ENGLISH RAIS - manual for Rais Q-Tee 2 INSTRUCTIONS FOR INSTALLATION, USE AND MAINTENANCE RAIS Q-Tee 2 IMPORTANT INFORMATION On first lighting the stove you must be careful not to touch the painted surfaces and it is MOST IMPORTANT that the door is kept slightly ‘ajar’ in order for the door seal and sealant to cure. This will prevent the door seal sticking to the painted body and becoming damaged.
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 2 January 2014
ENGLISH RAIS - manual for Rais Q-Tee 2 Revision : 1 Date : January 2014 HETAS SUPPLEMENT …………………………………………………….. MANUFACTURERS PLATE ………………………………………………. INTRODUCTION ………………………………………………………….. WARRANTY …………………………………………………….………….. SPECIFICATIONS ………………………………………………………….. INSTALLATION INSTRUCTIONS ………………………………….……… CONVECTION ………………………………………………………….. CHIMNEY …………………………………………………….…………. INSTALLATION ………………………………………………..……... CHANGING THE CHIMNEY CONNECTION ……………………………..
ENGLISH RAIS - manual for Rais Q-Tee 2 SUPPLEMENTARY INSTALLATION INSTRUCTIONS FOR THE UK MARKET TO BE READ IN CONJUNCTION WITH THOSE IN THE INSTRUCTION BOOKLET READ THE INSTRUCTION BOOKLET AND THESE SUPPLEMENTARY INSTRUCTIONS CAREFULLY BEFORE INSTALLATION These instructions together with those in the instruction booklet cover the basic principles to ensure the satisfactory installation of the stove, although detail may need slight modification to suit particular local site conditions.
ENGLISH RAIS - manual for Rais Q-Tee 2 Chimney For the stove to perform satisfactorily the chimney height must be sufficient to ensure an adequate draught of approximately 15 Pa so as to clear the products of combustion and prevent smoke problems into the room. NOTE: A chimney height of not less than 4.5 metres measured vertically from the outlet of the stove to the top of the chimney should be satisfactory.
ENGLISH RAIS - manual for Rais Q-Tee 2 Approved Document J, to a distance of 30 cm in front of the stove and 15 cm to each side measuring from the door of the combustion chamber Combustion air supply In order for the stove to perform efficiently and safely there should be an adequate air supply into the room in which the stove is installed to provide combustion air. This is particularly necessary if the room is doubleglazed or a flue draught stabiliser is operating in the same room as the appliance.
ENGLISH RAIS - manual for Rais Q-Tee 2 SUPPLEMENTARY OPERATING INSTRUCTIONS FOR THE UK MARKET TO BE READ IN CONJUNCTION WITH THOSE IN THE INSTRUCTION BOOKLET READ THE INSTRUCTION BOOKLET AND THESE INSTRUCTIONS CAREFULLY BEFORE USING THE STOVE WARNING NOTE Properly installed, operated and maintained this stove will not emit fumes into the dwelling. Occasional fumes from de‑ashing and re‑fuelling may occur. However, persistent fume emission is potentially dangerous and must not be tolerated.
ENGLISH RAIS - manual for Rais Q-Tee 2 smokeless fuels or exempt appliances for use in smoke control areas in England. In Scotland and Wales this power rests with Ministers in the devolved administrations for those countries. Separate legislation, the Clean Air (Northern Ireland) Order 1981, applies in Northern Ireland.
RAIS - manual for Rais Q-Tee 2 ENGLISH out when the above action is taken then the fire brigade should be called immediately. Do not relight the stove until the chimney and flueways have been cleaned and examined by a professional. Permanent air vent The stove requires a permanent and adequate air supply in order for it to operate safely and efficiently.
ENGLISH RAIS - manual for Rais Q-Tee 2 d) that there is an adequate air supply into the room, e) that an extractor fan is not fitted in the same room as the fire. 2. Fire Blazing Out Of Control Check that: a) the doors are tightly closed, b) the air control is turned down to the minimum setting, c) the air inlet damper is closed and that it is not prevented from closing completely by a piece of ash, d) a suitable fuel is being used, e) the door seals are in good condition.
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 11 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 12 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 13 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 14 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 15 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 16 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 17 January 2014
ENGLISH RAIS - manual for Rais Q-Tee 2 Freestanding Installation - distance from a combustible wall To determine whether the wall next to where the stove is going to be installed is flammable, you should contact your building contractor or the local building authorities. The hearth should be able to accommodate the weight of the stove. The chimney must be independently supported by wall brackets or a ceiling support plate. The weight of the stove is indicated in the brochure.
ENGLISH RAIS - manual for Rais Q-Tee 2 Placement of Q-Tee II Installation distance from a combustible wall The stove is placed on a non-combustible floor. Using non insulated 150mm I.D. flue pipe, the minimum distance to combustible wall must be 450 mm from the flue. Normal set-up - corner setting A. Distance to furniture (min.) Distance to flammable materials (min.) B. in front (floor) C. to the side (floor) D. to the rear (wall) E.
ENGLISH RAIS - manual for Rais Q-Tee 2 Placement of Q-Tee II Corner setting 45° The stove is placed on a non-combustible floor. A. Distance to furniture (min.) Distance to flammable materials (min.) B. in front (floor) C. to the side (floor) D. to the rear (wall) E.
ENGLISH RAIS - manual for Rais Q-Tee 2 Placement of Q-Tee II Installation distance from combustible ceiling, floor and side wall Normal corner setting Distance to flammable materials (min.) E. to the side of the wall G. to the floor H.
ENGLISH RAIS - manual for Rais Q-Tee 2 Installation distance from non-combustible wall We recommend a minimum distance to non-combustible material of 50mm ( F ) for cleaning considerations. It should always be possible to access the flue access door.
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 23 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 24 January 2014
ENGLISH RAIS - manual for Rais Q-Tee 2 By setting the interval between position 1 and 2 (firewood) and between position 2 and 3 (approved smokeless fuel) the energy content in the firewood / approved smokeless fuel is used optimally, as there is oxygen as there is oxygen for combustion and for the burning of the pyrolysis gasses. When the flames are a clear yellow the damper has been set correctly. Finding the correct position comes with time, after you have used the stove for a while.
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 26 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 27 January 2014
ENGLISH RAIS - manual for Rais Q-Tee 2 Lighting of Approved Smokeless Fuel When the last flames are extinguished and there is a nice layer of embers (5), add 2-3 kgs of approved smokeless fuel. Spread the pieces evenly over the layer of embers. Close the door and once the fire has a good hold close completely. Damper - see adjustment of damper. When the flames are clear and stable (6) - close the damper gradually.
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 29 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 30 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 31 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 32 January 2014
ENGLISH RAIS - manual for Rais Q-Tee 2 PROBLEM SOLVING Q-Tee 2 Manual 33 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 34 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 35 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 36 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 37 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 38 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 39 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 40 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 41 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 42 January 2014
ENGLISH Q-Tee 2 Manual RAIS - manual for Rais Q-Tee 2 43 January 2014
ENGLISH RAIS - manual for Rais Q-Tee 2 U K Distributor. Robeys Ltd. Riverside, Goods Road, Belper, Derbyshire, England. DE56 1UU Tel: 01773 820940 Fax: 01773 820477 E Mail: info@robeys.co.uk www.robeys.co.
