The Goose Warning Line Stanchion Guardian Part #15225 USER’S MANUAL DO NOT THROW AWAY THESE INSTRUCTIONS! READ AND UNDERSTAND BEFORE USING EQUIPMENT! Guardian Fall Protection Kent, WA 800-466-6385 www.guardianfall.
TABLE OF CONTENTS: INTRODUCTION……………………………………………………………………………………………………………...... USER INFORMATION………………………………………………………………………………………………………... GENERAL SYSTEM SELECTION CRITERIA……………………………………………………………………………. TRAINING REQUIREMENTS…………………………………………………………………………………………..….. RESCUE PLAN……………………………………………………………………………………………………………………. DESCRIPTION OF THE GOOSE WARNING LINE STANCHION…………………………………………...….
USER INFORMATION: Date of First Use ________________________________ Serial # _______________________________________ Trainer _______________________________________ User __________________________________________ GENERAL SYSTEM SELECTION CRITERIA: Selection of fall protection shall be made by a Competent Person. All fall protection equipment shall be purchased new and unused. The equipment is designed for use as a part of a personal fall protection system.
TRAINING REQUIREMENTS: The employer must ensure that each employee who might be exposed to fall hazards has been trained by a Competent or Qualified Person. The training program must include the following: The ability to recognize the hazards of falling The procedures to be followed in order to minimize these hazards.
INSPECTION: Before each use, the worker must inspect all fall protection equipment. A formal inspection must be made by a Competent or Qualified Person other than the user at least every six months. Record the results of these inspections in the Inspection Log in the back of this manual. Visually inspect all components of the Goose Warning Line Stanchion, looking for any signs corrosion, bending, cracks, or deformations.
APPLICABLE STANDARDS: The Goose Warning Line Stanchions, when installed properly, meet OSHA 1926.501 and OSHA 1926.502(f) requirements for Goose Warning Line Stanchions. Consult regulatory agencies for more information on personal fall arrest systems and associated components. WARNING! Guardian Fall Protection equipment is designed to be used with Guardian approved components. Please contact Guardian if you have a question regarding compatibility.
WARNING! Install the Goose Warning Line Stanchion system according to manufacturer’s instructions & recommendations in an OSHA compliant manner. Serious injury can occur if instructions are not followed. BEFORE INSTALLING THE GOOSE WARNING LINE STANCHIONS: Before installation, plan your system. Consider all factors that will affect your safety during use of this equipment. The following list give important points to consider when planning your system.
THE GOOSE WARNING LINE STANCHION INSTALLATION cont.: DO NOT LEAN on any portion of the Goose Warning Line Stanchion at any time. Flags shall be rigged so that its lowest point is no less than 34” and its highest point is no more than 39” from the walking surface. The Warning Line System is designed to meet OSHA regulations. Warning Line Systems are NOT designed for hoisting or tie off of any other equipment or persons. Place the Goose Warning Line Stanchion on the ground.
THE GOOSE WARNING LINE STANCHION INSTALLATION cont.: To install as permanent warning lines, use #12 Powers Screws to screw into place. To uninstall the Goose Warning Line Stanchions, unscrew if necessary, pull each leg out, pull the leg up, and it should close. For further information regarding warning line systems, please refer to OSHA 1926.502 (f) LABELS: These labels must be present and legible on the Goose Warning Line Stanchion at all times.
INSPECTION LOG: USER MUST INSPECT EQUIPMENT BEFORE EACH USE. COMPETENT PERSON TO INSPECT AND INITIAL AT LEAST EVERY 6 MONTHS. Date of First Use_________________ YR. J F M A M J J A S O N D This is a permanent system and does not expire. However a semi-annual inspection is required. “WE PUT OUR NAME ON THE PRODUCT BECAUSE YOU PUT YOUR LIFE ON THE LINE” Guardian Fall Protection, Inc. 800-466-6385 th 26609 79 Ave. S. Kent, WA 98032 www.guardianfall.