Operation Manual

Armadillo 9X Sweeper #4100033 Rev. D 07/15

Page 83

TROUBLESHOOTING

This section provides information to assist in identifying maintenance trouble and provides possible causes and

actions to correct the problem. Many of the solution require servicing your machine, they can be found in the

service manual for you unit. Service must be preformed by an approved authorized repair station.

TROUBLESHOOTING CHART

PROBLEM POSSIBLE CAUSE(S) SOLUTION(S)

Engine will not start or runs roughly after start.

Additionally with LP fuel, check the following:

Additionally with Diesel fuel, check the following:

Battery dead. Recharge or replace battery.

Machine out of fuel. Refuel

Fuel lter plugged. Clean or replace lter.

Fuel line broken or obstructed. Blow fuel line out with compressed air.

Dirty air lter. Clean or replace air lter.

Problems with spark plugs, ignition

coil, ignition switch, regulator,

wiring harness.

Review engine manual for

maintenance and troubleshooting

procedures.

Tank valve not fully opened. Open the valve slowly.

Fuel tank type does not match fuel

supply.

Use the correct tank type for the fuel

supply.

Fuel tank and lines are covered

with frost.

Open shut-off valve slowly to ¼ open,

start.

Defective vacuum lock-off. Replace or repair.

Cold weather start with Glow plugs See Starting instructions, page 34.

TROUBLESHOOTING