Installation guide

2
magicolor
6100 Print System
!""# $

Caution:
Do not hold the toner cartridge
vertically.
Remove the toner
cartridges from their
shipping cartons.
Holding a cartridge with
both hands, gently rock it
five or six times
horizontally.
Pull the tab to remove the
tape.
Remove the orange
protective cover from each
cartridge.
Press the front cover latch
on the upper-right side of
the printer and open the
printer’s front cover.
Align the toner cartridge
with the cartridge guides.
Gently push the cartridge
into the printer.

Caution:
Each toner
cartridge has a colored
label that corresponds
to a colored label to the
right of the cartridge
slots. Always install the
toner cartridge in the
slot with a label of the
same color.
Install the other toner
cartridges.
»Note:
Leave the printer’s front cover in the open position while installing the
OPC Belt Cartridge as described in the next section.
%!""& " $

Caution:
The OPC belt is extremely sensitive to bright light and touch. Always leave it in its protective box until you’re ready to install it. Any exposure to light
should be limited to less than two minutes or permanent damage could result. Always handle the cartridge by its sides so you don’t touch the surface of the belt.
Rotate up the two lock
levers to prepare the
opening for the cartridge.

Caution
:
Make sure the
printer’s front cover is
still open.
Pull out the two tension-
release pins (one on each
side of the cartridge).
Remove the protective
sheet from the cartridge.
»Note:
The white powder
lubricant on a new OPC
belt is normal; it won’t
affect quality.
Holding the cartridge above
the printer, align the guide
pins on the cartridge with
the guide slots in the lock
levers.
The green surface of the
cartridge faces you.

Caution:
When
lowering the cartridge
into the guide slots, the
metal contact on the
lower left side of the
cartridge should be
aligned outside of the
left guide slot.
Gently guide the cartridge
into the printer.
Rotate the two lock levers
toward the back of the
printer to secure the
cartridge in the printer.
1

2
3

4
5


#$#%
1 2

3
4
EDNord - Istedgade 37A - 9000 Aalborg - telefon [phone]