PARTS MANUAL MODEL SERIES: P1204 12 kW Stationary Standby Electric Generator Product style and configuration may vary. Thoroughly read the OPERATOR’S MANUAL before operating the generator. Safe operation and top performance can be obtained only when equipment is operated and maintained properly.
TA B L E O F C O N T E N T S BATTERY ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PAGE 3 GENHEAD INLET PANEL ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PAGE 4 CONTROL PANEL ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PAGE 5 MUFFLER BOX ASSEMBLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PA R T S D R AW I N G - B AT T E RY A S S E M B LY PA R T S L I S T - B AT T E RY A S S E M B LY Item No. 1 2 3 Part Number 026-0481 026-0480 N/A Qty 1 1 1 Description CABLE BATTERY, NEGATIVE CABLE BATTERY, POSITIVE BATTERY, BCI GROUP 26 or 26R VENTED *N/A - Must be purchased separately.
PA R T S D R AW I N G - G E N H E A D I N L E T PA N E L A S S E M B LY NOTE: Seal all connections with gas tape. Use 2½ wraps minimum. Check all connections under pressure using a soap and water solution. PA R T S L I S T - G E N H E A D I N L E T PA N E L A S S E M B LY - 2 2 K W Item Part No.
PA R T S D R AW I N G - C O N T R O L PA N E L A S S E M B LY PA R T S L I S T - C O N T R O L PA N E L A S S E M B LY Item No.
PA R T S D R AW I N G - M U F F L E R B O X A S S E M B LY PA R T S L I S T - M U F F L E R B O X A S S E M B LY Item No. 1 2 3 4 5 6 7 Part Number 094-0144 115-0391 094-0146 094-0147 094-0150 115-0392 N/A Qty 2 1 1 1 1 1 12 Description INSULATION, SIDES MUFFLER BOX BASE INSULATION, BOTTOM INSULATION, TOP INSULATION, FRONT SIDE MUFFLER BOX TOP SCREW, #10 TRILOBE 1/2" PANHEAD TORX *N/A - These are standard parts available at your local hardware store.
PA R T S D R AW I N G - E N G I N E G E N H E A D A S S E M B LY PA R T S L I S T - E N G I N E G E N H E A D A S S E M B LY Item Part No.
PA R T S D R AW I N G - E N C L O S U R E PA R T S L I S T - E N C L O S U R E Item No.
PA R T S D R AW I N G - G E N E R AT O R Torque to 15 lbs-ft ITEM 10 PA R T S L I S T - G E N E R AT O R Item No.
NOTES 10 200-2666
NOTES 200-2666 11
CONTACT THE POWERMATE PRODUCT SERVICE DEPARTMENT AT 1-800-445-1805 to obtain warranty service information or to order replacement parts or accessories. HOW TO ORDER REPLACEMENT PARTS Even quality built equipment such as the Powermate standby generator you have purchased, might need occasional replacement parts to maintain it in good condition over the years. To order replacement parts, please give the following information: 1. Model No. and Serial No. and all specifications shown on the Model No./Serial No.
