Model #: ___________________________ Serial #: ___________________________ Date Purchased: ____________________ Installation & Operation Manual Tim Horton’s TH-CRTE: Electric Counter Top Rethermalizer L20-417, rev.
TO THE PURCHASER, OWNER AND STORE MANAGER Please review these warnings prior to posting them in a prominent location for reference. WARNING WARNING DO NOT store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. The power supply must be disconnected before servicing, maintaining or cleaning this appliance. WARNING Improper installation, alteration, service or maintenance can cause property damage, injury or death.
TH-CRTE COUNTER TOP RETHERMAILZER 1. TABLE OF CONTENTS INSTALLATION ................................................................................... 1 1.1. CHECKING YOUR NEW APPLIANCE .......................................................................................... 1 1.2. INSTALLATION CLEARANCES ................................................................................................... 2 1.3. INSTALLATION TO COUNTER ...............................................................
INSTALLATION 1. INSTALLATION 1.1. CHECKING YOUR NEW APPLIANCE Your new Pitco appliance has been carefully packed into one crate. Every effort has been made to ensure that it is delivered to you in perfect condition. As you unpack your new appliance, inspect each of the pieces for damage. If something is damaged, DO NOT sign the bill of lading. Contact the shipper immediately; the shipper is only responsible for 15 days after delivery.
INSTALLATION TH-CRTE COUNTER TOP RETHERMAILZER 1.2. INSTALLATION CLEARANCES The clearances shown below are for combustible and non-combustible installations and will allow for safe and proper operation of your appliance. Back Sides Combustible Construction Inches (centimeters) 6.0" (15.24cm) 6.0" (15.24cm) Non Combustible Construction Inches (centimeters) 0.0" (0.0cm) 0.0" (0.0cm) In addition to the above clearances there must also be at least 16 inches (40.64cm) of aisle space in front of the unit.
INSTALLATION 1.5. ELECTRICAL CONNECTIONS It is advised that this power supply be plugged into a wall receptacle that is controlled by the ventilation control. This will prevent the appliance from being operated without the ventilator on. The power requirements for your appliance are listed below. Voltage/Phase KW Amps 200VAC, single phase 5.5 28 208VAC, single phase 6 29 220VAC, single phase 5 23 230VAC, single phase 5.
INSTALLATION TH-CRTE COUNTER TOP RETHERMAILZER Available Power Cords # Description 1 Shrouded Twist Lock 2 Right Angle Straight Blade Standard NEMA L6-30P NEMA 6-30P Hubbell # HBL2621S HBL9331 Mates to HBL2626 HBL9330 Appliance will be shipped with only one power cord from the listing above. L20-417, rev.
INSTALLATION 1.6. VENTILATION AND FIRE SAFETY SYSTEMS Your new appliance must have proper ventilation to function safely and properly. It is very important to install a fire safety system. Your ventilation system should be designed to allow for easy cleaning. Frequent cleaning and proper maintenance of the ventilation system and the appliance will reduce the chances of fire. Ventilation and fire safety systems must comply to local and national codes. Refer to ANSI 83.
TH-CRTE COUNTER TOP RETHERMAILZER INSTALLATION 1.8. INITIAL CLEANING When your appliance is shipped, many of its parts are covered with a thin coat of oil for protection. Before the appliance is ready for cooking it must be cleaned. This will remove the oil coating and any foreign matter that may have accumulated during storage and shipment. Refer to the following procedure to clean the appliance.
OPERATION 2. OPERATION 2.1. FILLING THE APPLIANCE 2.1.1. FILLING THE COOKER TANK It is recommended that the cooker tank is filled with hot water. This will greatly decrease the time it takes for the appliance to reach operating temperature. Refer to the following procedure to fill the cook tank prior to operation. CAUTION This appliance is not designed for cooking with oil. Fill with potable water only. 1. If the drain line hose is connected, ensure that the drain valve is closed. DRAIN VALVE CLOSED 2.
OPERATION TH-CRTE COUNTER TOP RETHERMAILZER 2.3. COOKING It is important to keep the cook tank full of water to minimize the chance of boiling the appliance dry and to keep the water at a level that will provide optimum cooking performance. To ensure the quality of the food you cook in this appliance, follow the preparation instructions from the food manufacturer. 2.3.1. ADDITIONAL CONTROLLER FUNCTIONS Some controllers have additional functions not described in this manual.
PREVENTATIVE MAINTENANCE 3. PREVENTATIVE MAINTENANCE 3.1. DAILY PREVENTATIVE MAINTENANCE Performing the preventative maintenance steps below on a daily basis will keep your equipment safe and at peak performance. WARNING The power supply must be disconnected 3.1.1. APPLIANCE INSPECTION before cleaning and servicing this appliance! Check that the high temperature limit, temperature probe, low water level sensor and the heating element are in the correct position and secured in place.
TH-CRTE COUNTER TOP RETHERMAILZER PREVENTATIVE MAINTENANCE 3.3. ANNUAL/PERIODIC PREVENTATIVE MAINTENANCE AND INSPECTION This section should ONLY be performed by a qualified service technician as part of a regular kitchen maintenance program. This inspection should take place a minimum of once a year by an Authorized Service Technician recommended by Pitco. WARNING The power supply must be disconnected before cleaning and servicing this appliance! 3.3.1.
TROUBLESHOOTING 4. TROUBLESHOOTING 4.1. POWER FAILURE If electric power is removed for any reason, the appliance will shut down. To restart the appliance, follow the appliance start up procedure in section 2.2. CAUTION DO NOT attempt to operate this appliance during a power outage. 4.2. HIGH TEMPERATURE LIMIT This appliance is equipped with a high temperature limit switch. The high temperature limit switch will stop the appliance from functioning if the internal cook tank reaches an unsafe temperature.
TROUBLESHOOTING TH-CRTE COUNTER TOP RETHERMAILZER 4.4.
In the event of problems with or questions about your order, please contact the Pitco Frialator factory at: (603) 225-6684 World Wide Website Address: www.pitco.com In the event of problems with or questions about your equipment, please contact the Pitco Frialator Authorized Service and Parts representative (ASAP) covering your area, or contact Pitco at the numbers listed to the left. MAILING ADDRESS – P.O. BOX 501, CONCORD, NH 03302-0501 SHIPPING ADDRESS – 10 FERRY ST., CONCORD, NH 03301 L20-259, rev.
