Owner`s manual

ManualsBrandsR.H. Peterson ManualsLawn and Gardenrealfyre G5 Series

REV 4 0811041514

No. L-A2-02908

Charred Oak Designer (CHDG5-24) shown

ROBERT H. PETERSON CO. 14724 East Proctor Ave., City of Industry, CA 91746

G5 SERIES FOR NATURAL OR PROPANE GAS

ROBERT H. PETERSON CO.

IMPORTANT: For safe operation and proper performance and to comply with CSA Certiﬁ cation, ONLY

Robert H. Peterson parts and accessories must be used with this gas log set.

Do not store or use gasoline or other

ﬂ ammable vapors and liquids in the vicinity

of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Open a window.

• Do not try to light any appliance.

• Do not touch any electrical switch; do

not use any phone in your building.

• Immediately call your gas supplier from

a neighbor's phone and follow the gas

supplier's instructions.

• If you cannot reach your gas supplier,

call the ﬁ re department.

WARNING: If the information in this

manual is not followed exactly, a ﬁ re or

explosion may result causing property

damage, personal injury or loss of life.

IMPORTANT: READ THESE INSTRUCTIONS

CAREFULLY BEFORE STARTING

INSTALLATION OF YOUR LOG SET

Your Peterson Real-Fyre gas log set is to be installed

only in a solid-fuel burning ﬁ replace with a working

ﬂ ue and constructed of noncombustible material. Solid

fuels shall not be burned in a ﬁ replace where this gas

log set is installed. The installation, including provisions

for combustion, ventilation air and required minimum

permanent vent opening, must conform with the National

Fuel Gas Code (Z223.1/NFPA 54) and applicable

local building codes. In Canada, the installation must

conform with the current CAN/CGA B149.1, and B149.2

Installation Code. A Damper Stop Clamp is included to

maintain the minimum permanent vent opening and to

prevent full closure of the damper blade. The chimney

damper should be fully opened when burning the

log set. Your log set is designed to burn with yellow

ﬂ ames; thus adequate ventilation is absolutely

necessary.

OWNER'S

MANUAL

Installation and service must be

performed by an NFI Certiﬁ ed or

other qualiﬁ ed professional installer,

service agency or the gas supplier.

INSTALLER & CONSUMER:

These instructions MUST be retained

with this appliance.

C.S.A. CERTIFIED

GLOWING EMBERS

GAS FIREPLACE

LOG SET

INSTALLATION

AND

OPERATING

INSTRUCTIONS

Summary of content (20 pages)

PAGE 1
OWNER'S MANUAL ROBERT H. PETERSON CO. Charred Oak Designer (CHDG5-24) shown C.S.A. CERTIFIED GLOWING EMBERS GAS FIREPLACE LOG SET INSTALLATION AND OPERATING INSTRUCTIONS G5 SERIES FOR NATURAL OR PROPANE GAS WARNING: If the information in this IMPORTANT: READ THESE INSTRUCTIONS manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
PAGE 2
ROBERT H. PETERSON CO. CENDRE ARDENTS ENTHOUSIASTES ASPHYXIENT CHEMINÉE TRONÇONNE l'ENSEMBLE C.S.A./ C.G.A. CERTIFIÉ Charred Oak Designer (CHDG5-24) shown INSTALLATION ET DIRECTIVES QUI OPERE G5 SÉRIE POUR NATUREL Ou PROPANE ASPHYXIE AVERTISSEMENT: Si les informations dans ce manuel ne sont pas suivies exactement, un feu ou explosion peut résulter cause propriété endommage, blessure personnelle ou perte de vie.
PAGE 3
IMPORTANT INFORMATION IMPORTANT: For safe operation and proper performance and to comply with CSA Certification, ONLY Robert H. Peterson parts and accessories must be used with this gas log set. The minimum inlet gas supply pressure for purpose of input adjustment is 5" for natural gas and 10" for propane gas. Maximum inlet gas supply pressure for this burner is 10.5" for natural and 13" for propane gas.
PAGE 4
PARTS LIST FOR PETERSON REAL-FYRE C.S.A. CERTIFIED GLOWING EMBER GAS LOG SETS (G5 SERIES) NOTE: The parts for the RDPG5-24 Golden Oak Designer Plus 24" Set are illustrated and listed. Log styles and part sizes will vary depending upon the G5 series log set ordered. When ordering replacement parts, be sure to indicate your log set model. 11 GLOWING EMBERS BL 5 6 3 4 Item No. 15A 12 SAND OR VERMICULITE GRANULES 2 1. 2. 3. 4. 5. 6. BL. 7. 8. 9. 1 15B 10 13 7 15 CK-5-SP CONNECTOR KIT 16 10. 11.
PAGE 5
SAFETY CONTROL SYSTEM (Item No. 14) FOR MANUAL VALVE 25A Pressure Tap 22 Flame Diverter Bracket 25 23 21 24 19 20 18 Item No. Part No. Description 17. 18. 19. 20. 21. 22. 23. OR 24. 25. OR 25A. Control Knob Extension Manual SPK Valve Manual (SV-19) Valve Cover Regulator Cover Adaptor,1/2MFL x 3/8MPT Pressure Regulator, Nat.Gas Pressure Regulator, L.P. Gas Nipple, 3/8 x 1.5" Pilot Assembly, Natural Gas Pilot assembly, L.P. Gas Natural Gas orifice or L.P.
PAGE 6
SAFETY CONTROL SYSTEM (Item No. 14) FOR 01 VALVE SPARKING PROBE FLAME HOOD SENSOR PROBE 41 Item No. Part No. 41 OR 42 Pilot Assembly(NAT) Pilot Assembly(L.P.) Valve Assembly (Natural or L.P gas) Brass Adaptor w/o plug Heat Shield Pine Cone with switch (EPK-1) Wire Harness, 24" Ignition Module Pack 43 44 45 46 47 Place Heat Shield (#44) over Valve (#42) PILOT ASSEMBLY (PAC-6 or 7) REV 4 0811041514 Description Switch 6 No.
PAGE 7
ALTERNATE CONTROLS AUTOMATIC REMOTE LIGHTING SAFETY PILOT SYSTEM (11 VALVE) 51 60 54 61 4857 52 Generator Spade Clips 61 54 53 Pilot Gas Supply 59 CONNECT TO BURNER PAN ASSEMBLY 58 50 STREET ELBOW 56 49 BRASS ELBOW SERIES 11 VALVE TOGGLE SWITCH Item No. Part No. PILOT BURNER WIRING HARNESS JUMPER WIRE PILOT GENERATOR PILOT GAS PORT PILOT CAP SCREW 48. 49. 50. TH TH TP TP IN PILOT GAS SUPPLY 51. 52. 53. 54.
PAGE 8
INSTALLATION OF YOUR GAS LOG SET The Peterson Real-Fyre gas log set must be installed by an NFI Certified or other qualified, professional installer. Instructions must be followed carefully to insure proper performance and full benefit from your gas log set. Peterson Real-Fyre gas logs must be installed only in a wood burning fireplace with the minimum venting requirements met (see Page 3). Check parts list to be sure all parts are included. Gas supply pipe must be l/2" minimum interior diameter or larger.
PAGE 9
LOG PLACEMENT LOG PLACEMENT (for Charred Series see supplement instructions on pages 10 & 11) Proper log placement is important to ensure proper performance of your Real-Fyre gas log set. Be sure to follow the log placement instructions carefully. Optional log placement patterns, an exclusive feature of Real-Fyre gas logs, are explained below.
PAGE 10
LOG PLACEMENT (continued) OPTIONAL BONUS LOG PLACEMENT Your optional bonus log (Included with Emberwood Deluxe, Emberwood Deluxe Designer, Golden Oak Designer Plus and Split Oak Designer Plus Log Sets) should be placed directly above the front or rear bottom logs (Logs #1 and #2), so it does not extend into the space between the front and rear logs (Figure 7). 7 REAL-FYRE GAS LOG SETS 16" Place the front and rear bottom logs on the grate (Figure 8).
PAGE 11
LOG PLACEMENT (cont'd) LOG #2 LO G G LOG #1A #6 LO #5 LOG #1B Figure 12 MAINTAIN A SPACE IN THE CENTER OF THE LOGS AT ALL TIMES Figure 14 Log #7 #3 LO #4 LO G G Figure 13 Figure 15 CAUTION: BURN HAZARD. LOGS WILL REMAINHOT FOR SOME TIME AFTER USE. YOU MUST MAINTAIN THE LOG LAYOUT AS SHOWN TO ENSURE PROPER OPERATION OF YOUR LOG SET. IF YOU NEED TO REPOSITION ANY LOG TO MAINTAIN THE PROPER LAYOUT, USE HEAT RESISTANT GLOVES OR ALLOW LOGS ADEQUATE TIME TO COOL BEFORE HANDLING.
PAGE 12
POUR VOTRE SECURITE, LISEZ AVANT D’ALLUMER * Nous recommandons qu’avant que vous installiez votre grosse bûche mise vous vous familiarisez avec la disposition de la valve du contrôle. Cela vous aidera pour être opérer plus confiant la grosse bûche mise quand a complètement installé (voyez des Illustrations dessous pour contriol typique placez).
PAGE 13
FOR YOUR SAFETY, READ BEFORE LIGHTING * We recommend that before you install your log set you familiarize yourself with the control valve layout. This will help you to be confident operating the log set when fully installed (see Figures below for typical control positions). WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. The Peterson Real-Fyre gas log set has a pilot which must be lit by hand.
PAGE 14
POUR VOTRE SECURITE, LISEZ AVANT D’ALLUMER * Nous recommandons qu’avant que vous installiez votre grosse bûche mise vous vous familiarisez avec la disposition de la valve du contrôle. Cela vous aidera pour être opérer plus confiant la grosse bûche mise quand a complètement installé (voyez des Illustrations dessous pour contriol typique placez).
PAGE 15
FOR YOUR SAFETY, READ BEFORE LIGHTING * We recommend that before you install your log set you familiarize yourself with the control valve layout. This will help you to be confident operating the log set when fully installed (see Figures below for typical control positions). WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. The Peterson Real-Fyre gas log set has a pilot which must be lit by hand.
PAGE 16
POUR VOTRE SECURITE, LISEZ AVANT D’ALLUMER * Nous recommandons qu’avant que vous installiez votre grosse bûche mise vous vous familiarisez avec la disposition de la valve du contrôle. Cela vous aidera pour être opérer plus confiant la grosse bûche mise quand a complètement installé (voyez des Illustrations dessous pour contriol typique placez).
PAGE 17
FOR YOUR SAFETY, READ BEFORE LIGHTING * We recommend that before you install your log set you familiarize yourself with the control valve layout. This will help you to be confident operating the log set when fully installed (see Figures below for typical control positions). WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. The Peterson Real-Fyre gas log set has a pilot which must be lit by hand.
PAGE 18
POUR VOTRE SECURITE, LISEZ AVANT D’ALLUMER * Nous recommandons qu’avant que vous installiez votre grosse bûche mise vous vous familiarisez avec la disposition de la valve du contrôle. Cela vous aidera pour être opérer plus confiant la grosse bûche mise quand a complètement installé (voyez des Illustrations dessous pour contriol typique placez).
PAGE 19
FOR YOUR SAFETY, READ BEFORE LIGHTING * We recommend that before you install your log set you familiarize yourself with the control valve layout. This will help you to be confident operating the log set when fully installed (see Figures below for typical control positions). WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. The Peterson Real-Fyre gas log set has a pilot which must be lit by hand.
PAGE 20
WARRANTY PETERSON VENTED GAS LOG SETS LIMITED WARRANTY All Peterson gas logs are WARRANTED for as long as you own them (lifetime). All Peterson burner assemblies are WARRANTED for TEN (10) YEARS. SPK-26 controls are covered by a THREE (3) YEAR “All Parts” Warranty. All other Peterson valves, pilots, and controls are covered by a ONE (1) YEAR Limited Warranty (excluding batteries).