SDS

ManualsBrandsQuikrete ManualsBuilding materials80 lbs. Type M Masonry Cement

ONE SECURITIES CENTRE, 3490 PIEDMONT ROAD, SUITE 1300, ATLANTA, GA 30305 SDS D2 TEL 404-634-9100 WWW.QUIKRETE.COM

Page 1 of 12

D2: Packaged Raw Materials

SAFETY DATA SHEET

(Complies with OSHA 29 CFR 1910.1200)

SECTION I: PRODUCT IDENTIFICATION

The QUIKRETE

Companies Emergency Telephone Number

One Securities Centre (770) 216-9580

3490 Piedmont Road, Suite 1300 Information Telephone Number

Atlanta, GA 30305 (770) 216-9580

SDS D2

Revision: May-16

QUIKRETE

Product Name Code #

MASONRY CEMENT-TYPE S 1125-71

MASONRY

CEMENT-TYPE N 1125-70

MASONRY

CEMENT-TYPE M 1125-81

PLASTIC

CEMENT 2121-94

MCS

CEMENT TYPE MORTAR S (34 KG) 4013-00

PREMIUM

PLASTERING CEMENT 1125-98

ALL-STAR

MASONRY CEMENT 1121

QUIKRETE®

PORTLAND/LIME CEMENT, GRAY TYPE S 1125-20

QUIKRETE®

PORTLAND/LIME CEMENT, WHITE TYPE N 1124-06

ZIA

MASONRY CEMENT

PRODUCT

USE: HYDRAULIC SPECIALTY CEMENTS FOR USE IN MASONRY MORTARS AND STUCCOS

SECTION II - HAZARD IDENTIFICATION

Hazard-determining components of labeling: Silica, Portland cement

2.1 Classification of the substance or mixture

Carcinogen – Category 1A

Skin Corrosion – Category 1B

Skin Sensitization – Category 1B

Specific Target Organ Toxicity Repeat Exposure – Category 1

Specific Target Organ Toxicity: Single Exposure – Category 3

2.2a Signal word DANGER!

2.2b Hazard Statements

Summary of content (12 pages)

PAGE 1
D2: Packaged Raw Materials SAFETY DATA SHEET (Complies with OSHA 29 CFR 1910.
PAGE 2
May cause cancer through chronic inhalation Causes severe skin burns and serious eye damage May cause an allergic skin reaction Causes damage to lungs through prolonged or repeated inhalation May cause respiratory irritation 2.2c Pictograms 2.2d Precautionary statements Do not handle until all safety precautions have been read and understood. Wear impervious gloves, such as nitrile. Wear eye protection, and protective clothing. Do not eat, drink or smoke when using this product.
PAGE 3
product from body and thoroughly rinse with water. If you experience or suspect a cement burn or inflammation you should immediately see a health care professional. Skin burns and irritation may be caused by brief exposure, though often are caused by extended exposure of 15 minutes, an hour, or longer. Interaction of Portland cement with water or sweat releases a caustic solution which produces the burns or irritation.
PAGE 4
Portland Cement Limestone Sand, Silica, Quartz 65997-15-1 1317-65-3 14808-60-7 60-80 20-40 <1 *The concentrations ranges are provided due to batch-to-batch variability. None of the constituents of this material are of unknown toxicity. SECTION IV – FIRST AID MEASURES 4.1 Description of the first-aid measures General information: After inhalation: Remove person to fresh air. If breathing is difficult, administer oxygen. If not breathing, give artificial respiration.
PAGE 5
changes in the normal condition of the skin. Signs and symptoms of burns include the above and whitening, yellowing, blackening, peeling or cracking of skin. The Portland cement in this product may cause allergic contact dermatitis in sensitized individuals. This overreaction of the immune system can lead to severe inflammation. Sensitization may result from a single exposure to the low levels of Cr (VI) in Portland cement or repeated exposures over months or years.
PAGE 6
7.1 Handling Precautions for safe handling: Ensure good ventilation/exhaustion at the workplace. DO NOT BREATHE DUST. In dusty environments, the use of an OSHA, MSHA or NIOSH approved respirator and tight fitting goggles is recommended. Wear appropriate PPE (See section 8).Do not mix with other chemical products, except as indicated by the manufacturer. Do not get in eyes, on skin or clothing. Good housekeeping is important to prevent accumulation of dust. 7.
PAGE 7
A NIOSH-approved dust mask or filtering face piece is recommended in poorly ventilated areas or when permissible exposure limits may be exceeded. Respirators should be selected by and used under the direction of a trained health and safety professional, following requirements found in OSHA’s respirator standard (29 CFR 1910.134) and ANSI’s standard for respiratory protection (Z88.2).
PAGE 8
11.2 Symptoms related to physical/chemical/toxicological characteristics: Inhalation: May cause respiratory tract irritation. Causes damage to organs through prolonged or repeated exposure. This product contains crystalline silica. Prolonged or repeated inhalation of respirable silica from this product can cause silicosis. Skin contact: Causes skin irritation. Handling can cause dry skin, discomfort, irritation, and dermatitis. May cause sensitization by skin contact.
PAGE 9
No further relevant information available. 12.3 Bioaccumulative potential: No further relevant information available. 12.4 Mobility in soil No further relevant information available. 12.5 Other Adverse Effects No further relevant information available. SECTION XIII – DISPOSAL CONSIDERATIONS 13.1 Waste Disposal Method The packaging and material may be land filled; however, material should be covered to minimize generation of airborne dust.
PAGE 10
15.1 Safety, Health and Environmental Regulations/Legislations specific for the chemical Canada WHMIS Classification: Considered to be a hazardous material under the Hazardous Products Act as defined by the Controlled Products Regulations and subject to the requirements of Health Canada’s Workplace Hazardous Material Information (WHMIS). This document complies with the WHMIS requirements of the Hazardous Products Act (HPA) and the CPR. 15.
PAGE 11
15.4 Global Inventories DSL All components of this product are on the Canadian DSL list. TSCA No.: Crystalline silica (quartz) appears on the EPA TSCA inventory under the CAS No. 14808-60-7. All constituents are listed in the TSCA inventory. 15.5 NFPA Ratings SECTION XVI – OTHER INFORMATION Last Updated: May 4, 2016 NOTE: The information and recommendations contained herein are based upon data believed to be correct.
PAGE 12
Phone (800) 282-5828 www.QUIKRETE.com End of SDS ONE SECURITIES CENTRE, 3490 PIEDMONT ROAD, SUITE 1300, ATLANTA, GA 30305 Page 12 of 12 SDS D2 TEL 404-634-9100 WWW.QUIKRETE.