Use and Care Manual
FIG 1
B
A
8
1
2
3
4
5
9
10
11
6
7
1. UV Light
2. Flood Light
3. Battery Power Indicator
4. Switch Button for Lights
5. Switch Button for Laser
6. Laser Pointer
7. Spot Light
8. Magnetic Pocket Clip
9. Rubber Cover
10. Charging Port
11. Charging Cable
140/450 LUMEN
LED INSPECTION PEN LIGHT
WITH UV AND LASER
PILP450UVL
IMPORTANT SAFETY INSTRUCTIONS
READ AND UNDERSTAND ALL WARNINGS, CAUTIONS
AND OPERATING INSTRUCTIONS BEFORE USING THIS
EQUIPMENT. Failure to follow all instructions listed below
may result in electric shock, fire, and/or serious personal
injury.
WARNING:
CLASS 2 LASER RADIATION. Avoid direct eye exposure.
Do NOT stare into the beam, aperture, or into a reflection
from a mirror-like surface. This is a class 2 laser. Serious
injury to eyes could result.
RADIATION EXPOSURE. Do NOT disassemble or modify
the laser. There are no serviceable components inside.
HAZARDOUS RADIATION. Avoid exposure. Modifying or
using the controls, adjustments, and/or performance of
product as stated in the procedures, other than those
specified herein may result in hazardous radiation
exposure.
• Never point the laser towards aircraft or vehicles. It is
unsafe and illegal.
• Never point the laser towards people or animals.
• Keep the product away from children. Do not use the
product around children. This is not a toy.
• Do not use the product for any function that the
manufacturer does not approve. Serious injury to eyes
could result.
• Make sure all individuals in the area that the product is
being used are aware that a Class 2 Laser product is
being used. Make those individuals aware of all laser
hazards.
WARNING:
Do Not Look directly into LED Light.
Do Not shine the LED light directly into the eyes of others.
Do Not allow children to use LED light unless under the
supervision of an adult.
WARNING: This LED light is powered by a
Lithium-ion battery. Lithium-ion batteries are small,
compact, and ideal for providing long-lasting power to
this product. However, they must be used and charged
properly. Improper use can result in serious injury, fire,
or death.
CAUTION: This product comes with the battery
installed internally. Do not attempt to remove the battery
from the product.
• Do not place this lithium-ion battery powered product in
fire or apply heat to it.
• Do not apply strong impact or shocks to this lithium-ion
battery powered product.
• Do not allow the lithium-ion battery to get wet.
• Do not leave this lithium-ion battery powered product in
the direct sunlight, or use or store it inside cars in hot
weather. Doing so may cause the battery to generate
heat, rupture, or ignite. Using the battery in this
manner may also result in a loss of performance and a
shortened battery life.
• NEVER THROW WATER ON A BURNING LITHIUM-ION
BATTERY! If a lithium-ion battery does catch on fire,
it will burn even more violently when contacted with
water.
• Store the product at temperatures between 41°F and
77°F (5°C and 25°C).
• Properly dispose of all batteries at a recycling center
or per local code. More information regarding battery
disposal in U.S. and Canada is available at; http://www.
rbrc.org/index.html, or by calling 1-800-822-8837
(1-800-8BATTER).
SPECIFICATIONS
•Brightness for Spot Light: 140 Lumens, Dimmable
•Brightness for Flood Light: 450 Lumens, Dimmable
•Beam Distances (max.): 164 Ft. (Spot Light), 65 Ft.
(Flood Light)
•Ultraviolet (UV) Light: 365nm
•Laser: Class 2, 650nm, <1.0mW
•Run Time: 2.5-4 Hours
•Battery: 3.7V, 800 mAh Lithium-Ion, Built-In
•Charging Time: 3 Hours
•Net Weight: 0.2 lb
Includes: Light, Charging Cable and Operator’s Manual
CHARGING THE LIGHT
The light can be recharged by connecting the included
USB charging cable to a USB power output, such as a
cellular phone power adaptor or laptop USB port.
1. Make sure the light is turned off.
2. Lift the rubber cover (9) to expose the charging port
(10).
3. Connect the USB-C (small) end of the charging cable
to the charging port and connect the USB end to a
standard 5V USB power output.
4. The battery power Indicator lights (3) will illuminate
green to show the battery power level. One indicator
light will be flashing if charging is in progress.
5. When charging is complete, all five indicator lights will
be solid green.
OPERATION
SWITCHES
Light Switch (4) Actions
SHORT PRESS to turn the light on. Addtional short presses
cycle through the light modes in the following sequence.
Spot Light - Flood Light - UV Light - Off
To dim any of the lights, select the light mode you want,
hold (
LONG PRESS) the switch button until the desired
brightness level is reached.
NOTE: The light memorizes the brightness setting for each
mode until next setting change.
Laser Switch (5) Actions
SHORT PRESS to turn the laser on/off.
BATTERY POWER INDICTOR
The light has a battery power indicator (3). It consists of
five green lights. To indicate the battery power level, turn
the light on. More illuminated green lights indicate more
battery power remaining.
ULTRAVIOLET (UV) LIGHT
The product features a 365nm Ultraviolet (UV) Light (1) for
automotive leak detection, HVAC leak detection, forgery or
counterfeit detection, crime scene inspection, mineral and
gemstone analysis, and more.
TOLL FREE HELP LINE:
888-552-8665
powersmithproducts.com
Operator’s Manual
LASER POINT
The red laser pointer (6) helps pinpoint objects in out-of-
reach locations.
This product has a Class 2 laser. It complies
with 21 CRF 1040.10 AND 1040.11 except for
deviations pursuant to laser notice 50, June
24th 2007.
MAGNETIC POCKET CLIP
The magnetic pocket clip (8) rotates 120° for more
versatility in your light position. See FIG 1-B.
WARRANTY
This product is warranted free from defects in material
and workmanship for 2 (Two) years after date of purchase.
This limited warranty does not cover normal wear and
tear or damage from neglect or accident. The original pur-
chaser is covered by this warranty and it is not transfer-
able. Prior to returning your product to store location of
purchase, please call the Toll-Free Help Line for possible
solutions.
©Richpower Industries, Inc. All Rights reserved
Richpower Industries, Inc.
736 Hampton Road
Williamston, SC 29697
Printed in China, on recycled paper