Operating instructions

4 Installation and Operating Instructions
Lifting Station Type ABS Nirolift. Lifting Station Type ABS Sanisett.
1.3 Legal regulations covering the use of lifting stations for the pumping of faecal-free
efuent.
Automatically operated lifting stations are required if:
- thewaterlevelintheodourlockoftheefuentsourceliesbelowthesewerbackwashlevel.
- rainwater gullies are present where the upper edge of the inlet grid lies below the sewer backwash level.
The sewer backwash level is the maximum possible water level in the public sewer network. Information on this
canbeobtainedfromyourLocalAuthority.IfthebackwashlevelhasnotbeenxedbytheLocalAuthority,then
the surface level of the roadway at the connection point is taken to be the level.
The regulations also require that all wastewater which can cause offensive odours must be collected in closed,
odour-tight, and free-standing collection tanks.
The collection tanks must be vented by vent pipes which are brought above roof level.
ATTENTION! The regulations of DIN 1986/100, EN 12050-2 and EN 12056 should be observed!
2 Safety
Thegeneralandspecichealthandsafetyguidelinesaredescribedindetailinthe“SafetyInstructionsfor
Sulzer Products Type ABS” booklet. If anything is not clear or you have any questions as to safety make certain
to contact the manufacturer Sulzer.
This unit can be used by children aged 8 years and above, and persons with reduced
physical, sensory, or mental capabilities, or lack of experience and knowledge, when they
have been given supervision or instruction concerning the safe use of the device and
understand the hazards involved. Children must not play with the appliance. Cleaning and
user maintenance should not be performed by children without supervision.
3 Transport
m
During transport the unit should not be dropped or thrown.
4 Installation and dimensions (mm)
1 Synthetic tank 10 Shut-off valve (accessory)
2 Wastewater pump Robusta (not supplied with tank,
must be ordered separately)
11 Vent/cable pipe DN 70, lead to above roof level
12 Cable inlet, odour-tight
3 Bend (accessory) 13 Socket
4 Uppertting(adjustable360°) 14 Concrete
5 Coverplatewithoorrun-offandodourlock(only
suitableforfoottrafc).
15 Screed
16 Floor tiles
6 Two inlet ports DN 100 (Nirolift) 100/150 (Sanisett) 17 Motor connection cable
7 Discharge line for connection of P.V.C pipe; 40 mm
(Nirolift), 50 mm (Sanisett)
18 Branch pipe (T-piece)
8 Sealtonishedoor 1) Anti-siphon loop
9 Discharge line. --- Approximate excavation dimensions