Owner manual

www.powersolve.co.uk
Powe rsolve Electronics Ltd. 8A, Arnhem Road, Newbury, RG14 5RU. England
Tel:[phone] Fax: [phone] Email: [e-mail]
DC-DC Converters
All Specifications Typical At Nominal Line, Full Load and 25°C Unless Otherwise Noted.
1
BOTTOM
VIEW
2
3
5
24
23
22
16
15
14
13
9
10
11
12
1.25
(31.8)
0.60
(15.2)
0.80
(20.3)
0.10
(2.5)
0.15
(3.8)
0.40
(10.2)
SEE
NOTE
0.08
(2.0)
0.20
(5.1)
NOTE: Pin Size is 0.02 inch (0.5mm) DIA
All Dimensions in Inches (mm)
Tolerance .xx =
+
.02, .xxx=
+
.010
INPUT
Input Voltage Range 24V 9-36V
48V 18-72V
Input Filter Pi Type
OUTPUT
Voltage Accuracy +2.0% max.
Voltage Balance (Dual) +1.0% max.
Temperature Coefficient +0.05%/°C max.
Ripple and Noise, 20MHz BW, Single & +5V 100mV p-p max.
Dual 1% p-p max.
Short Circuit Protection Continuous
Line Regulation
1
, Single/Dual +0.5% max.
Load Regulation, Single
2
+0.5% max.
Dual
3
+1% max.
GENERAL
Efficiency See Table
Isolation Resistance 10
9
ohms min.
Switching Frequency 100kHz, Typ.
Operating Temperature Range -25°C to +71°C
Case Temperature (Plastic Case) 95°C max.
(Copper Case) 100°C max.
Cooling Free-Air Convection
Storage Temperature Range -40°C to +100°C
Dimensions 1.25 x 0.8 x 0.4 inches
(31.8 x 20.3 x 10.2 mm)
ISOLATION VOLTAGE
500 VDC min. Standard Models
3K VDC min
4
Suffix “H” Models
CASE MATERIAL
Standard Models Non-Conductive Black Plastic
Suffix “M” Models
5
Black Coated Copper with Non-Conductive Base
Electrical Specification
NOTE:
1. Measured From High Line to low Line
2. Measured From Full Load to 10% Load
3. Measured From Full Load to 1/4 Load
4. Non-Conductive Black Plastic Only
5. Suffix "HM" 1.5KVDC Instead of 3KVDC Isolation
*NP - NO PIN
*NC - NO CONNECTION WITH PIN
500 VDC 1.5K & 3K VDC
Pin Single Output Dual Output Pin Single Output Dual Output
1 +V Input +V Input 1 NP NP
2 NC -V Output 2 -V Input -V Input
3 NC Common 3 -V Input -V Input
5 NP NP 5 NP NP
9 NP NP 9 NC Common
10 -V Output Common 10 NC NC
11 +V Output +V Output 11 NC -V Output
12 -V Input -V Input 12 NP NP
13 -V Input -V Input 13 NP NP
14 +V Output +V Output 14 +V Output +V Output
15 -V Output Common 15 NC NC
16 NP NP 16 -V Output Common
22 NC Common 22 +V Input +V Input
23 NC -V Output 23 +V Input +V Input
24 +V Input +V Input 24 NP NP
Pin Connection