Installation Guide

ManualsBrandsProCom ManualsKitchen36.38 in. Vent-Free Dual Fuel Fireplace Insert

This firebox has been tested and approved under ANSI Z21.91 for use with any ANSI

Z21.11.2 approved gas logs.

– Do not store or use gasoline or other flammable vapors and liquids in vicinity of

this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

 Do not try to light any appliance.

 Do not touch any electrical switch; do not use any phone in your building.

 Immediately call your gas supplier from a neighbor’s phone. Follow the gas

supplier’s instructions.

 If you cannot reach your gas supplier, call the fire department.

– Installation and service must be performed by a qualified installer, service agency

or the

as su

lier.

Carefully review the instructions supplied with the decorative type unvented room

heater for the minimum fireplace size requirement.

DO NOT INSTALL AN APPLIANCE IN THIS FIREBOX UNLESS THIS FIREBOX MEETS

THE MINIMUM DIMENSIONS REQUIRED FOR THE INSTALLATION.

WARNING: IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED

EXACTLY, A FIRE MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL

INJURY

OR LOSS OF LIFE.

PC-PC36VFC-701-1101

CAUTION – FOR YOUR SAFETY

FOR USE ONLY WITH A LISTED GAS-FIRED UNVENTED DECORATIVE ROOM

HEATER NOT TO EXCEED 40,000 BTU/HR. DO NOT BUILD A WOOD FIRE.

VENT-FREE GAS FIREBOX

Model # PC32VFC & PC36VFC

Questions about installation, operation, or troubleshooting? Before returning to your retailer, contact our

customer service department at 1-877-886-5989, 8:00 a.m.- 4:30p.m., EST, Monday-Friday or e-mail

customerservice@usaprocom.com.

INSTALLER : Leave this manual with the appliance CONSUMER : Retain this manual

for future reference

Summary of content (13 pages)

PAGE 1
VENT-FREE GAS FIREBOX Model # PC32VFC & PC36VFC CAUTION – FOR YOUR SAFETY WARNING: IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE. – Do not store or use gasoline or other flammable vapors and liquids in vicinity of this or any other appliance. WHAT TO DO IF YOU SMELL GAS  Do not try to light any appliance.  Do not touch any electrical switch; do not use any phone in your building.
PAGE 2
TABLE OF CONTENTS Important Safety Information ......................................................................................................................................... 3 Product Feature ............................................................................................................................................................. 4 Local Codes..........................................................................................................................................
PAGE 3
IMPORTANT SAFETY INFORMATION INSTALLER: DO NOT DISCARD THIS MANUAL – LEAVE FOR HOMEOWNER’S FUTURE REFERENCE. IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate, or service this fireplace. Improper use of this fireplace can cause serious injury or death from burns, fire, explosion, electrical shock, and carbon monoxide poisoning. Only a qualified installer, service agent, or local gas supplier may install and service this product.
PAGE 4
1. Do not place Propane/LP supply tank(s) inside any structure. Propane/LP supply tank(s) must be placed outdoors. 2. Do not use this firebox as a wood-burning fireplace. Use only decorative unvented room heaters (log set). 3. Keep all air openings in front and bottom of fireplace clear and free of debris. This will ensure enough air for proper combustion. 4. Do not run fireplace:  Where flammable liquids or vapors are used or stored.  Under dusty conditions. 5.
PAGE 5
This firebox is designed for vent-free operation. State and local codes in some areas prohibit the use of vent-free fireplace. State of Massachusetts: The installation must be made by a licensed plumber or gas fitter in the Commonwealth of Massachusetts. Sellers of unvented propane or natural gas-fired supplemental room fireplaces shall provide to each purchaser a copy of 527 CMR 30 upon sale of the unit.
PAGE 6
INSTALLATION NOTICE: This fireplace is intended for use as supplemental heat. Use this fireplace along with your primary heating system. Do not install this fireplace as your primary heat source. If you have a central heating system, you may run system’s circulating blower while using fireplace. This will help circulate the heat throughout the house. WARNING: A qualified technician must install fireplace. Follow all local codes.
PAGE 7
NOTE: When firebox is installed directly on carpeting, tile or other combustible material, other than wood flooring, the firebox must be installed on a metal or wood panel extending the full width and depth of the fireplace. BUILT-IN FIREPLACE INSTALLATION Figure 2 – Clearance to Combustibles Built-in installation of this firebox involves installing firebox into a framed-in enclosure. This makes the front of the fireplace flush with wall.
PAGE 8
Figure 5 - Rough Opening for Installing in Corner IMPORTANT: When finishing your firebox, Combustible materials such as plywood and wood framing must have 3/4 -in. clearance to the sides and top of the firebox. Combustible materials should never overlap the firebox front facing. Non-combustible materials such as wall board, gypsum board, sheet rock may be placed at 0 in. clearance to the sides and top of the firebox. WARNING: Do not allow any combustible materials to overlap the firebox front facing.
PAGE 9
INSTALLING GAS LINE NOTI CE: A qualified service person must connect heater to gas supply. Follow all local codes. IMPORTANT: See Connecting to Gas Supply in your log set owner’s manual for details on gas hookup. You may run the gas line from either side of the firebox (see Figure 7). Decide which side you want to run the gas line from. Note: This is one option for installing shutoff valve. Check local codes for equipment shutoff valve location requirements.
PAGE 10
REPLACEMENT PARTS NOTE: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealers of this product. If they can’t supply original replacement parts, call Customer Service toll free at (1-877-886-5989) for referral information.
PAGE 11
PARTS LIST This list contains replaceable parts used in your firebox. When ordering parts, follow the instructions listed under Replacement Parts on 10 of this manual. Part..
PAGE 12
OPTIONAL ACCESSORY QTY Part.. Description Part # 1 Top Trim FB32D104 1 2 Left/Right Trim FB32D121 2 3 Blower Assembly FIB100 1 4 Trim Kit TK32-100B 1 BLOWER (OPTIONAL ACCESSORY) Refer to model FIB100 manual.
PAGE 13
WARRANTY INFORMATION Keep This Warranty IMPORTANT: We urge you to fill your warranty registration card within TEN (10) days of date of installation, complete with the entire serial number which can be found on the rating plate. Retain this portion of the card for your record. Always specify model and serial numbers when communicating with customer service. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.