F5: Epoxies SAFETY DATA SHEET (Complies with OSHA 29 CFR 1910.
Causes skin and eye irritation May cause cancer Wash skin thoroughly after handling Avoid breathing fume/gas/mist/vapors/spray Wear protective gloves/ protective clothing/ eye protection/ face protection Use outdoors or in a well-ventilated area Primary Route of Exposure Eyes, skin and oral Carcinogenicity This product or one of its ingredients present at 0.1% or more IS listed as a carcinogen or suspect carcinogen by NTP, IARC, Prop 65 or OSHA.
Immediately seek medical advice or attention if symptoms are significant or persist. SECTION V - FIRE FIGHTING MEASURES Flash Point: 149oC (>300oF) Flammable Limits: N/A Extinguisher Media: Carbon Dioxide, Dry Chemical, Water Fog Unusual Fire and Explosion Hazard: None known. Thermal Decomposition can be formed. Special Fire Fighting Procedures: Firefighters must wear self-contained breathing apparatus and full protective clothing to prevent contact with toxic and/or irritating fumes.
Engineering Measures: Use local and general exhaust ventilation to maintain airborne concentrations below TLV. Suitable respiratory equipment should be used in cases of insufficient ventilation or where operational procedures demand it. Personal Protective Equipment Respiratory Protection None normally required. Use a NIOSH approved organic vapor chemical cartridge respirator when air movement is inadequate to control vapor build-up.
Conditions to avoid: Exposure to excessive heat and storage above 35°C (95°F) will shorten shelf life. SECTION XI – TOXICOLOGICAL INFORMATION Acute Oral Toxicity: Not Determined Acute Dermal Toxicity: Not Determined Acute Inhalation Toxicity: Not Determined Skin Irritation: Irritating to skin The product has not been tested. The statement has been derived from the properties of the individual components. Eye Irritation: Irritating to eyes. The product has not been tested.
This product contains a chemical or chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. SECTION XII – ECOLOGICAL INFORMATION Fish: Diglycidyl Ether of Bisphenol A: Fathead minnow/LC50 (96hrs): >3.1mg/l Aquatic Invertebrates: Diglycidyl Ether of Bisphenol A: Water Flea Daphnis/EC 50 (48hrs): > 1.4mg/l Algae: No Data Available Microorganisms: Diglycidyl Ether of Bisphenol A: Bacteria, (Growth inhibition)/IC50 (18hrs): > 42.
HMIS Rating Health Flammability Physical Hazard PPE NFPA Rating 1 1 0 B Hazard Rating: 0 = minimal, 1 = Slight, 2 = moderate, 3 = severe, 4 = extreme Federal Regulations CERCLA RQ SARA Title 311/312 Not Determined CA Prop 65 This product contains a chemical or chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
is subject to our standard terms and conditions, a copy if which is available upon request. This company warrants only that its products meet the specifications stated in the sales contract. Typical properties, where stated, are to be considered as representative of current production and should not be treated as specifications.
F5: Epoxies SAFETY DATA SHEET (Complies with OSHA 29 CFR 1910.
Hazard statement(s) Causes skin burns Causes severe eye damage Suspected of damaging fertility May cause cancer May be harmful if inhaled Wash skin thoroughly after handling Avoid breathing fume/gas/mist/vapors/spray Wear protective gloves/ protective clothing/ eye protection/ face protection Use outdoors or in a well-ventilated area Avoid contact during pregnancy/while nursing Primary Route of Exposure Eyes, skin and oral Carcinogenicity This product or one of its ingredients present at 0.
Skin: Remove contaminated clothing. Wash with mild soap and water. Get medical attention if skin irritation or dermatitis persists. Ingestion: Give plenty of water. DO NOT induce vomiting. Call a physician immediately. Other: Referral to a physician is recommended if there is any question about the seriousness of the injury/exposure. If sensitization occurs, future contact with the material should be avoided.
Exposure Guidelines Component Ethylene Glycol Quartz Silica Sand (Crystalline Silica) Benzyl Alcohol CAS# 10721-1 1480860-7 OSHA PEL TLV 50ppm (Ceiling) 100 mg/ m3 (Ceiling) 3 0.1 mg/m 0.025 mg/m3 10051-6 50ppm (Ceiling) 100 mg/m3 Engineering Measures: Use local and general exhaust ventilation to maintain airborne concentrations below TLV. Suitable respiratory equipment should be used in cases of insufficient ventilation or where operational procedures demand it.
Specific Gravity(g/cc): Vapor Density(air = 1): Vapor Pressure: VOC Content: pH: Boiling Point: N/A Non-Volatile N/A 1 g/L (tested per EPA CFR 40, Part 63, Subpart PPPP, Appendix A) 47 g/L (tested per EPA CFR 40, Part 60, method 24) N/D N/A SECTION X – STABILITY AND REACTIVITY Stability: Stable Thermal Decomposition: Incompatibility: Can yield CO, CO2 and organic Nitrogen compounds.
Sensitization: May cause allergic skin reaction and irritation to the respiratory system. The product has not been tested. The statement has been derived from the properties of the individual components. Carcinogenicity Classification: Quartz Silica Sand (Crystalline Silica): IARC Group1: Known human carcinogen based on human evidence. NTP (National Toxicology Program) has classified Crystalline Silica as a known human carcinogen.
SECTION XV – OTHER REGULATORY INFORMATION HMIS Rating Health Flammability Physical Hazard PPE NFPA Rating *3 1 0 B Hazard Rating: 0 = minimal, 1 = Slight, 2 = moderate, 3 = severe, 4 = extreme Federal Regulations CERCLA RQ 5000 lbs CAS 107-21-1 Chemical Name Ethylene Glycol SARA Title 311/312 Chronic Health Hazard CA Prop 65 This product contains a chemical or chemicals known to the State of California to cause cancer, birth defects or other reproductive harm.
MANUFACTURER DISCLAIMER: This SDS to the best of our knowledge conforms to the requirements of OSHA 29 CFR 1910.1200, 91/155/EEC and summarizes the health and safety hazard information and general guidance on how to safety handle the material at the date of issue. Each user must review the SDS in the context of how the product will be handled and used in the workplace.
