SDS

PRODUCT DESC.
CONTENT
WEIGHT %
RZ-50 AEROSOL SPRAY LUBRICANT
PRODUCT CLASS
PTFE POLYMER DRY FILM AEROSOL LUBRICANT
SECTION 4: FIRST AID MEASURES
PRODUCT PART NO.
RZ 50
SAFETY DATA SHEET (SDS)
SHEET 2 OF 4
PRODUCT NAME
SECTION 3: COMPOSITION / INFORMATION ON INGREDIENTS
LUBRICANT
0
RZ-50
2/18/2015
C.A.S. NUMBER
INHALATION
IF SWALLOWED, DO NOT INDUCE VOMITING. KEEP AT REST AND SEEK MEDICAL PROMPT ATTENTION
USE PROPER RESPIRATORY PROTECTION AND IN A WELL VENTILATED AREA. REMOVE VICTIM FROM EXPOSURE AND
GENERAL AREA. ADMINISTER ARTIFICIAL RESPIRATION IF BREATHING IS STOPPED. KEEP AT REST AND SEEK PROMPT
MEDICAL ATTENTION.
INGESTION
SDS DATE
SDS NUMBER
EYE CONTACT
FLUSH EYES WITH LARGE AMOUNTS OF WATER UNTIL IRRITATION SUBSIDES. IF IRRITATION PERSISTS, SEEK MEDICAL
ATTENTION.
SKIN CONTACT
SKIN ABSORPTION
FLUSH WITH LARGE AMOUNTS OF WATER, USE SOAP IF NECESSARY. REMOVE GROSSLY CONTAMINATED CLOTHING,
INCLUDING SHOES, AND LAUNDER BEFORE REUSE.
NA
HYDROCARBON PROPELLANT
68476-86-8
40-60
800 PPM
ALIPHATIC HYDROCARBON
142-82-5
40-60
500 PPM
400 PPM
CHEMICAL NAME
CAS#
EXPOSURE LIMITS
ACGIH TLV
OSHA PEL
STOP THE GAS FLOW IMMEDIATELY BEFORE ATTEMPTING TO EXTINGUISH ANY GAS FIRE. ALLOW THE FIRE TO BURN ITSELF OUT. IF
THE GAS SOURCE CANNOT BE SHUT OFF IMMEDIATELY, ALL EQUIPMENT AND SURFACES EXPOSED TO THE FIRE SHOULD BE COOLED
WITH WATER TO PREVENT OVER-HEATING, FLASH-BACKS AND/OR EXPLOSIONS. CONTROL THE FIRE UNTIL THE GAS SUPPLY CAN BE
SHUT OFF. ISOLATE THE "FUEL" SUPPLY FROM FIRE. AVOID SPRAYING WATER DIRECTLY INTO STORAGE CONTAINERS DUE TO
DANGER OF BOILOVER. USE PROPER PROTECTIVE EQUIPMENT AND FRESH AIR RESPIRATORS WHEN EXPOSURE TO HAZARDOUS
CONCENTRATIONS OF TOXIC GASES IS POSSIBLE.
POLY-TFE OMEGA-HYDRO-ALPHA (METHYLCYCLOHEXYL)
65530-85-0
4-8
NOT ESTABLISHED
NOT ESTABLISHED
800 PPM
SECTION 5: FIRE-FIGHTING MEASURES
EXTINGUISHING
MEDIA
UNUSUAL FIRE &
EXPLOSION
HAZARDS
STOP GAS FLOW. RECOMMEND USE OF DRY CHEMICAL, CO
2
OR HALOGENATED EXTINGUISHING AGENT.
PRODUCT RELEASES FLAMMABLE VAPORS AT WELL BELOW AMBIENT TEMPERATURES AND READILY FORMS FLAMMABLE MIXTURES
WITH AIR AND WILL BURN IN THE OPEN AND CAN BE EXPLOSIVE IN CONFINED SPACES. PRODUCT VAPORS ARE INVISIBLE AND HEAVIER
THAN AIR AND MAY TRAVEL LONG DISTANCES TO POINTS OF IGNITION. ALKANE/CHLORINE GAS MIXTURES HAVE PRODUCED
EXPLOSIONS.
-104
0
C, 169 K
AUTOIGNITION TEMP
540
0
C, 813 K
FLASH POINT
FLAMMABLE LIMITS (% BY VOLUME)
LEL
UEL
2.37%
9.50%
IN AIR
SPECIAL FIRE
FIGHTING
PROCEDURES
PRIME LINE PRODUCTS, INC.
26950 SAN BERNARDINO AVE.
REDLANDS, CA 92374
PH: 909-887-8118
FX: 909-880-2906
Email: [e-mail]
EMERGENCY #: 800-255-
3924, 909-887-8118