Manual

TROUBLESHOOTING
BEFORE CALLING FOR SERVICE:
Please check the following problems/solutions before contacting our service center.
PROBLEM
Burner wilt not light
after turning and
pushing the knobs
Burner cannot light
by match
Yellow or orange flame
with gas odor
Low heat with knob
in HI position
Flare=up
Flameout
Flame lifting
Flashback
Grease fire
38
POSSIBLE CAUSE SOLUTION
Propane tank is empty. Refill or replace propane tank.
Igniter deposited with Use clean swab and alcohol to
cooking residues, clean.
Igniter damaged. Replace.
Igniter wires are loose or Reconnect or replace with new
fall off. igniter assembly with wires.
Improper alignment of Use needlenose pliers to adjust the
igniter with side burner, alignment as shown in Step 11.12
in the manual.
Orifice blocked
Wire is shorting.
No gas
Gas flow is not smooth.
Incorrect assembly
between burner and valve
Incomplete combustion
Gas hose bent or kinked.
Burner or orifice blocked.
Low gas pressure
Grill not preheated.
Excessive meat fat
Temperature too high
Grease deposit
High winds
Gas pressure too high
Burner port blocked.
Grease accumulated in
food.
Check the orifice for blockage.
Replace with new igniter
assembly with wires.
Open the LP tank valve or replace
LP tank valve.
Clear burner tubes.
Reassemble.
Call Consumer Affairs at
1=800=851 =8900.
Smooth out the hose.
Clear blockage.
Call the gas dealer.
Preheat the grill for 15 minutes.
Cut off fat before grilling.
Adjust.
Clean.
Find a less windy place.
Call the gas supplier.
Clean burner port.
Turn off knobs and LP tank valve.
Leave lid open and let fire burn out.
Clean the grill after cooling.