Owner`s manual

January 29, 2014 7034-276 25
MT. VERNON AE
Clean-Out Cover
Figure 25.1
Handleglassassemblywithcare.
When cleaning glass door:
• Avoidstriking,scratchingorslamming
glass.
CAUTION
• DoNOTcleanglasswhenhot.
• DoNOTuseabrasivecleaners.
• Useahardwaterdepositglasscleaneronwhitelm.
Refer to maintenance instructions.
Handle glass doors with care.
• Inspectthegaskettoensureitis
undamaged.
• DoNOTstrike,slamorscratchglass.
• DoNOToperateappliancewithglassdoor
removed,cracked,brokenorscratched.
WARNING
9. Door Latch Inspection
• Frequency: Prior to heating season
• By: Homeowner
Thedoorlatchisnon-adjustablebutthegasketingbetween
theglassandreboxshouldbeinspectedperiodicallytomake
surethereisagoodseal.Ifthegasketisfrayedordamaged,
replace with a new one.
10. Cleaning Exhaust Blower - Requires No
Lubrication
• Frequency: Yearly or as needed
• By: Homeowner
 a.BesurethewallcontrolscreensaysOFFandthe
appliance is allowed to cool.
 b. Useasoftbrushandvacuumtocleanthepropellers.
11. Cleaning Convection Blower - Requires No
Lubrication
• Frequency: Yearly or as needed
• By: Homeowner
 a.BesurethewallcontrolscreensaysOFFandthe
appliance is allowed to cool.
 b.Useasoftbrushandvacuumtocleanthepropellers.
12. Cleaning the Top Vent Adapter (if installed)
• Frequency: As Needed
• By: Homeowner
a. BesurethewallcontrolscreensaysOFFandthe
appliance is allowed to cool.
b. Openthecleanoutcover. Figure 25.1.
c. Sweepoutanyashbuild-up.
7. Cleaning the Hopper
• Frequency:Monthlyorafterburning1tonoffuel, 
 (aprx50bags)orwhenchangingfueltypes
• By: Homeowner
a. BesurethewallcontrolscreensaysOFFandtheappliance
is allowed to cool.
b. Afterburningapproximately1tonoffuelyouwillneedto
cleanthehoppertopreventsawdustand/ornesbuild-up.
c. Acombinationofsawdust/nesandpelletsontheauger
reducestheamountoffuelsupplytotherepot.
d. This can result in nuisance shut downs and mis-starts
 •. Emptythehopperofanyremainingpellets.
 •. Vacuumthehopperandfeedtube.
8. Cleaning the Glass
• Frequency:Whenclearviewofrepotbecomes
 obscure
• By: Homeowner
 a. Be sure the wall control screen says OFF and the
appliance is allowed to cool.
 b. Cleanglasswithanon-abrasivecommerciallyavailable
cleaner. Wipe down with dry towel.