Owner`s manual

ManualsBrandsR.H. Peterson ManualsDomestic AppliancesG4-30PA-SS

Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746

Owner’s

Manual

Important: Read this manual carefully before starting installation of the log set.

CODE AND SUPPLY REQUIREMENTS

The installation and the provisions for combustion

and ventilation air must conform with local codes and

ordinances, or in the absence of local codes, with the

latest National Fuel Gas Code, ANSI Z223.1/NFPA 54,

the Natural Gas and Propane Installation Code, CSA

B149.1, or International Fuel Gas Code.

Regulated burner

system for use

with propane and

natural gas

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

This appliance is designed as an attended

appliance. Adults must be present when the

unit is operating. DO NOT leave this unit burning

when unattended. If this product is left burning

unattended it may cause damage or serious

injury.

Certiﬁ ed to:

ANSI Z21.60b

(CSA 2.26b)

ANSI Z21.97 Draft D

CAN1-2.21-M85

WARNING

Improper installation, adjustment, alteration,

service, or maintenance can cause injury or

property damage. Read the installation, operating

and maintenance instructions thoroughly before

installing or servicing this equipment.

The installation of appliances designed for manufactured

home (U.S. only) or mobile home installation must

conform with the Standard CAN/CSA Z240 MH, Mobile

Housing, in Canada, or with the Manufactured Home

Construction and Safety Standard, Title 24 CFR, Part

3280, in the United States, or when such a standard

is not applicable, ANSI/NCSBCS A225.1/NFPA 501A,

Manufactured Home Installations Standard.

Do not store or use gasoline or other

ﬂ ammable vapors and liquids in the vicinity

of this or any other appliance.

An LP-cylinder shall not be stored in the

vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.

• Do not touch any electrical switch; do

not use any phone in the building.

• Immediately call the gas supplier from

a neighbor’s phone and follow the gas

supplier’s instructions.

• If you cannot reach the gas supplier,

call the ﬁ re department.

WARNING

If the information in this manual is not followed

exactly, a ﬁ re or explosion may result, causing

property damage, personal injury, or loss of life.

Installation and service must be performed

by an NFI Certiﬁ ed or other qualiﬁ ed

professional installer, service agency, or

the gas supplier.

09-23

REV 2 - 100429952

L-A2-271

Models:

G4-18/20PA-SS

G4-18/20A-SS

G4-24PA-SS

G4-24A-SS

G4-30PA-SS

G4-30A-SS

G4 STAINLESS STEEL BURNER FOR INDOOR OR OUTDOOR USE

Summary of content (16 pages)

PAGE 1
Owner’s Manual Certified to: Models: ANSI Z21.60b (CSA 2.26b) G4-18/20PA-SS G4-18/20A-SS G4-24PA-SS G4-24A-SS G4-30PA-SS G4-30A-SS ANSI Z21.97 Draft D CAN1-2.21-M85 Regulated burner system for use with propane and natural gas G4 STAINLESS STEEL BURNER FOR INDOOR OR OUTDOOR USE Important: Read this manual carefully before starting installation of the log set.
PAGE 2
Manuel du propriétaire Modèles: Certifié à: G4-18/20PA-SS G4-18/20A-SS G4-24PA-SS G4-24A-SS G4-30PA-SS G4-30A-SS ANSI Z21.60b (CSA 2.26b) ANSI Z21.97 Draft D CAN1-2.21-M85 Système réglé de brûleur pour l'usage avec du propane et le gaz naturel BRÛLEUR À L'ACIER INOXYDABLE G4 POUR L'USAGE D'INTÉRIEUR OU EXTÉRIEUR Lisez ce manuel soigneusement avant de commencer l'installation de l'ensemble de notation.
PAGE 3
TABLE OF CONTENTS SAFETY INFORMATION PARTS LIST BEFORE YOU BEGIN - IMPORTANT INFORMATION INSTALLING THE DAMPER CLAMP INSTALLATION NOTES PAGE LOG PLACEMENT CHARRED SERIES SUPPLEMENTAL INSTRUCTIONS OPERATING THE LOG SET - LIGHTING AND EXTINGUISHING TECHNICAL DATA AND SPECIFICATION INFORMATION TROUBLESHOOTING THE GAS LOG SET WARRANTY 3 4 5 6 6 8 9 10 11 13 14 16 SAFETY INFORMATION 1.
PAGE 4
PARTS LIST Before beginning installation, be sure the gas log set is complete by comparing its contents with this PARTS LIST. The Golden Oak log set is listed and illustrated. The parts may differ depending upon the log style and size of the set. Be sure you know the model number and size of your set when ordering replacement or optional parts and accessories. 9 6 4 Large adapter 9a Replacement parts can be ordered from your local dealer.
PAGE 5
BEFORE YOU BEGIN - IMPORTANT INFORMATION Before You Begin, review the information and BEFORE YOU BEGIN - IMPORTANT safeguards below about the installation and operation ® of the Real-Fyre gas log set. Fig. 5-1 Check to be sure that the fireplace meets the venting and construction requirements for the installation of the Real-Fyre® gas log set. Rear width THIS BURNER IS DESIGNED FOR USE WITH PROPANE OR NATURAL GAS.
PAGE 6
INSTALLING THE DAMPER CLAMP A damper clamp is provided as a means to prevent full 4. Should the damper clamp not fit, install a permanent damper stop or provide some other means of and/or accidental closure of the fireplace damper when installed as illustrated (Fig. 6-2). When the gas log set preventing full and/or accidental closure of the damper. is operating, the damper must be fully open. To install the damper clamp: 1. Open the fireplace damper. 2. Place the damper clamp over the damper blade (Fig.
PAGE 7
INSTALLATION (cont.) CONNECTING THE GAS SUPPLY 1. With the burner pan off and properly positioned in the fireplace, fill the burner pan completely with the granules. Avoid spilling the granules on the Peterson control, if one is in place. 1. The burner pan is supplied with an air mixer for propane gas or a fuel injector for natural gas. The air mixer or fuel injector must be used in ALL installations.
PAGE 8
NOTES PAGE REV 2 - 100429952 8 L-A2-271
PAGE 9
LOG PLACEMENT The beauty and design of the Real-Fyre® gas logs are the result of skilled craftsmanship, research, and engineering. The fine quality materials used to mold the logs are formulated from kiln-fired ceramics, superior refractories and the best expanded shales and aggregates, exactly proportioned. Added to this material are steel reinforcing rods, precisely sized and designed to prevent breakage. This creates realistic, long-lasting logs.
PAGE 10
CHARRED SERIES SUPPLEMENTAL INSTRUCTIONS These instructions must be used with the Charred series gas log set series EMBER COALS PLACEMENT Attach the ember bed to the burner by slipping it onto the back edge (center left to right) with the perforated section facing towards the back fireplace wall. Fig. 10-1 Ember bed Part No. CHD-01 Cover the surface of the ember bed with the ember coals (Fig. 10-1).
PAGE 11
OPERATING THE LOG SET - LIGHTING AND EXTINGUISHING FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may result, causing property damage, personal injury, or loss of life. A. BEFORE LIGHTING, smell all around the gas log set area for gas. Be sure to smell next to the floor because some gas is heavier than air and will settle on the floor. B. IF YOU SMELL GAS: • Shut off the gas to the appliance. • Extinguish any open flame.
PAGE 12
ACTIONNANT LA NOTATION RÉGLÉE - ÉCLAIRAGE ET S'ÉTEIGNANT POUR VOTRE SÛRETÉ, LISEZ AVANT L'ALLUMAGE AVERTISSEMENT: Si vous ne suivez pas ces instructions exactement, une incendie ou une explosion peut résulter, entraînant des dégats matériels, le dommage corporel, ou des pertes humaines. A. AVANT L'ALLUMAGE, sentez tous autour du secteur réglé de notation de gaz pour le gaz. Soyez sûr de sentir à côté du plancher parce qu'un certain gaz est plus lourd que l'air et arrangerez sur le plancher. B.
PAGE 13
TECHNICAL DATA AND SPECIFICATION INFORMATION MAINTENANCE SERVICE Once installed and operating properly, the RealFyre® gas log set requires very little maintenance. You should inspect the log set and control annually for the following: 1. Excessive sooting - Some sooting of the log set is normal and adds to the appearance of burned wood. If sooting accumulates, you may brush the soot off with a stiff brush. Do not use water or soot cleaners to clean off the soot.
PAGE 14
TROUBLESHOOTING THE GAS LOG SET SYMPTOM 1. Excessive smoking and sooting CAUSE A. Poor draft or down draft Note: Like burning natural firewood, the RealFyre® gas log set is designed to burn with a yellow smoky flame. Some sooting is common and desirable. B. Improper set for gas used C. Damper closed D. Set is positioned too close to the front of the firebox E. Improper log placement F. Flue is less than 8" in diameter 2. Low flame G. Air mixer on propane set is closed A.
PAGE 15
TROUBLESHOOTING THE GAS LOG SET (cont.) SYMPTOM 3. Uneven flame distribution (Lower at one end of the burner) 4. Flame backing out of air mixer (propane) REV 2 - 100429952 CAUSE A. Clogged or blocked portholes A. B. Insufficient gas pressure and/or supply C. Granules may be packed down too tightly or not evenly B. D. Auxiliary shut-off valve partially closed D. E. Valve not fully open A. Clogged or blocked portholes E. A. B. Insufficient gas pressure and/or supply C.
PAGE 16
WARRANTY PETERSON VENTED GAS LOG SETS LIMITED WARRANTY All Peterson gas logs are WARRANTED for as long as you own them (lifetime). All Peterson burner assemblies are WARRANTED for TEN (10) YEARS. SPK-26 controls are covered by a THREE (3) YEAR “All Parts” Warranty. All other Peterson valves, pilots, and controls are covered by a ONE (1) YEAR Limited Warranty (excluding batteries).