Owner`s manual

ManualsBrandsR.H. Peterson ManualsLawn and GardenOCR-27P

ROBERT H. PETERSON CO. • 14724 East Proctor Avenue • City of Industry, CA 91746

OWNER’S

MANUAL

WARNING: If the information in this manual

is not followed exactly, a ﬁ re or explosion may

result causing property damage, personal

injury or loss of life.

- Do not store or use gasoline or other

ﬂ ammable vapors and liquids in the vicinity

of this or any other appliance.

- A propane cylinder not connected for use

shall not be stored in the vicinity of this or

any other appliance.

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open ﬂ ame.

3. If odor continues, keep away from the

appliance and immediately call your gas

supplier or ﬁ re department.

Installation and service must be performed by

an NFI Certiﬁ ed or other qualiﬁ ed professional

installer, service agency, or gas supplier.

09-66

WARNING

Improper installation, adjustment, alteration,

service, or maintenance can cause property

damage, personal injury, or loss of life. Read

the installation, operating and maintenance

instructions thoroughly before installing or

servicing this equipment.

CODE AND SUPPLY REQUIREMENTS:

The installation must conform with local codes and

ordinances, or, in the absence of local codes, with

the latest National Fuel Gas Code, ANSI Z223.1.

This appliance is designed as an attended

appliance. Adults must be present when the

unit is operating. DO NOT leave this unit burning

when unattended. If this product is left burning

unattended, it may cause damage or serious injury.

INSTALLER & CONSUMER: These instructions MUST

be retained with this appliance for future reference.

Important: Read these instructions carefully

before starting installation of the unit.

IMPORTANT

For safe operation and proper performance of

this product and to comply with certification,

listings, and building code acceptances, use

ONLY Peterson Real-Fyre

controls, parts, and

accessories that have been speciﬁ cally listed or

certiﬁ ed for use with this burner system. Use of

other controls, parts, or accessories is prohibited

and will void all warranties, certiﬁ cations, listings,

and building code approvals, and may cause

property damage, personal injury, and loss of life.

Certiﬁ ed to:

ANSI Z21.97/CSA 2.41-2012 for outdoor decorative gas appliances

WARNING: For Outdoor Use Only

DANGER

CARBON MONOXIDE HAZARD

This appliance can produce carbon

monoxide which has no odor.

Using it in an enclosed space can

kill you.

Never use this appliance in an

enclosed space such as a camper,

tent, car, or home.

L-A2-181

REV 14 - 1211211503

ROUND OUTDOOR CAMPFYRE CONTROL SYSTEM

05 Series Shown

OCB(E,M)-34(P) series

(

)

Summary of content (28 pages)

PAGE 1
OWNER’S MANUAL 05 Series Shown WARNING: For Outdoor Use Only Certified to: ANSI Z21.97/CSA 2.41-2012 for outdoor decorative gas appliances OCB(E,M)-34(P) 34(P) seri series 09-66 ROUND OUTDOOR CAMPFYRE CONTROL SYSTEM INSTALLER & CONSUMER: These instructions MUST be retained with this appliance for future reference. WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
PAGE 2
MANUEL DU PROPRIÉTAIRE 05 Séries Montrées AVERTISSEMENT: Pour l'usage extérieur seulement Certifié à: ANSI Z21.97/CSA 2.41-2012 pour les appareils à gaz décoratifs extérieurs OCB(E, M)-34(P) 34(P) séri séries 09-66 SYSTÈME DE CONTRÔLE EXTÉRIEUR ROND DE CAMPFYRE d'INSTALLATEUR; CONSOMMATEUR: Ces instructions DOIVENT être maintenues avec cet appareil pour la future référence. Important: Lisez ces instructions soigneusement avant de commencer l'installation de l'unité.
PAGE 3
TABLE OF CONTENTS 4 6 7 7 8 8 8 9 10 10 10 10 11 12 13 14 14 16 18 19 21 23 25 27 27 28 PARTS LIST PRE-INSTALLATION AND PREPARATION SAFETY GUIDELINES INSTALLATION SAFETY GUIDELINES OPERATING THE UNIT SAFELY AND CORRECTLY IMPORTANT SAFETY INFORMATION MINIMUM CLEARANCE TO COMBUSTIBLES INSTALLATION INSTALLATION SPECIFICATIONS CONNECT TO THE GAS SUPPLY CONNECT TO A POWER SUPPLY (05 Series Only) LEAK TEST CONTROL PANEL INTERIOR ACCESS (IF APPLICABLE) INSTALLING/REPLACING BATTERIES (IF APPLICABLE) CONVERTING TO
PAGE 4
PARTS LIST 01 Series Flex connector 3 NO. DESCRIPTION Burner ring 4 Remote handset 1. Burner pan assy 2. Control panel assembly 2 3. Flex connector (2) Control panel assembly 4. Remote handset 5. Pilot assembly 6. Lava granules (10 lbs) & lava coals (6 lbs) 2 Fig. 4-1 Pilot assembly under screen Burner pan assembly Pilot assembly (under screen) 5 Control panel front view 1 6 Fig. 4-2 Lava granules & coals Pilot hood "D" battery access plate Igniter electrode Fig.
PAGE 5
PARTS LIST (cont.) Match lit manual series Fig. 5-1 1 NO. DESCRIPTION Burner pan assembly Control valve 2 assembly 1. Burner pan assy 2. Control valve assembly Burner ring 3. Flex connector (2) 4. Lava granules (10 lbs) & lava coals (6 lbs) 3 Flex connector Lava granules & coals 4 2 Control valve front view Fig. 5-2 Fig. 5-3 Contact your local dealer for replacement parts 05 Series NO. DESCRIPTION 1. Burner pan assy 2. Control panel assembly 3. Flex connector (2) 4.
PAGE 6
PRE-INSTALLATION AND PREPARATION SAFETY GUIDELINES A. Before installing this unit, check the MINIMUM CLEARANCE TO COMBUSTIBLES section to ensure that the surrounding area is properly sized for the installation. B. The unit is for outdoor use only. DO NOT install or use this appliance inside a building, garage, or any other enclosed area, including recreational vehicles and/or boats.
PAGE 7
INSTALLATION SAFETY GUIDELINES A. Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least annually by a qualified service person. More frequent cleaning may be required as necessary. It is imperative that control compartment, burners and circulating air passageways of the appliance are kept clean. B. Carefully inspect for shipping damage. If any parts are damaged, call the dealer. C.
PAGE 8
IMPORTANT SAFETY INFORMATION BE CAREFUL If not installed and used correctly per these instructions, this product can cause serious injury. CAUTION: Installation and maintenance must be done by an NFI Certified or other qualified professional installer. Read these instructions before installing this unit. Be sure you understand all safety precautions and warnings contained in this manual. A. FOR OUTDOOR USE ONLY. B. When shutting the unit down—be sure to TURN THE CONTROL VALVE FULLY OFF. C.
PAGE 9
INSTALLATION (Cont.) INSTALLATION SPECIFICATIONS When installing in your enclosure, allow a minimum of 8" (vertical) from the bottom of the control panel to the burner pan (Fig. 9-1), and set back the edge of the burner pan no more than 30" from the outer wall (see Fig. 9-1 and 9-2). This will allow adequate access for maintenance and troubleshooting. Note: Two vent openings for adequate combustion air must be provided (Fig. 9-1).
PAGE 10
INSTALLATION (Cont.) CONNECT TO THE GAS SUPPLY 1. Bring the gas-supply pipe up from beneath the unit near its center. Note: Locate the gas supply line out of pathways where people may trip over it or in areas where the line may be subject to accidental damage. 2. Install the supplied flare adaptor to the gas supply (NPT) using a gas pipe sealing compound or Teflon tape (see Fig. 10-1). 3. Connect the flex connector coming from the valve assembly to the gas supply adaptor (see Fig. 10-1).
PAGE 11
INSTALLING/REPLACING BATTERIES (IF APPLICABLE) CAUTION: ENSURE THE UNIT IS CONNECTED TO THE GAS LINE AND HAS BEEN TESTED FOR LEAKS BEFORE YOU INSERT BATTERIES. I N S TA L L I N G / R E P L AC I N G T H E S PA R K GENERATOR BATTERY FOR PIEZO LIT MANUAL UNITS To access the "AA" battery, unscrew the complete generator cap (Fig. 11-1). Withdraw the existing battery and spring (Fig. 11-2) and detach the "AA" battery. Insert the new battery (negative end first) into the spring.
PAGE 12
CONVERTING TO A DIFFERENT GAS TYPE (PIEZO LIT) To convert PIEZO LIT MANUAL UNITS (only) from propane to natural gas or from natural to propane gas, carefully follow the steps below: 1. SHUT OFF THE GAS SUPPLY TO THE UNIT AND ANY NEARBY ELECTRICAL SOURCES OR APPLIANCES. 2. If present, remove all decorative media from the unit. 3. If installed, remove the screws attaching the burner pan to your enclosure. 4. The control panel bottom plate must be removed to allow access to the valve assembly found inside.
PAGE 13
CONVERTING TO A DIFFERENT GAS TYPE (MATCH LIT) To convert MATCH LIT MANUAL UNITS (only) from propane to natural gas or from natural to propane gas, carefully follow the steps below: 1. SHUT OFF THE GAS SUPPLY TO THE UNIT AND ANY NEARBY ELECTRICAL SOURCES OR APPLIANCES. 2. If present, remove all decorative media from the unit. 3. Remove the screws attaching the burner pan to your enclosure. 4. Carefully detach the flex connector attached to the orifice holder (see Fig.
PAGE 14
DECORATIVE MEDIA OPTIONS The unit has several options for decorative media, each with a different set of components and setup instructions. These setup instructions are for your reference. None of these options come with the outdoor campfyre kit and must be ordered separately. Note: Lava media (included with burner) is always placed on the burner first in each option. This provides an important base for the diffusion of gas and air. Depending on fire-pit size, more lava than supplied may be required.
PAGE 15
OPTIONAL CAMPFYRE LOGS (cont.) Screen with lava on burner pan WARNING This screen must be clear and free of obstructions at all times to ensure proper operation (Fig. 15-1). DO NOT PLACE LAVA MEDIA ON THE SCREEN LAVA MEDIA PLACEMENT 1. FIRST, pour the 10 lb bag of lava granules into the burner pan, evenly covering the burner pan assembly with the exception of the screen. THEN, pour the 6 lb bag of lava coals into the burner pan, evenly covering the burner pan assembly with the exception of the screen.
PAGE 16
OPTIONAL BEACHWOOD LOGS AND/OR VOLCANIC STONE 2 4 8 3 1 Fig. 16-1 5 7 6 OCBW-34 # 1. 2. 3. 4. 5. 6. 7. 8. Description Knotted log Hooked log Crooked log Curved log Stripped log Long charred log Short charred log Volcanic stones (box) Part Number OCBWL-17 OCBWL-18 OCBWL-16 OCBWL-15 OCBWL-12 OCBWL-20 OCBWL-9 VS-25 Qty 1 1 1 1 1 1 1 1 Although log placement may vary, suggested log placement for the Beachwood log set is provided below.
PAGE 17
OPTIONAL BEACHWOOD LOGS (cont.) 6 CAUTION: CAMPFYRE OR DECORATIVE MEDIA WILL REMAIN HOT FOR SOME TIME AFTER USE. IF YOU NEED TO REPOSITION ANY DECORATIVE MEDIA, U S E H E AT- R E S I S TA N T GLOVES OR ALLOW TO COOL BEFORE HANDLING. 3 4 5 7 LOG PLACEMENT OPTION TWO - LOG SQUARE Fig. 17-1 1. Lay Log #1 across the volcanic stone, then lay the hooked part of Log #2 over one end of Log #1 at an angle of approximately 90 degrees (see Fig. 15-2). Beachwood Log Set p Other options 2.
PAGE 18
OPTIONAL GLASS/GEMS OR RIVER ROCK ON GLASS/GEMS Item 1. or 2. Description Glass (10 lb bag) Gems (10 lb bag) Box of river rock (optional) Part Number GL-10-x* GLG-10-x* STN-10 * Replace “x” in model number with the applicable glass/gem code for your chosen media. Glass and gems are available in various colors; contact your dealer for further details. Qty 2** 1 ** Depending on fire-pit size, additional glass/gems may be required. 1 Note: Installation is the same fo r g l a s s a n d g e m s .
PAGE 19
OPERATING THE UNIT - LIGHTING AND EXTINGUISHING FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. C. Use only your hand to push in or move the controls. Never use tools. If the control will not push in or move by hand, DO NOT try to repair it. Call a qualified professional service technician. Force or attempted repair may result in fire or explosion. A.
PAGE 20
OPERATING THE UNIT - LIGHTING AND EXTINGUISHING POUR VOTRE SÛRETÉ, LISEZ AVANT L'ALLUMAGE AVERTISSEMENT: SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS EXACTEMENT, UNE INCENDIE OU UNE EXPLOSION PEUT RÉSULTER, ENTRAÎNANT DES DÉGATS MATÉRIELS, LE DOMMAGE CORPOREL, OU DES PERTES HUMAINES. C. Utilisez seulement votre main pour enfoncer ou pour déplacer les commandes. N'utilisez jamais les outils. Si la commande n'enfoncera pas ou ne se déplacera pas à la main, n'essayez pas de la réparer.
PAGE 21
OPERATING THE UNIT - LIGHTING AND EXTINGUISHING FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. A. BEFORE LIGHTING, smell all around the unit area for gas. Be sure to smell next to the floor, because some gas is heavier than air and will settle on the floor. B. WHAT TO DO IF YOU SMELL GAS 1. Shut off the gas to the appliance. 2. Extinguish any open flame. 3.
PAGE 22
FONCTIONNEMENT DE L'ÎLE UNITÉ - ÉCLAIRAGE ET S'ÉTEINDRE Pour votre sécurité lisez avant d’allumer Avertissement. Quiconque ne respecte pas a la lettre les instructions dans la présente notice risque de déclencher un incendie ou une explosion entraînant des dommages, des blessures ou la mort. AVANT DE S'ALLUMER, sentez tous autour de l'île unité secteur pour le gaz. Soyez sûr de sentir à côté de la terre, parce qu'un certain gaz est plus lourd que l'air et arrangera sur le plancher.
PAGE 23
OPERATING THE UNIT - LIGHTING AND EXTINGUISHING FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. A. BEFORE LIGHTING, smell all around the unit area for gas. Be sure to smell next to the floor, because some gas is heavier than air and will settle on the floor. B. WHAT TO DO IF YOU SMELL GAS 1. Shut off the gas to the appliance. 2. Extinguish any open flame. 3.
PAGE 24
FONCTIONNEMENT DE L'ÎLE UNITÉ - ÉCLAIRAGE ET S'ÉTEINDRE POUR VOTRE SÛRETÉ, LISEZ AVANT DE S’ALLUMER AVERTISSEMENT SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS EXACTEMENT, UNE INCENDIE OU UNE EXPLOSION PEUT RÉSULTER, ENTRAÎNANT DES DÉGATS MATÉRIELS, DES BLESSURES, OU LA PERTE DE LA VIE. A. AVANT DE S’ALLUMER, sentez tous autour du secteur extérieur de feu de camp pour le gaz. Soyez sûr de sentir à côté du plancher, parce qu’un certain gaz est plus lourd que l’air et arrangera sur le plancher. B.
PAGE 25
OPERATING THE UNIT - LIGHTING AND EXTINGUISHING FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. A. BEFORE LIGHTING, smell all around the unit area for gas. Be sure to smell next to the floor, because some gas is heavier than air and will settle on the floor. B. WHAT TO DO IF YOU SMELL GAS C. Use only your hand to push in or turn the gas control knob. Never use tools.
PAGE 26
ACTIONNANT L'UNITÉ - ÉCLAIRAGE ET S'ÉTEIGNANT POUR VOTRE SÛRETÉ, LISEZ AVANT L'ALLUMAGE AVERTISSEMENT : Si vous ne suivez pas ces instructions exactement, une incendie ou une explosion peut résulter, entraînant des dégats matériels, le dommage corporel, ou des pertes humaines. A. AVANT L'ALLUMAGE, sentez tous autour de l'unité de superficie pour le gaz. Soyez sûr de sentir à côté du plancher, parce qu'un certain gaz est plus lourd que l'air et arrangera sur le plancher. B.
PAGE 27
OPERATION Each installation site for any unit presents its own unique combustion environment. Specific factors such as weather, wind currents, yard debris, altitude, drafts, the size of the surrounding area, all have an influence on the proper operation of the unit. A normally operating unit will demonstrate the following characteristics: a) A lively, realistic yellow flame, b) Odor-free.
PAGE 28
PETERSON CAMPFYRE LIMITED WARRANTY THREE (3) YEAR LIMITED WARRANTY All Peterson Outdoor Campfyre logs, enclosures, and burner component parts, (except valves and controls) are covered by a three (3) year limited warranty. All Peterson valves and controls are covered by a separate one (1) year limited warranty (excluding batteries). A COPY OF YOUR SALES SLIP FOR PROOF OF PURCHASE IS REQUIRED This warranty applies to the original purchaser and to single family residential use only.