Instructions / Assembly

QuickJack Portable Car Jack 28 P/N 5900959 — Rev. H — May 2018
Operation
This section describes how to operate your QuickJack.
QuickJack recommends using Vehicle Lifting Points for Frame-Engaging Lifts for proper positioning of
Vehicles on your QuickJack. It shows the factory-recommended Lifting Points for a wide variety of
Vehicles. It is available from the Automotive Lift Institute (ALI) website at autolift.org/ali-store/.
⚠ WARNING Improper positioning of a Vehicle could lead to it being unstable and potentially
falling off the QuickJack. This could damage the Vehicle, damage the QuickJack,
and potentially injure anyone underneath.
Safety
Before you raise or lower a Vehicle using your QuickJack:
• Check the QuickJack. Check the QuickJack for any missing, heavily worn, or damaged parts.
Make sure the Lift Blocks are in their Receiver Trays. Do not operate the QuickJack if you find any
issues; instead, take it out of service, then visit support.quickjack.com, email
[e-mail], or call [phone].
• Check the area. Check the area around the QuickJack for obstructions; anything that might
impact the raising or lowering of the Vehicle. Do not forget to check
above the QuickJack. If you
find an obstruction, move it out of the way. Do not allow people or animals near the QuickJack
while it is in motion.
• Check the operators. Make sure everyone who is going to operate the QuickJack has been
trained in its use, has read the labels on the unit, and has read the manual. Only the operator
should be near the QuickJack when it is in motion.
• Check for safety. Make sure everyone who is going to be walking near the QuickJack is aware
of its presence and takes appropriate safety measures.
When raising the QuickJack, do not
leave it until it is engaged on a locking position
. When lowering the QuickJack, do not
leave it until it is on the ground. Do not allow children to operate the QuickJack. Do not allow
anyone under the influence of drugs or alcohol to operate the QuickJack.
Do not work under an elevated Vehicle unless properly rated Vehicle Jack Stands are in place
under the factory-recommended Lifting Points.
• Check the Vehicle. Never exceed the QuickJack’s weight rating. Do not allow people inside a
Vehicle you are going to raise. Make sure the Vehicle is not overbalanced on either end. You must
use the factory-recommended Lifting Points for the Vehicle. Never raise just one side, one corner,
or one end of a Vehicle.