Assembly Guide CW-119
Important Safety Instructions Obtaining Service When using exercise equipment, basic precautions should always be taken, including the following: For information about product operation or service, refer to the Precor web site at www.precor.com where you can also find customer support numbers or a list of Precor authorized service centers. • • Read all instructions before assembling the CW-119. These instructions are written for your safety and to protect the unit.
CW-119 Assembly Guide Table of Contents Important Safety Instructions .................................................................................. 3 Obtaining Service ..................................................................................................................................... 3 1 Preparations ............................................................................................................... 5 2 Assembly Instructions .............................................
CW-119 Assembly Guide 1 Required Tools Tools that you need to obtain before assembling the unit include: Preparations The CW-119 parts are inspected before shipment. Each unit contains several pieces that require assembly. You must obtain adult assistance during the assembly process. Unpacking the Equipment When you open the box, carefully unpack the pieces and lay them on the floor near the location where you plan to use them.
CW-119 Assembly Guide Hardware Kit Fastener Qty ³⁄₈-inch x ¾-inch buttonhead screw (A) 4 ³⁄₈-inch split washer (B) 4 ⁵⁄₁₆-inch x 1¼-inch buttonhead screw (C) 7 ⁵⁄₁₆-inch split washer (D) 7 ⁵⁄₁₆-inch washer (E) 7 Preparations, continued page 6
CW-119 Assembly Guide 2 Assembly Instructions Assembly of the CW-119 takes about 45 minutes to complete. If this is the first time you have assembled this type of equipment, plan on allowing more time. Be careful to open boxes and assemble components in the sequence presented in this manual. Note: With so many assembled parts, proper alignment and adjustment is critical. While tightening the fasteners, be sure to leave room for adjustments. Do not fully tighten fasteners until instructed to do so.
CW-119 Assembly Guide Assemble the Unit Attach the Main Frame to the Stabilizer using four ³⁄₈-inch X ¾-inch buttonhead screws (A) four ³⁄₈-inch split washers (B) Wrench tighten. Note: Make sure the wheels on the Stabilizer are positioned as shown in the illustration.
CW-119 Assembly Guide Assemble the Pads 1. Attach the Seat Pad to the Seat Adjustment using three 1¼-inch buttonhead screws (C) three ⁵⁄₁₆-inch split washers (D) three ⁵⁄₁₆-inch washers (E) Wrench tighten. 2. Attach the Back Pad to the Back Adjustment using four 1¼-inch buttonhead screws (C) four ⁵⁄₁₆-inch split washers (D) four ⁵⁄₁₆-inch washers (E) Wrench tighten. This completes the assembly of the CW-119.
CW-119 Assembly Guide Clean the Pads and Assembly To clean the pads, moisten a clean, soft cloth in a mild solution of soap and water and wipe all the parts thoroughly. Dry the pad with a clean, dry cloth. Use the same procedure to clean the Main Frame and plastic parts. Frequently vacuum the floor underneath the CW-119 to prevent the accumulation of dust and dirt. If necessary, use the Seat Pad to lift the front end and tip the CW-119 onto its wheels to roll it to a different location.
Limited Warranty Precor, Incorporated (PRECOR) will repair or replace any of the following components which are defective as to materials or workmanship for products manufactured and sold after June 1, 1990: ICARIAN & STRETCH CENTER: Lifetime:Structural Steel Framework Five Years: Rotary Bearings, Weight Stacks, Pulleys, Guide Rods, Structural Moving Parts One Year: Cable, Linear Bearings, Springs Ninety Days: Upholstery, Handgrips, All Other Items Not Listed Not withstanding the above, all warranties prov
CW-119 Assembly Guide Notes: page 12
CW-119 Specifications Length: 48 inches (122 cm) Height: 39 inches (99 cm) Width: 30 inches (76 cm) Shipping weight: 84 lb (38 kg) Precor Incorporated 20031 142nd Avenue NE P.O. Box 7202 Woodinville, WA USA 98072-4002 1-800-347-4404 Precor, Icarian, and Move Beyond are registered trademarks of Precor Incorporated. Copyright 2008 Precor Incorporated. Specifications subject to change without notice. www.precor.
