This .pdf document is bookmarked Operating Instructions and Parts Manual Air Filtration System Model PM1200 Powermatic 427 New Sanford Road LaVergne, Tennessee 37086 Ph.: 800-274-6848 www.powermatic.com Part No.
Warranty and Service Powermatic® warrants every product it sells against manufacturers’ defects. If one of our tools needs service or repair, please contact Technical Service by calling 1-800-274-6846, 8AM to 5PM CST, Monday through Friday. Warranty Period The general warranty lasts for the time period specified in the literature included with your product or on the official Powermatic branded website. • Powermatic products carry a limited warranty which varies in duration based upon the product.
Table of Contents Warranty and Service .................................................................................................................................... 2 Table of Contents .......................................................................................................................................... 3 Warning ......................................................................................................................................................... 4 Introduction...
Warning 1. Read and understand the entire owner’s manual before attempting assembly or operation. 2. Read and understand the warnings posted on the machine and in this manual. Failure to comply with all of these warnings may cause serious injury. 3. Replace warning labels if they become obscured or removed. 4. Always wear approved safety glasses/face shields while using woodworking equipment. Everyday eyeglasses only have impact resistant lenses; they are not safety glasses. 5.
WARNING: Drilling, sawing, sanding or machining wood products generates wood dust and other substances known to the State of California to cause cancer. Avoid inhaling dust generated from wood products or use a dust mask or other safeguards for personal protection. Wood products emit chemicals known to the State of California to cause birth defects or other reproductive harm. For more information go to http://www.p65warnings.ca.gov/wood.
Grounding Instructions Electrical connections must be made by a qualified electrician in compliance with all relevant codes. This machine must be properly grounded to help prevent electrical shock and possible fatal injury. In the event of a malfunction or breakdown, grounding provides a path of least resistance for electric current to reduce the risk of electric shock. This tool is equipped with an electric cord having an equipment-grounding conductor and a grounding plug.
Installation Unpacking Inspect the Air Filtration Unit and check for shipping damage. Report any damage immediately to your distributor and shipping agent. Do not discard any shipping material until the Air Filtration Unit is installed and running properly. The unit must be anchored to a building structure which will support a minimum of 100 pounds. Never mount to surfaces such as dry wall, false ceiling grids, etc.
Figure 1 Figure 2 Operation Turn off, disconnect (unplug) the Air Filtration Unit from the power source before servicing or changing filters. There are two filters that need to be cleaned and/or replaced periodically, depending upon the amount of use and the environment of your shop. Using clogged filters will diminish the overall efficiency of the unit.
The diffusion filter will not need replacing. It should be inspected occasionally, and if needed, cleaned by light vacuuming or compressed air. (An optional charcoal diffusion filter – stock no. 1791084 – may be purchased, and is used to reduce odors and non-flammable vapors.) Transmitter Replacement The remote transmitter provided with your Air Filtration Unit is pre-programmed and ready to operate once the battery is installed.
Replacement Parts Replacement parts are listed on the following pages. To order parts or reach our service department, call 1-800-274-6848 Monday through Friday, 8:00 a.m. to 5:00 p.m. CST. Having the Model Number and Serial Number of your machine available when you call will allow us to serve you quickly and accurately. Non-proprietary parts, such as fasteners, can be found at local hardware stores, or may be ordered from Powermatic.
Parts Breakdown for PM1200 Air Filtration System 11
Parts List for PM1200 Air Filtration System Index No. Part No. Description Size Qty 1 ............... 1791083 ................... Outer Filter for PM1200 ....................................... 12”x24”x1” ................... 1 2 ............... 1791082 ................... Inner Filter for PM1200 ........................................ 12”x24”x1” ................... 1 3 ............... PM1200-03 .............. Retaining Plate ..................................................... ........................
Replacement Filters: Stock No. Description 1791082 ........................... Inner Filter, PM1200, 12”x24”x1” 1791083 ........................... Disposable Outer Filter, PM1200, 12”x24”x1” 1791084 ........................... Charcoal Diffusion Filter, PM1200 (optional) 1791085 ...........................
427 New Sanford Road LaVergne, Tennessee 37086 Phone: 800-274-6848 www.powermatic.
