Owner`s manual

R
May 12, 2014
7050-128G
Page 3
Santa Fe Pellet Stove
Section 1: Listing and Code Approvals
A. Appliance Certifi cations ......................4
B. Mobile Home Approved ......................4
C. Glass Specifi cations ............................4
D. Electrical Rating ..................................4
E. BTU & Effi ciency Specifi cations ..........4
Section 2: Getting Started
A. Design, Installation & Location
Considerations ....................................5
B. Locating Your Appliance & Chimney ..6
C. Thermostat Location ...........................6
D. Draft ....................................................6
E. Negative Pressure ..............................6
F. Avoiding Smoke and Odors ................7
G. Fire Safety ..........................................8
H. Tools & Supplies Needed ...................8
I. Inspect Appliance & Components
and Pre-Use Check List ......................8
Section 3: Dimensions & Clearances
A. Appliance Dimensions ........................9
B. Clearances to Combustibles ...............10
C. Hearth Requirements..........................11
Section 4: Vent Information
A. Chimney & Exhaust Connection .........12
B. Venting Termination Requirements ....12
C. Pellet Venting Chart ............................13
Section 5: Venting Systems
A. Alcove .................................................14
B. Vertical - Interior ..................................15
C. Through the Wall & Vertical - External 15
D.
Vertical Into Existing Class A Chimney 15
E. Masonry ..............................................16
F. Alternate Masonry ...............................16
G. Through the Wall .................................17
Section 6: Mobile Home .................................. 18
Section 7: Appliance Set-Up
A. Outside Air Kit .....................................19
B. Top Vent Adapter ................................20
C. Rear Vent Adapter ..............................21
D. Optional Grille Installation.....................21
E. Log Set Placement ..............................22
F. Thermostat Installation ........................22
Section 8: Operating Instructions
A. Combustible & Non-Combustible
Material ...............................................23
B. Fuel Size, Material & Storage .............23
C. General Operation Information ...........24
D. Before Your First Fire .........................24
E. Starting Your First Fire ........................24
F. Fire Characteristics .............................25
G. Feed Rate Adjustment .......................25
H. Ignition Cycles ....................................25
I. Frequently Asked Questions...............26
Section 9: Troubleshooting ............................27-29
Section 10: Maintaining & Servicing Appliance
A. Proper Shutdown Procedure ...............30
B. Quick Reference Maintenance Guide ........30
C. General Maintenance & Cleaning .......30-33
D. High Ash Fuel Content Maintenance ..34
E. Soot or Creosote Fire ..........................34
F. Blower & Snap Disc #2 Replacement .35-36
G. Igniter Replacement ............................37
H. Baffl e & Brick Removal .......................37
I. Baffl e & Brick Replacement ................38
J. Glass Replacement .............................39
K. Broken/Damaged Component ............39
Section 11: Reference Material
A. Component Functions.........................40-41
B. Component Locations .........................42
C. Service & Maintenance Log ................43-44
E. Warranty Policy ...................................45-46
G. Contact Information .............................48
TABLE OF CONTENTS
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the fi replace or to property.