User Manual Hob PAG6430
Progress CONTENTS Safety information Safety instructions Product description Daily use Hints and tips 2 3 6 6 8 Care and cleaning Troubleshooting Installation Technical information Energy efficiency 8 9 11 13 14 Subject to change without notice. SAFETY INFORMATION Before the installation and use of the appliance, carefully read the supplied instructions. The manufacturer is not responsible if an incorrect installation and use causes injuries and damages.
Progress 3 • • • • • • • • • Do not operate the appliance by means of an external timer or separate remote-control system. Unattended cooking on a hob with fat or oil can be dangerous and may result in fire. Never try to extinguish a fire with water, but switch off the appliance and then cover flame e.g. with a lid or a fire blanket. Do not store items on the cooking surfaces. Metallic objects such as knives, forks, spoons and lids should not be placed on the hob surface since they can get hot.
Progress and the upper drawer, is sufficient for air circulation. • The bottom of the appliance can get hot. Make sure to install a non-combustile separation panel under the appliance to prevent access to the bottom. Electrical Connection WARNING! Risk of fire and electrical shock. • All electrical connections should be made by a qualified electrician. • The appliance must be earthed. • Before carrying out any operation make sure that the appliance is disconnected from the power supply.
Progress 5 • Set the cooking zone to “off” after each use. • Do not put cutlery or saucepan lids on the cooking zones. They can become hot. • Do not operate the appliance with wet hands or when it has contact with water. • Do not use the appliance as a work surface or as a storage surface. • When you place food into hot oil, it may splash. WARNING! Risk of fire and explosion • Fats and oil when heated can release flammable vapours.
Progress Service • Use original spare parts only. • To repair the appliance contact an Authorised Service Centre. PRODUCT DESCRIPTION Cooking surface layout 1 2 4 Semi-rapid burner Triple Crown burner Auxiliary burner Control knobs 3 Control knob Symbol 1 2 3 4 Symbol Description no gas supply / off position Description ignition position / maximum gas supply minimum gas supply DAILY USE WARNING! Refer to Safety chapters.
Progress 7 Burner overview A B C D WARNING! Be very careful when you use open fire in the kitchen environment. The manufacturer declines any responsibility in case of the flame misuse. 1. Push the control knob down and turn it counterclockwise to the maximum gas ). supply position ( 2. Keep the control knob pushed for equal or less than 10 seconds. This lets the thermocouple warm up. If not, the gas supply is interrupted. 3. Adjust the flame after it is regular.
Progress Turning the burner off To put the flame out, turn the knob to the off position . WARNING! Always turn the flame down or switch it off before you remove the pans from the burner. HINTS AND TIPS WARNING! Refer to Safety chapters. Cookware CAUTION! Do not use cast iron pans, potstones, earthenware, grill or toaster plates. The stainless steel can become tarnished if it is too much heated.
Progress 9 Be very careful when you replace the pan supports to prevent the hob top from damage. 2. The enamel coating occasionally can have rough edges, so be careful when you wash the pan supports by hand and dry them. If necessary, remove stubborn stains with a paste cleaner. 3. After you clean the pan supports, make sure that they are in correct positions. 4. For the burner to operate correctly, make sure that the arms of the pan supports are aligned with the centre of the burner.
Progress Problem Possible cause Remedy Burner cap and crown are placed incorrectly. Place the burner cap and crown correctly. The flame extinguishes immediately after ignition. Thermocouple is not heated up sufficiently. After lightning the flame, keep the knob pushed for equal or less than 10 seconds. The flame ring is uneven. Burner crown is blocked with food residues. Make sure that the injector is not blocked and the burner crown is clean. If you cannot find a solution...
Progress 11 INSTALLATION WARNING! Refer to Safety chapters. Before the installation Before you install the hob, write down the information bellow from the rating plate. The rating plate is on the bottom of the hob. Model ....................................... PNC ......................................... Serial number ...........................
Progress Injectors replacement 1. Remove the pan supports. 2. Remove the caps and crowns of the burner. 3. With a socket spanner 7 remove the injectors and replace them with the ones which are necessary for the type of gas you use (see table in "Technical Information" chapter). 4. Assemble the parts, follow the same procedure backwards. 5. Replace the rating plate (it is near the gas supply pipe) with the one for the new type of gas supply.
Progress 13 Building In A) supplied seal B) supplied brackets CAUTION! Install the appliance only on a worktop with flat surface. min. 650 mm min. 100 mm Possibilities for insertion min. 55 mm The panel installed below the hob must be easy to remove and let an easy access in case a technical assistance intervention is necessary.
Progress Other technical data TOTAL POWER: Gas original: G25 (2L) 25 mbar = 9 kW Gas replacement: G30/G31 (3B/P) 30/30 mbar = 654 g/h Electric supply: 230 V ~ 50 Hz Appliance category: II2L3B/P Gas connection: R 1/2" Appliance class: 3 Bypass diameters BURNER Ø BYPASS 1/100 mm Triple Crown 56 Semi-rapid 32 Auxiliary 28 Gas burners for NATURAL GAS G25 25 mbar BURNER NORMAL POWER kW MINIMUM POWER kW INJECTOR MARK 1/100 mm Triple Crown 4,0 1,4 147 Semi-rapid 2,0 0,45 100 Au
Progress 15 Number of gas burners Energy efficiency per gas burner (EE gas burner) 4 Left rear - Semi-rapid 57.0% Right rear - Rapid 52.0% Left front - Semi-rapid 57.0% Right front - Auxiliary not applicable Energy efficiency for the gas hob (EE gas hob) 55.3% EN 30-2-1: Domestic cooking appliances burning gas - Part 2-1 : Rational use of energy General Energy saving • • • • • • • Before use, make sure that the burners and pan supports are assembled correctly.
www.progress-hausgeraete.
