Owner`s manual

28 7034-276 January 29, 2014
MT. VERNON AE
A. Glass Replacement - Door Assembly
(Replace with 5mm ceramic glass only)
a. Swing open the face and remove the door from the
appliancebyliftingthedooroffofthehingepinsandlay
onaatsurfacefacedown.
b. Using a Phillips head screw driver, remove 4 screws, 2
onthetopand2onthebottom.Removemetalbracket
and then remove the glass. Figure 28.1.
c. Replacewithnewglasswithgasket.
d. Re-attachmetalbracketwith4screws.
e. Re-install door over hinge pins and close face.
CAUTION!
Handleglasswithcare.
• Inspectthegaskettoensureitisundamaged.
• DoNOTstrike,slamorscratchglass.
• DoNOToperateappliancewithglass&doorassembly
removed.
• DoNOToperatewithglasscracked,brokenor
scratched.
6 Service Parts Replacement
• Glassis5mmthickhightemperatureheat-re-
sistant ceramic glass.
• DONOTREPLACEwithanyothermaterial.
• Alternatematerialmayshatterandcause
injury.
WARNING
Remove 4 screws
Glass with Gasket
Metal Bracket
Figure 28.1
B.BafeRemoval
a. Theappliancemustbeincompleteshutdown,completely
coolandtheexhaustbloweroff.
b. Opendoor.
c. Thebafeislocatedatthetopinsideofrebox.
d. Removebafebyplacingaatheadscrewdriverintothe
slot of the latches located in the upper corners and push
down.Thebottomofthelatch will fall forward offof the
post.Liftthebafeupandthenouttowardyou.Figure
28.2.
e. Toreplacethebafe,placethe2locatingearsbehindthe
bottomedgeandtiltthebafeupandintoplace.
f. Thebafemustbecenteredinthereboxbeforelatching
itinplace.Ifitisnotcenteredthelatchistrappedbetween
thebafeandsideofthereboxinsteadoflatchingprop-
erly.
g. Thebottomofthelatcheswilltovertheposts.Pushthe
topofthelatchforwardtolocklatchintoplace.
WARNING
Cast iron is a very heavy material. Thebafeis
madeofcastironandthereforeisheavyandawkward
attimestomaneuver.Clearandprepareyourwork
areabeforeyoubegin.
Baffle
Latches
Insert flat head screw driver into “V”
section and push down and the bottom
of the latch will fall forward off of post
Locating ears - 1 on
each side. Fit behind
bottom edge.
Figure 28.2