Owner`s manual

December 16, 2011
7037-135H
Page21
4300 Wood Stove Series (ACC)
R
7
Appliance Set Up
Figure 21.3

DoNOToperatebeforefullyassemblingcomponents.
Burningyourstovewithoutapedestalorlegkit
attached:
• Willvoidyourwarranty.
• Mayresultinpropertydamageorpersonalinjury.
WARNING
NOTE: The Ash Removal System, must be
installed rst before installing the pedestal.
A. Pedestal Assembly and Ash Removal
System (ARS) Installation for Step Top
Uni-body
Doorhandlemustbe
inopenpositionto
tightensetscrew
SetScrew
(alignwithflat
sideofrod)
AshDoorRodshown
ininstalledposition
2
2
Remove 2 bricks for
installation and then re-install
ARS Cover
Figure 21.1
Figure 21.2
Included in Kit:  Door assembly, door handle & magnet,
ashdrawer,fastenerpackage.Acoverplatethatisrequired
foraooroutsideairinstallationonapedestalmodelisalso
included,Ifnotneeded,discard.
Tools Required:  Phillips head screwdriver, 7/16 socket
wrench,3/32and5/36Allenwrench.
Begin installing the ARS System.
1. Remove2frontbricksasshowninFigure 21.1.
2. Laybodyofstoveonitsbackonaprotectivepadorpallet.
3. Remove the 2 nuts and 2 bolts holding the channel in
place and set the channel aside.  Discard the 2 nuts.
I nstallthegasketoverthe8protrudingscrews.
Theglossysideofthegasketneedstogoagainsttherebox
bottom.
It is important the gasket is not put on upside
down as it could compromise its sealing capa-
bilities.Figure 21.2.
4. Installashdoorassemblybyslidingtherodatanangle
into the slot onthe left side. As the rod starts passing
throughtheslot,slidethehandleovertherodandthen
nishpushingtherodthroughtheslot.
Slidetheashdooroverthe8screwsprotrudingfromthe
bottomofthestove.Securewithnutsandwasherspro-
vided. Figure 21.2.
5. Re-installhandleusinga3/32Allenwrenchtotightenthe
setscrewinthedoorhandle.Thesetscrewneedstobe
snug. Figure 21.3.
6. Install magnet using a Phillips head screwdriver.  This
magnet will hold the door handle in an open position
whichinturnholdstheashdooropensoashescanbe
brushedintotheashdrawer.Figure 21.2.
Glossy side of
Gasket
against firebox
bottom
Start sliding rod at
an angle into slot,
slide handle over rod
and then finish
pushing through slot.
Ash Door
Assembly
Magnet
Lay stove flat on
protective padding or
pallet
Door Handle