Owner`s manual

ManualsBrandsR.H. Peterson ManualsLawn and GardenOCR-27P

L-A2-182

REV 15 - 1211281430

ROBERT H. PETERSON CO. • 14724 East Proctor Avenue • City of Industry, CA 91746

CODE AND SUPPLY REQUIREMENTS:

This Outdoor Campfyre

™

must be installed in

accordance with local codes and ordinances,

or, in the absence of local codes, with the latest

National Fuel Gas Code, ANSI Z223.1.

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open ﬂ ame.

3. If odor continues, keep away from the

appliance and immediately call your gas

supplier or ﬁ re department.

FOR YOUR SAFETY

1. Do not store or use gasoline or other ﬂ ammable

vapors and liquids in the vicinity of this or any

other appliance.

2. A propane cylinder not connected for use shall

not be stored in the vicinity of this or any other

appliance.

MANUAL & REMOTE-OPERATED

OUTDOOR CAMPFYRE

™

OWNER’S

MANUAL

For all OCR-34 Series Outdoor Campfyres™

Installation and service must be performed by

an NFI Certiﬁ ed or other qualiﬁ ed professional

installer, service agency, or the gas supplier.

WARNING

Improper installation, adjustment, alteration, service,

or maintenance can cause property damage,

personal injury, or loss of life. Refer to this manual.

For assistance or additional information, consult a

qualiﬁ ed professional installer, service agency, or

the gas supplier.

This appliance is designed as an attended

appliance. Adults must be present when the

unit is operating. DO NOT leave this unit burning

when unattended. If this product is left burning

unattended, it may cause damage or serious injury.

INSTALLER & CONSUMER: These instructions MUST

be retained with this appliance for future reference.

Important: Read these instructions carefully before

starting installation of the Outdoor

Campfyre

™

IMPORTANT

For safe operation and proper performance of this

product and to comply with certiﬁ cation, listings,

and building code acceptances, use ONLY Peterson

Real-Fyre

controls, parts, and accessories that

have been speciﬁ cally listed or certiﬁ ed for use with

this burner system. Use of other controls, parts, or

accessories is prohibited and will void all warranties,

certiﬁ cations, listings, and building code approvals,

and may cause property damage, personal injury,

and loss of life.

DANGER

CARBON MONOXIDE HAZARD

This appliance can produce carbon

monoxide which has no odor.

Using it in an enclosed space can

kill you.

Never use this appliance in an

enclosed space such as a camper,

tent, car, or home.

09-66

Certiﬁ ed to:

ANSI Z21.97/CSA 2.41-2012 for outdoor decorative gas appliances

WARNING: For Outdoor Use Only

Summary of content (30 pages)

PAGE 1
MANUAL & REMOTE-OPERATED OUTDOOR CAMPFYRE™ OWNER’S MANUAL WARNING: For Outdoor Use Only Certified to: ANSI Z21.97/CSA 2.41-2012 for outdoor decorative gas appliances 09-66 For all OCR-34 Series Outdoor Campfyres™ INSTALLER & CONSUMER: These instructions MUST be retained with this appliance for future reference. Important: Read these instructions carefully before starting installation of the Outdoor Campfyre™.
PAGE 2
MANUEL OWNERS MANUEL & CAMPFYRE DE PLEIN AIR OPÉRÉ ÉLOIGNÉ AVERTISSEMENT: Pour l'usage extérieur seulement Certifié à: ANSI Z21.97/CSA 2.41-2012 pour les appareils à gaz décoratifs extérieurs 09-66 Pour toute l’ OCR-34 série Campfyres extérieur CODE ET EXIGENCES DE LA PROVISION: Ce Campfyre De plein air ™ doit être installé conformément à codes locaux et ordonnances, ou dans l’absence de codes locaux, avec le Code du Gaz du Combustible National le plus tardif, ANSI Z223.1.
PAGE 3
TABLE OF CONTENTS 4 7 8 8 9 11 11 PARTS LIST PRE-INSTALLATION AND PREPARATION SAFETY GUIDELINES INSTALLATION SAFETY GUIDELINES OPERATING THE UNIT SAFELY AND CORRECTLY SAFE USE & MAINTENANCE OF PROPANE GAS CYLINDERS IMPORTANT SAFETY INFORMATION CONNECTING THE GAS TO THE OUTDOOR CAMPFYRE™ 11 12 13 13 13 14 15 MINIMUM CLEARANCE TO COMBUSTIBLES ACCESSING THE GAS CONTROL SYSTEM CONNECTING THE GAS TO THE OUTDOOR CAMPFYRE™ LEAK TESTING ALTERNATE GAS/ELECTRICAL INSTALLS THROUGH SIDEWALL INSTALLING/REPLACING BATT
PAGE 4
PARTS LIST Contact your local dealer for replacement parts Piezo lit manual series NO. 1. 2. 3. 4. DESCRIPTION Fire pit Burner pan assembly (natural or propane) Igniter assembly Control panel assembly Burner pan 1 Control panel Fire pit 5. Lava granules (10 lbs) & lava coals (6 lbs) 2 BURNER PAN ASSEMBLY Vent Igniter assembly under screen Burner pipe Control knob Fig. 4-1 Burner pan 3 Ignitor button Thermocouple Igniter assembly Burner pan Fig. 4-4 Fig. 4-3 Fig.
PAGE 5
PARTS LIST (cont.) Contact your local dealer for replacement parts 01 Series Burner pan Control panel access door NO. DESCRIPTION Fig. 5-1 1. Fire pit 2. Burner pan assembly (natural or propane) 3. Pilot assembly 4. Control panel assembly 5. Remote handset Vent 6. Lava granules (10 lbs) & lava coals (6 lbs) Remote receiver & switch Fire pit 1 Fig. 5-3 Burner assembly 2 Burner ring Burner pan from below Pilot assembly under screen Burner pipe Burner pan Gas line in Fig.
PAGE 6
PARTS LIST (cont.) Contact your local dealer for replacement parts 05 Series Control panel access door NO. DESCRIPTION Burner pan Fig. 6-1 1. Fire pit 2. Burner pan assembly (natural or propane) 3. Pilot assembly 4. Control panel assembly 5. Remote handset Vent 6. Lava granules (10 lbs) & lava coals (6 lbs) Fire pit 1 2 Burner ring Fig. 6-3 Burner assembly Burner pan from below Pilot assembly under screen Remote receiver & switch Burner pipe Burner pan Gas line in Fig.
PAGE 7
PRE-INSTALLATION AND PREPARATION SAFETY GUIDELINES A. Before installing this unit, check the MINIMUM CLEARANCE TO COMBUSTIBLES section to ensure that the surrounding area is properly sized for the installation. B. The unit is for outdoor use only. DO NOT install or use this appliance inside a building, garage, or any other enclosed area, including recreational vehicles and/or boats.
PAGE 8
INSTALLATION SAFETY GUIDELINES A. Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least annually by a qualified service person. More frequent cleaning may be required as necessary. It is imperative that control compartment, burners and circulating air passageways of the appliance are kept clean. B. Carefully inspect for shipping damage. If any parts are damaged, call the dealer. C.
PAGE 9
SAFE USE & MAINTENANCE OF PROPANE GAS CYLINDERS IMPORTANT FOR YOUR SAFETY READ AND FOLLOW ALL WARNINGS PROVIDED WITH THE PROPANE-GAS CYLINDER. When operating this appliance with a propane-gas cylinder, these instructions and warnings MUST be observed. FAILURE TO DO SO MAY RESULT IN A SERIOUS FIRE OR EXPLOSION. The use of pliers or a wrench should not be necessary. Only cylinders marked “propane” may be used. CYLINDER/CONNECTOR REQUIREMENTS a.
PAGE 10
UTILISATION SÛRE ET ENTRETIEN DES CYLINDRES DE GAZ DE PROPANE IMPORTANT POUR VOTRE SÛRETÉ LISEZ ET SUIVEZ TOUS LES AVERTISSEMENTS ÉQUIPÉS DE VOTRE CYLINDRE DE GAZ DE PROPANE. En actionnant cet appareil avec un cylindre de gaz de propane ON DOIT observer ces instructions et avertissements. LE MANQUE DE FAIRE AINSI PEUT AVOIR COMME CONSÉQUENCE UNE INCENDIE OU UNE EXPLOSION SÉRIEUSE.
PAGE 11
IMPORTANT SAFETY INFORMATION BE CAREFUL If not installed and used correctly per these instructions, this product can cause serious injury. CAUTION: Installation and maintenance must be done by an NFI Certified or other qualified professional installer. Read these instructions before installing this Outdoor Campfyre™. Be sure you understand all safety precautions and warnings contained in this manual. A. FOR OUTDOOR USE ONLY. THIS UNIT MUST BE INSTALLED AT LEAST 36" FROM ANY COMBUSTIBLE WALLS OR MATERIAL.
PAGE 12
CONNECTING THE GAS TO THE OUTDOOR CAMPFYRE™ (Cont.) Place the Outdoor Campfyre™ enclosure at the installation location over the gas-supply pipe. The supply pipe should not protrude more than 3" up into the enclosure. Ensure the flex connector does not become kinked or damaged. Do not allow the unit to rest on it. FOR 05 SERIES MODELS; the controls must be within reach of a 110V GFI receptacle (for the power supply).
PAGE 13
CONNECTING THE GAS TO THE OUTDOOR CAMPFYRE™ 3. Make sure that the control knob on the manual unit (see Fig. 13-1), or the manual ON/OFF switch and remote ON/OFF switch on the remote unit (see Fig. 13-2 or 13-3), is in the OFF position as instruced below . Test for leaks at all connections. Access door LEAK TESTING Turn on the gas supply, ignite the burner, and test at all connections for leaks using a soapy water solution. If bubbles appear, a leak is present.
PAGE 14
INSTALLING/REPLACING BATTERIES CAUTION: ENSURE THE UNIT IS CONNECTED TO THE GAS LINE AND HAS BEEN TESTED FOR LEAKS BEFORE YOU INSERT BATTERIES. INSTALLING/REPLACING THE BATTERIES FOR THE MANUAL UNIT Fig. 14-1 The ignitor requires one "AA" battery (included). Fig. 14-2 1. Unscrew the plastic cover of the ignitor button and remove (Fig. 14-1). 2. Lift out spring and, if installed, the battery together, noting position of positive end of battery (Fig. 14-2). Remove and replace with new battery as needed.
PAGE 15
INSTALLATION OF THE OUTDOOR CAMPFYRE™ RING First, remove the ring from its packaging and make sure that it has not been damaged during shipping. Then follow the two simple steps below. CAUTION: Ring is heavy. Fire Ring Fire ring STEP 1: You must fix the ring permanently in place. To do this, apply a bead of high-temperature silicone (included) around the top of the Outdoor Campfyre™ base, just outside of the raised locator tags (Fig. 15-2). Fig.
PAGE 16
CONVERTING TO A DIFFERENT GAS TYPE To convert manual units from propane to natural gas or from natural to propane gas, carefully follow the steps below: 1. SHUT OFF THE GAS SUPPLY TO THE UNIT AND ANY NEARBY ELECTRICAL SOURCES OR APPLIANCES. 2. If present, remove all decorative media from the unit. 3. Remove the screws attaching the burner pan to your enclosure. 4. Detach the thermocouple (taking care not to kink it) from the safety valve (see Fig. 16-2 for location). 5.
PAGE 17
DECORATIVE MEDIA OPTIONS The unit has several options for decorative media, each with a different set of components and setup instructions. Find the section that pertains to your model and follow those setup instructions. Note: Lava media (included with burner) is always placed on the burner first in each option. This provides an important base for the diffusion of gas and air. OPTIONAL CAMPFYRE LOGS OCL-34 Item 1. 2. 3. 4. 5. 6. 7.
PAGE 18
OPTIONAL CAMPFYRE LOGS (cont.) Screen with lava on burner pan WARNING This screen must be clear and free of obstructions at all times to ensure proper operation (Fig. 18-1). DO NOT PLACE LAVA MEDIA ON THE SCREEN LAVA MEDIA PLACEMENT 1. FIRST, pour the 10 lb bag of lava granules into the burner pan, evenly covering the burner pan assembly with the exception of the screen. THEN, pour the 6 lb bag of lava coals into the burner pan, evenly covering the burner pan assembly with the exception of the screen.
PAGE 19
OPTIONAL BEACHWOOD LOGS AND/OR VOLCANIC STONE 2 4 8 3 1 Fig. 19-1 5 7 6 OCBW-34 # 1. 2. 3. 4. 5. 6. 7. 8. Description Knotted log Hooked log Crooked log Curved log Stripped log Long charred log Short charred log Volcanic stones (box) Part Number OCBWL-17 OCBWL-18 OCBWL-16 OCBWL-15 OCBWL-12 OCBWL-20 OCBWL-9 VS-25 Qty 1 1 1 1 1 1 1 1 Although log placement may vary, suggested log placement for the Beachwood log set is provided below.
PAGE 20
OPTIONAL BEACHWOOD LOGS (cont.) 6 CAUTION: CAMPFYRE OR DECORATIVE MEDIA WILL REMAIN HOT FOR SOME TIME AFTER USE. IF YOU NEED TO REPOSITION ANY DECORATIVE MEDIA, U S E H E AT- R E S I S TA N T GLOVES OR ALLOW TO COOL BEFORE HANDLING. 3 4 5 7 LOG PLACEMENT OPTION TWO - LOG SQUARE Fig. 20-1 1. Lay Log #1 across the volcanic stone, then lay the hooked part of Log #2 over one end of Log #1 at an angle of approximately 90 degrees (see Fig. 15-2). Beachwood Log Set p Other options 2.
PAGE 21
OPTIONAL GLASS/GEMS OR RIVER ROCK ON GLASS/GEMS Item 1. or 2. Description Glass (10 lb bag) Gems (10 lb bag) Box of river rock (optional) Part Number GL-10-x* GLG-10-x* STN-10 * Replace “x” in model number with the applicable glass/gem code for your chosen media. Glass and gems are available in various colors; contact your dealer for further details. Qty 2 1 1 Note: Installation is the same fo r g l a s s a n d g e m s . Glass shown here.
PAGE 22
LOG SET NOTES PAGE Please use this page to record any information about your log set that you may want to have at hand.
PAGE 23
OPERATING THE UNIT - LIGHTING AND EXTINGUISHING FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. C. Use only your hand to push in or move the controls. Never use tools. If the control will not push in or move by hand, DO NOT try to repair it. Call a qualified professional service technician. Force or attempted repair may result in fire or explosion. A.
PAGE 24
OPERATING THE UNIT - LIGHTING AND EXTINGUISHING POUR VOTRE SÛRETÉ, LISEZ AVANT L'ALLUMAGE AVERTISSEMENT: SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS EXACTEMENT, UNE INCENDIE OU UNE EXPLOSION PEUT RÉSULTER, ENTRAÎNANT DES DÉGATS MATÉRIELS, LE DOMMAGE CORPOREL, OU DES PERTES HUMAINES. C. Utilisez seulement votre main pour enfoncer ou pour déplacer les commandes. N'utilisez jamais les outils. Si la commande n'enfoncera pas ou ne se déplacera pas à la main, n'essayez pas de la réparer.
PAGE 25
OPERATING THE UNIT - LIGHTING AND EXTINGUISHING FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. A. BEFORE LIGHTING, smell all around the unit area for gas. Be sure to smell next to the floor, because some gas is heavier than air and will settle on the floor. B. WHAT TO DO IF YOU SMELL GAS 1. Shut off the gas to the appliance. 2. Extinguish any open flame. 3.
PAGE 26
FONCTIONNEMENT DE L'ÎLE UNITÉ - ÉCLAIRAGE ET S'ÉTEINDRE Pour votre sécurité lisez avant d’allumer Avertissement. Quiconque ne respecte pas a la lettre les instructions dans la présente notice risque de déclencher un incendie ou une explosion entraînant des dommages, des blessures ou la mort. AVANT DE S'ALLUMER, sentez tous autour de l'île unité secteur pour le gaz. Soyez sûr de sentir à côté de la terre, parce qu'un certain gaz est plus lourd que l'air et arrangera sur le plancher.
PAGE 27
OPERATING THE UNIT - LIGHTING AND EXTINGUISHING FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. A. BEFORE LIGHTING, smell all around the unit area for gas. Be sure to smell next to the floor, because some gas is heavier than air and will settle on the floor. B. WHAT TO DO IF YOU SMELL GAS 1. Shut off the gas to the appliance. 2. Extinguish any open flame. 3.
PAGE 28
FONCTIONNEMENT DE L'ÎLE UNITÉ - ÉCLAIRAGE ET S'ÉTEINDRE POUR VOTRE SÛRETÉ, LISEZ AVANT DE S’ALLUMER AVERTISSEMENT SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS EXACTEMENT, UNE INCENDIE OU UNE EXPLOSION PEUT RÉSULTER, ENTRAÎNANT DES DÉGATS MATÉRIELS, DES BLESSURES, OU LA PERTE DE LA VIE. A. AVANT DE S’ALLUMER, sentez tous autour du secteur extérieur de feu de camp pour le gaz. Soyez sûr de sentir à côté du plancher, parce qu’un certain gaz est plus lourd que l’air et arrangera sur le plancher. B.
PAGE 29
OPERATION Each installation site for any unit presents its own unique combustion environment. Specific factors such as weather, wind currents, yard debris, altitude, drafts, the size of the surrounding area, all have an influence on the proper operation of the unit. A normally operating unit will demonstrate the following characteristics: a) A lively, realistic yellow flame, b) Odor-free.
PAGE 30
PETERSON CAMPFYRE LIMITED WARRANTY THREE (3) YEAR LIMITED WARRANTY All Peterson Outdoor Campfyre logs, enclosures, and burner component parts, (except valves and controls) are covered by a three (3) year limited warranty. All Peterson valves and controls are covered by a separate one (1) year limited warranty (excluding batteries). A COPY OF YOUR SALES SLIP FOR PROOF OF PURCHASE IS REQUIRED This warranty applies to the original purchaser and to single family residential use only.