MSDS

*Estimate
N/A-Not Applicable
N/R-Not Restricted
N/E-Not Established
MATERIAL SAFETY DATA SHEET
NOTE: BLANK SPACES ARE NOT PERMITTED. IF ANY ITEM IS NOT APPLICABLE, THE SPACE MUST BE MARKED TO INDICATE THAT.
IDENTITY
(As shown on Label or package) PLASTI DIP and PLASTI DIP UV (F-698, 819, 820)
PART NO.
IF APPLICABLE
SECTION I
MANUFACTURER'S
NAME Plasti Dip International Inc.
EMERGENCY PHONE No.
USA only: 1-800-424-9300 INT’L: 703-527-3887
ADDRESS (NUMBER, STREET, CITY, STATE AND ZIP CODE)
3920 Pheasant Ridge Drive
REVISION #
Blaine, MN 55449
MANUFACTURER'S PHONE
No. FOR INFORMATION 1-763-785-2156
DATE MSDS
WAS PREPARED October 17, 2008
SECTION II - HAZARDOUS INGREDIENTS INFORMATION. All Health Hazards which comprise 1% or greater of the composition and all
carcinogens if 0.1% of the composition or greater.
HAZARDOUS COMPONENTS CHEMICAL
and IDENTITY AND COMMON NAME (S)
% Wt.
(OPTIONAL)
CAS NO. OSHA
PEL
ACGIH
TLV
OTHER LIMITS
RECOMMEND
VM&P Naphtha 32 – 38 64742-89-8 300 ppm 300 ppm None
Hexane 16-19 110-54-3 500 ppm 50 ppm None
Toluene 13-16 108-88-3 200 ppm 50 ppm None
Methyl Ethyl Ketone 3-7 78-93-3 200 ppm 200 ppm None
Resins 25-27 N/A N/A N/A None
SECTION III - PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING
POINT 149-285°F
SPECIFIC GRAVITY (H
2
0 =1)
0.79 – 0.83
APPROXIMATE WEIGHT PER GALLON (LBS)
6.60 – 6.90
VAPOR PRESSURE
125 mmHg @ 20°C
VAPOR DENSITY
(AIR = 1) Heavier than air
EVAPORATION RATE
(BUTYL ACETATE =1) >1.0
SOLUBILITY IN WATER
Insoluble
% VOLATILE 72 – 75
VOC LBS./GAL 4.8-5.2
OTHER
(IF ANY) None
APPEARANCE
AND ODOR Various colors, Honey Like Substance – Characteristic Odor
SECTION IV-FIRE AND EXPLOSION HAZARD DATA
FLASH POINT -10.0°F
(METHOD USED) TCC
FLAMMABLE LIMITS LEL
0.9
UEL
11.5
EXTINGUISHING
MEDIA Carbon Dioxide, Dry Chemical, or Foam
SPECIAL FIRE
FIGHTING PROCEDURES Self contained breathing apparatus with a full face piece, operated in pressure demand or other positive pressure mode.
UNUSUAL FIRE AND
EXPLOSION HAZARDS This material is flammable and may be ignited by heat, sparks, flame or static electricity.
HAZARDOUS PRODUCTS FORMED BY
FIRE OR THERMAL DECOMPOSITION Carbon Dioxide and/or Carbon Monoxide
EXPLOSIVE LIMITS
(% BY VOLUME IN AIR) 0.9 – 11.5
SECTION V - OPTIONAL HAZARD RATINGS IDENTIFICATION
HAZARD RATING
4-EXTREME
3-HIGH
2-MODERATE
1-SLIGHT
0-INSIGNIFICANT
**SEE SECTION IV
National Fire Protection Association (NFPA)
FIRE 3
REACTIVITY 0 .
HEALTH 2
SPECIAL HAZARDS None .
This is the "front" when printed in duplex. Page 1 of 2 pages if not duplex.