions Incineration is preferred. Dispose of contents/container in accordance with local/regional/national/ international regulations. Do not discharge into drains/surface waters/ groundwater. This product should not be allowed to enter drains, water courses, or the soil. Local disposal regulations Dispose in accordance with all applicable regulations.
CERCLA Hazardous Substance List (40 CFR 302.4) Not listed Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Sara Title III Section 312 Hazard Class: Immediate (Acute) health hazard, delayed (chronic) health hazard Section 313 Listed Ingredients: Dibenzoyl Peroxide, Zinc Distearate Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Not regulated Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.
Revision date 23 February 2017 Version # 02 HMIS® ratings Health: 3 Flammability: 1 Reactivity: 1 Disclaimer CTS Cement Manufacturing Corporation cannot anticipate all conditions under which this information and its product, or the products of other manufacturers in combination with its product, may be used. It is the user’s responsibility to ensure safe conditions for handling, storage and disposal of the product, and to assume liability for loss, injury, damage or expense due to improper use.
