Service manual

ManualsBrandsPhilips ManualsTV27PT71B

Summary of content (323 pages)

PAGE 1
PAGE 2
IMPORTANT SAFETY NOTICE Proper service and repair is important to the safe, reliable operation of all Philips Consumer Electronics Company** Equipment. The service procedures recommended by Philips and described in this service manual are effective methods of performing service operations. Some of these service operations require the use of tools specially designed for the purpose. The special tools should be used when and as recommended.
PAGE 3
FIRE AND SHOCK HAZARD 1. Be sure all components are positioned in such a way as to avoid the possibility of adjacent component shorts. This is especially important on those chassis which are transported to and from the service shop. 2. Never release a repaired unit unless all protective devices such as insulators, barriers, covers, strain reliefs, and other hardware have been installed in accordance with the original design. 3.
PAGE 4
LEAKAGE CURRENT COLD CHECK 1. Unplug the ac line cord and connect a jumper between the two prongs of the plug. 2. Turn on the power switch. 3. Measure the resistance value between the jumpered ac plug and all exposed cabinet parts of the receiver, such as screw heads, antennas, and control shafts. When the exposed metallic part has a return path to the chassis, the reading should be between 1 megohm and 5.2 megohms.
PAGE 5
PAGE 6
TV SAFETY NOTES SAFETY CHECKS After the original service problem has been corrected, a complete safety check should be made. Be sure to check over the entire set, not just the areas where you have worked. Some previous servicer may have left an unsafe condition, which could be unknowingly passed on to your customer.
PAGE 7
5. When troubleshooting and making test measurements in a receiver with a problem of excessive high voltage, reduce the line voltage by means of a Variac to bring the HV into acceptable limits while troubleshooting. Do not operate the chassis longer than necessary to locate the cause of the excessive HV. 6. New picture tubes are specifically designed to withstand higher operating voltages without creating undesirable X-radiation.
PAGE 8
PREVENTION OF ELECTROSTATIC DISCHARGE (ESD) Some semiconductor solid state devices can be damaged easily by static electricity. Such components commonly are called Electrostatically Sensitive (ES) Devices, Examples of typical ES devices are integrated circuits and some field-effect transistors and semiconductor "chip" components. The following techniques should be used to help reduce the incidence of component damage caused by electrostatic discharge (ESD). 1.
PAGE 9
PRACTICAL SERVICE PRECAUTIONS IT MAKES SENSE TO AVOID EXPOSURE TO ELECTRICAL SHOCK. While some sources are expected to have a possible dangerous impact, others of quite high potential are of limited current and are sometimes held in less regard. ALWAYS RESPECT VOLTAGES. While some may not be dangerous in themselves, they can cause unexpected reactions – reactions that are best avoided. Before reaching into the powered color TV set, it is best to test the high voltage insulation.
PAGE 10
GENERAL INFORMATION Typical Models Standard Screen - Model: 27PT71 Flat Screen - Model: 27PT91
PAGE 11
Technical Specifications Supply Supply Voltage : Power Consumption Stand By consumption Supply Frequency : Tuning System : Reception : Sound System : Sound Output : : Reception : Aerial input : Remote Control : : 90 – 140Vac : 90 W max. : 7 – 8W 50 - 60 Hz ? 5 % PLL NTSC-M BTSC DBX 2 x 5 W – 27”/32”/36” FSQ 2 x 5 W + 10W – 27” /32” RF Off air - 45.
PAGE 12
Cinch Cinch Cinch Cinch Cinch Cinch Cinch MON: CVBS (out) + L/R (out) CVBS (yellow) (1 V) Audio L (red) (0.2 - 2 V-RMS / 10 k ohm) Audio R (white) (0.2 - 2 V-RMS / 10 k ohm) YUV (in) Y (0.7Vpp/ 75 ohm) U (0.7Vpp/ 75 ohm) V (0.7Vpp / 75 ohm) Cinch Front - audio/video in CVBS (yellow) 1(1 V) Audio L (red) (0.2 - 2 V-RMS / 10 k ohm) Audio R (white) (0.2 - 2 V-RMS / 10 k ohm) Jack Headphone 32 - 2000 ohm (10 mW) 123–Y 4–C SVHS gnd gnd (1 V-PP / 75 ohm) (0.
PAGE 13
CBA Location Guide
PAGE 14
Model to Module Listings MODEL PANEL 27PT31B/121 313917867841 313917883531 313917880521 AVJ400A/001 Large Signal Panel Small Signal Panel M-Link Assembly (W/O M-Link) Side Jack Panel 27PT41B/121 313917867851 313917865621 AVJ400A/001 A10902A/001 A10904A/001 Large Signal Panel Small Signal Panel Side Jack Panel M-Link Assembly PIP Panel 27PT71B/121 EMH802A/001 313917863191 AVJ400A/001 A10902A/001 A10901A/001 310420710191 Large Signal Panel Small Signal Panel Side Jack Panel M-Link Assembly PIP Panel Re
PAGE 15
32PT41B/121 313917868651 313917865621 AVJ400A/001 A10902A/001 A10904A/001 Large Signal Panel Small Signal Panel Side Jack Panel M-Link Assembly PIP Panel 32PT71B/121 313917867861 313917863191 AVJ400A/001 A10902A/001 A10901A/001 310420710191 Large Signal Panel Small Signal Panel Side Jack Panel M-Link Assembly PIP Panel Receiver Assembly IR Board 32PT81S/128 313917888271 313917863191 313917867911 313917860611 313917882271 313917865661 313917859401 310420710191 Large Signal Panel Small Signal Panel Side
PAGE 16
32PT91S/121 313917865591 313917865601 A10901A/001 A10902A/001 A10904A/001 313917865661 313917864271 313917867911 310420710191 312123751431 313917857061 313917863791 Large Signal Panel Small Signal Panel PIP Panel (2 Tuner) M-Link Assembly PIP Panel Front Interface Panel Top Control Assembly Side Jack Panel Receiver Assembly IR Board Double Window PIP Assembly * Double Window PIP Panel * Guide Plus Panel * These panels are subassemblies of the Double Window PIP assembly.
PAGE 17
33LP803/221 313917867861 313917863191 AVJ400A/001 A10902A/001 A10901A/001 310420710191 Large Signal Panel Small Signal Panel Side Jack Panel M-Link Assembly PIP Panel (2 Tuner) Receiver Assembly IR Board Model To Remote Transmitter Listing Model Part Ref. Part No.
PAGE 18
PAGE 19
PAGE 20
PAGE 21
PAGE 22
PAGE 23
PAGE 24
PAGE 25
PAGE 26
Mechanical Disassembly Rear Cover Removal & Replacement Removal of the Rear Cover 1. Remove all screws from the rear cover. 2. Remove the rear cover. Replacement of the Rear Cover Before replacing the Rear Cover, perform the following inspection: • Ensure that AC Cord is placed correctly in the guide brackets. • Ensure that all cables are placed in their original position. Service Positions The following CBA's are present in this chassis (see also 'Chassis overview', CBA Location Diagram): 1.
PAGE 27
1. Remove the LSP-bracket from the bottom tray by sliding the bracket backward and then pull the bracket up and out of the bottom tray. 2. Place the Hooks (A) of the bracket in the first row of fixation holes of the cabinet bottom. In other words reposition the bracket hooks from position (1) to position (2). Service Position 2 for the Large Signal Panel (LSP) Position 2: The following service position will provide the best accessibility to the bottom side (solder side) of the Large Signal Panel: 1. 2. 3.
PAGE 28
Service position for the Small Signal Board (SSB) There is not a predefined service position for the bottom (B-) side of the SSB. All relevant test points can be accessed in both LSB service positions. If IC's must be replaced: take the complete panel out of the SIMM-connector. 1. Put the Large Signal Panel in service position 1 (as described above). 2. Release the 2 metal clamps at both sides of the SIMM-connector and the complete SSB can be taken out. It 'hinges' in the SIMM-connector.
PAGE 29
Access to the Side I/O Panel 1. Remove the two screws. 2. Remove the complete Side I/O-assembly. 3. Release the two clamps then lift the board out of the bracket.
PAGE 30
Access to the Mains Switch/LED Panel 1. Release the two clamps (1) by pulling them upward. 2. While pulling upward on the clamps, slide the complete assembly backward (2). 3. If it is necessary to remove the board, release the two clamps at the sides of the bracket and lift the board out (3). 1. To perform measurements, the panel may be attached to the LSP bracket (4).
PAGE 31
Access to the PIP Panel 1. Release the two clamps (1) and remove the PIP CBA from the bracket. Access to the Guide+ Panel 1. Remove the two screws that secure the Guide+ assembly in place. This will release the complete Guide+ assembly. 2. Pull the two clamps (1) outward and remove the board (2) from the bracket.
PAGE 32
Access to the M-Link 1. Release the two clamps at both sides and remove the board from the bracket. Access to the DC-shift/DAF panel 1. Release the clamps (1) and remove the board (2) from the bracket.
PAGE 33
Troubleshooting Tips Troubleshooting tips for the deflection and power supply circuitry. The Deflection Circuit: • Measure for VBAT (140V) across 2939/2940 (Section - A1 POWER SUPPLY). If the voltage is not present, disconnect jumper 9936 and 9937 (see A1 Power Supply) The complete Line Deflection stage is now disconnected. If the voltage is present then the deflection circuit may be the cause of the problem.
PAGE 34
Solving other problems TV switched off or changes channel without any user action Set switches off after “TV SWITCHING OFF” was displayed Auto standby switched the set off because: • there was no ident signal for more than 15 minutes • there was no remote control signal received or local key pressed for > 2 hours See Service Adjustments for a description of options to enable/disable auto standby. Picture problems Picture too dark or too bright - Press “Smart Picture” button on the remote control.
PAGE 35
PAGE 36
PAGE 37
PAGE 38
PAGE 39
H8 CHASSIS (A10) ADJUSTMENTS Electrical Adjustments Conditions All electrical adjustments should be performed under the following conditions: • Supply voltage: 120V +/- (10%) • Warm-up time: 10 minutes • The voltages and oscilloscope waveforms are measured in relation to the tuner ground. • Test probe: Ri > 10Meg Ohm; Ci < 2.5 pF. VG2 Adjustment Rough alignment Using a pattern generator displaying a circle pattern, adjust the VG2 potentiometer of LOT L5630 to obtain a normal picture. Fine adjustment 1.
PAGE 40
Focus Adjustment Using a pattern generator displaying a crosshatch pattern, adjust the focus potentiometer of LOT L5431 in such a way that the haze on the vertical lines at 2/3 from the left and right edges of the screen (just) disappears. PIP AGC Adjustment The Automatic Gain Correction adjustment prevents overdriving of the PIP-tuner if the input signal is too strong. Overdriving is visible as a loss of color and synchronization in the PIP picture.
PAGE 41
PIP AFC Adjustment • • • Connect a video generator with a color bar and a frequency of 61.25 MHz to the tuner. Connect a multimeter to the AFC output on pin 15 of IC 7914 – TDA9801 Use potentiometer R3944 to adjust the AFC output to 2.6 Volts. Software alignments (Service Alignment Mode) With the software alignments of the Service Alignment Mode, the geometry, white tone and tuner (IF) can be aligned.
PAGE 42
Tuner (Large Signal Panel and Double Window) AGC Adjustment Set pattern generator with gray scale video signal and connect to antenna input with RF signal amplitude - 10mV and set frequency to 63.25 MHz. • Enter SAM (see Software alignments (Service Alignment Mode)). Press Cursor Down button to highlight the TUNER menu item. Press Cursor Right button to enter the TUNER submenu. Press Cursor Down button to highlight the AFC submenu item. Use the Cursor Left/Right buttons to set the value of AFC to 100kHz.
PAGE 43
Geometry Adjustment The geometry alignments menu contains 13 items for correct picture geometry alignment. In widescreen models, the GEOMETRY SW is available for separate alignments of the superwide (panorama) mode. The geometry alignments are: Initial set-up: • • • • • • • • • Press the PICTURE button on the remote control repeatedly to change the Smart Picture setting to "SPORTS." Enter SAM (see Software alignments (Service Alignment Mode)). Press the Menu Down button to select the GEOMETRY menu item.
PAGE 44
Geometry Submenu Item Descriptions SERV-BLK: - To turn on/off the blanking of the lower half of the screen (To be used in combination with the vertical slope alignment) VER-SLOPE - To adjust the picture so the proportions are the same at the top and bottom of the screen.
PAGE 45
Option Codes for Single Tuner PIP, and 2 Tuner PIP
PAGE 46
Option Codes for Models Without PIP
PAGE 47
Option Codes for Double Window
PAGE 48
Option bits/bytes Option bytes for NAFTA models (4:3 Standard Screen) with software named: A10_1US1. OB1 bits 8, 7, ..., 1: SBNP, CVI, C169, E149, SMCK, AV3, CBFL, and IPIX OB2 bits 8, 7, ..., 1: IPMU, VDBY, PLST, SOSD, BLMU, PIPC, PIPT, VSLC OB3 bits 8, 7, ..., 1: MLNK, SURF, CCAP, DNRM, VMUT, TIME, AAVL, FUNN OB4 bits 8, 7, ..., 1: SPKC, VCBK, VBNR, USRC, BNUM, ROTI, SNIC, TMWIN OB5 bits 8, 7, ..., 1: AOUT, INCF, APC, NVM, (res), (res), (res), (res) OB6 bits 8, 7, ..., 1: (RESERVED) OB7 bits 8, 7, ...
PAGE 49
Service Modes & Error Messages The following topics are covered: • • • • • • Test points Service Modes and Dealer Service Tool (DST) Error code buffer and error codes The “blinking LED” procedure Trouble shooting tips Customer Service Mode Test points The H8 chassis is equipped with test points shown on the CBA and the schematic diagrams.
PAGE 50
Small Signal Panel PCB Test Point Guide
PAGE 51
CRT Panel PCB Test Point Guide Each test point has a reference number indicating the functional block in which it is located. • A1-A2-A3, etc.: Test points for the audio processing circuitry [A6, C6] • C1-C2-C3, etc.: Test points for the control circuitry [C8] • F1-F2-F3, etc.: Test points for the frame drive and frame output circuitry [A3] • I1-I2-I3, etc.: Test points for the Intermediate Frequency Circuitry [A4, C1] • K1-K2-K3, etc: Test points for the Guide+ panel • L1-L2-L3, etc.
PAGE 52
Service Default Mode (SDM) Introduction The Service Default Mode (SDM) is a technical aid for the service technician. The Service Default Mode (SDM) establishes fixed, repeatable settings of customer controls, which allow consistent measurements to be made. The SDM also initiates the blinking LED procedure and, if necessary, overrides the 5V protection. The SDM places the set in the following pre-defined conditions: • Tuning frequency set to 61.25 MHz (channel 3).
PAGE 53
Service Default Mode (SDM) Screen Special SDM functions Access to normal user menu Pressing the “MENU” button on the remote control switches between the SDM and the normal user menus (with the SDM mode still active in the background) Auto Program Press the Cursor Down button and highlight the "Install" menu item. Press the Cursor Right button to highlight the "Language " menu item. Press the Cursor Down button until the "Auto Program" menu item is highlighted.
PAGE 54
Service Alignment Mode (SAM) Introduction The Service Alignment Mode (SAM) is used to align the set and/or adjust the option settings and to display/clear the error code buffer values.
PAGE 55
SAM Screen and Menu Structure
PAGE 56
Explanation notes/references: 1 Operation Hours (Run Timer): This display indicates the accumulated total of operational hours. (Shown in hexadecimal format) 2 Software identification of the main micro controller (A10US1-2.7) A10 is the engineering chassis name for the H8 chassis • US1 is 2 letter and 1 digit combination to indicate the software type and the supported languages: • US = USA • 1 = Main Software language version number • 2.
PAGE 57
• upon automatic reset when content has not changed for 50 consecutive hours By leaving SDM or SAM via the power switch, the error buffer will not be reset.
PAGE 58
Error 4 = +5V protection 5V protection active; set is switched to protection; error code 4 is placed in the error buffer; the LED will blink 4 times (repeatedly). A 5V failure can cause a drop in the 5V-supply output, resulting in an undefined behavior of the set. Therefore, all I2C devices connected to the 5V supply are constantly monitored. When none of these devices responds to the micro controller for a prolonged time, the micro controller assumes that there is a failure in the 5V supply.
PAGE 59
Error 16 = PIP/DW Tuner I2C error. The Tuner (TEDE9 – item 1900) on the PIP-panel does not respond to the micro controller. Error 17 = PIP IC – M65669SP I2C failure (item 7803) or Double Window IC SAB9081 I2C failure. Error18 = I/O expander IC – 62320P I2C failure (item 7910 on PIP panel). Error 19 = Guide+ I2C failure (LC27016B – item 7005). Error 20 = V-chip for PIP, IC ZILOG 86130 I2C failure. Error 21 = NV clock IC MK41T56 I2C failure at mono board – Item 7011 at A7. (Latam only) Error 22 = Reserved.
PAGE 60
The Blinking LED Procedure The contents of the error buffer can also be made visible through the “blinking LED” procedure. This is especially useful when there is no picture. • When the SDM is entered, the LED will blink the number of times, equal to the value of the error code. Upon entry into the SDM, the LED will blink the contents of the error-buffer.
PAGE 61
The Customer Service Mode information screen Upon entry into the Customer Service Mode the following screen will appear. CSM Menu Screen The Customer Service Menu shows the following information: - Line 1 : “HRS : nnnnn” and SWID : “A10BBC-X.Y” HRS: Indicates the accumulated total of operational hours. (Shown in hexadecimal format.) (Standby hours are not counted as operating hours). SWID: Software identification of the main micro controller (example: A10US1-2.
PAGE 62
- Line 6 : “TIMER ON ” Indicates that the on/off timer is running. The following Complaints may be caused by the activation of the sleep timer: The set may turn on from standby or may switch to a different channel without using either the remote control or the local keyboard. To switch off the activation timer: Select “TIMER” in the “FEATURE” menu. Select “ACTIVATE’ in the “TIMER” menu. Set to “OFF” with the left/right cursor keys.
PAGE 63
H8 Technical Training INTRODUCTION The H8 TV Chassis is designed for the 2000-2001 model years. It comes in three screen sizes, which are 27, 32, and 36 inch. All Chassis versions have a Side Jack Panel, a Component Input, and Surround Speaker Jacks. The Rear Jack and Side Jack Panels are equipped with Composite, Component, and SVHS inputs. The sets are equipped with either a Standard Dark Glass picture tube or a Very Flat Square Invar picture tube.
PAGE 64
The Power Supply is a Switching type supply. The Power Supply begins operating as soon as AC power is applied to the set. AC power is applied to the Large Signal Board through Fuse 1900 and applied to the Bridge Rectifier 6915. The rectified B+ voltage is applied to the regulator switching IC, 7921, through Pins 6 and 3 of transformer 5912. Startup voltage for the supply is applied to Pin 4 through resistors 3914 and 3913.
PAGE 65
The voltage from jumper 9964 (approximately 8 volts) is used to produce the 3.3 volt standby, 5 volt standby, 5 volt remote control, and switched 8 volt supplies. The voltage is applied to transistor 7965 to produce the 3.3volt Standby supply. When the set is in the Standby mode, transistor 7944 is turned On, turning 7922 On, providing a extra current drive for the 3.3 volt regulator. The 8 volt unregulated supply is applied to 7942, which is a switched 8-volt regulator.
PAGE 66
Power Down and Front Detect Figure 4 The Power-Down and Front Detect circuits signal the Microprocessor in case power is removed from the set. The Microprocessor will store the customer settings before shutting the set down. Diode 6942 produces a negative voltage to turn transistor 7987 On, keeping the Power-Down line High. This keeps transistor 7277 turned Off. If power is removed from the set, the negative voltage will discharge before the operating voltage for the set falls.
PAGE 67
SWEEP AND SHUTDOWN CIRCUITS Horizontal and Vertical Drive Figure 5 The 3.3 volts Standby supply provides power to 7301 on Pin 14 for a Horizontal Soft Start. The Standby line from the Microprocessor turns the +8 volt supply On to provide power for the Sync circuits when the set is turned On. The Horizontal Output on Pin 56 is switched On by the Microprocessor via the I2C buss, after the Soft Start is complete. Vertical Drive, labeled Frame-Drive, is output on Pins 63 and 64.
PAGE 68
Horizontal Output and Shutdown Figure 6 Horizontal Drive (LINEDRIVE1) is fed to transistor 7481 and coupled through transformer 5406 to the Horizontal Output transistor 7410. In sets with the Very Flat CRT and larger screen sizes, an East West Drive circuit is present. The East West Drive circuit also has a protection circuit to detect the loss of Horizontal drive. In normal operation, 7470 is switched by the EW-Drive. The pulse width is too narrow to develop the necessary voltage to turn 7478 On.
PAGE 69
Vertical Output Figure 7 Positive and Negative Vertical drive from the Small Signal Board is fed to the Vertical Output IC7501 which drives the Vertical Yoke. The Vertical Pulse on Pin3 drives 7513 to produce the VFB (Vertical Feedback signal) for the Small Signal Board. A failure in the Vertical Output circuit will be detected by the Signal Processor on the SSB by sensing the Frame Drive line and by the Microprocessor sensing the loss of the VFB pulse.
PAGE 70
NON PIP Video Signal Flow Figure 8 The first version to be discussed is the Non PIP chassis video path. The Main Tuner, AV1, AV2, and Component Inputs are located on the Large Signal panel. The AV3 input is located on the Side Jack Panel. All of these inputs are fed to the Small Signal Board, SSB, which plugs into the Large Signal panel. The Tuner IF is fed to the SAW filter, 1451, and then to the Signal Processor, 7301, on Pins 1 and 2.Composite Video is output on Pin 16 and is buffered by 7305 and 7331.
PAGE 71
Standard CRT Drive Figure 9 The CRT drive signal is fed to 7830, which drives the CRT. As mentioned previously, a Test Signal is sent to 7830 and to the CRT. The Waveform on the left shows this Test Signal. When 7830 senses the correct current flow in the CRT, the Test Signal is sent to the SSB via the CUTOFF line. The Picture RGB signals are then fed to the CRT Board. This waveform is shown on the right. If the CRT is defective or unplugged, no pulse will be output on Pin 4.
PAGE 72
PIP (Picture in Picture) Video Flow Figure 10 There are two PIP chassis versions which are the Single Tuner and Two Tuner sets. Video Signal flow for the Single Tuner PIP version is the same as the Two Tuner version, except the Composite Video from Pin 16 of 7301 is routed through the Large Signal Board (LSB) to the PIP module and back to the 1333 Sound Trap in the Two Tuner version. In the Single Tuner version, Video from Pin 16 is routed through jumper 4308. The second Tuner is located on the PIP panel.
PAGE 73
PIP Circuit Figure 11 The PIP comes in two versions, Single Tuner with no tuner on the PIP panel and two tuner versions with the second tuner located on the PIP module. Output of the second tuner is fed to the SAW FILTER 1901, and to the Signal Processor 7914. Composite Video is fed to the Switch 7916, which selects between the PIP tuner or selected Composite Video from the SSB.
PAGE 74
PIP Switching Figure 12 Control for the PIP panel is performed by 7910 via the I2C buss. SEL_TUNER1 and SEL_TUNER2 control the composite switching to the SSB panel. S1, S2, and S3 control the tuner aux switching IC 7801.
PAGE 75
Power Supply Figure 13 The PIP panel is powered by +5 volt, +8 volt, and +33 volt supplies from the Large Signal Board (LSB). A 3.3 volt regulator supplies power to the PIP processor, 7803.
PAGE 76
Video Signal Flow with Double Window Figure 14 The XXPT91 versions of the H8 chassis have the DOUBLE WINDOW panels. This allows for both a single PIP window and a split screen. Each Time the PIP On/Off button on the remote is selected, the PIP window goes from a small window to a large window and then to a split screen. Composite Video and YUV switching between the PIP panel and the SSB is the same as the standard PIP. Two other differences are the Histogram IC 7403 and the Gemstar module.
PAGE 77
Double Window Tuner and Video Switching Figure 15 The PIP/Double Window panel allows for both a standard PIP window and a split screen. The PIP/Double Window module has a separate Tuner, SAW filter, and Signal Processor. The output of the Signal Processor, 7301, on Pin 16 is fed to switching IC 7402 which selects between the PIP Tuner and Composite Video from the SSB for feedback to the SSB on Pin 15 or Video for the PIP window on Pin 14.
PAGE 78
Double Window Output Figure 16 The PIP or Double Window YUV signal is fed to the PIP/DW processor, 7801. The I2C buss controls the IC from the Microprocessor on the SSB. The PIP/DW processor outputs YUV for the PIP window or Split Screen to the YUV switch 7803 where it is mixed with the YUV signal from the SSB for the main picture. The Fast Blanking line from 7801 on Pin 68 controls the switch point in which the PIP window or Split Screen is inserted. The SDA and SCL lines are switched by the +3VD line.
PAGE 79
Double Window Control and Power Supply Figure 17 The PIP/Double Window module is controlled by the I2C buss through 7403 on the PIP module. Pins 4, 5, 6, and 7 perform Video selection functions. Pin 10 produces a reset signal for the Guide Plus module. Pin 12 controls the +5VS and +8VS supplies.
PAGE 80
Flat CRT Drive Circuit Figure 18 The CRT panel for the Very Flat CRT's has an SVM circuit to sharpen the transitions from dark to light and light to dark. The RGB signals are combined and fed to 7860 which performs impedance matching. The signal is then buffered by 7861. Capacitors 2867, 2870, and 2874 along with diodes 6867 and 6868 act as a differentiator to separate the pulses for the contrast difference. Transistors 7862 and 7863 drive the SVM yoke.
PAGE 81
AUDIO SIGNAL PATH Audio Signal Processing Figure 19 All Audio Processing is performed by 7651, which is located on the SSB. The Sound IF is fed to Pin 50 and to the Sound Demodulator for decoding. The internal Switch selects between AV1, AV2, and AV3. The Audio is digitally processed inside the IC to separate the Second Audio Program and process volume levels to maintain a constant audio level if the user selects the AVL feature.
PAGE 82
Audio Amplifier Figure 20 Audio from the SSB is fed to the Audio Amplifier on the LSB. Left Channel Audio is fed to Pin 2 of 7702 while Right Channel Audio is fed to Pin 5. Audio is output to the speakers on Pins 12 and 7. Left and Right outputs are also fed to the Surround Sound Speaker Jack. The output of the Surround Jacks is the difference between the Left and Right Channels. The Amplifier is powered by a 27-volt supply, which is present, as soon as power is applied to the set.
PAGE 83
Headphone Amplifier Figure 21 Headphone audio from the SSB is fed to the Headphone Amplifier, 7703-A, located on the LSB. The Audio is then output to the Side Jack panel. This circuit is powered by the +5 volt supply.
PAGE 84
Side Jack Panel Figure 22 The Side Jack panel is the AV3 input in the Customer Menu. It has a Composite Video Input, SVHS Input, and a Stereo Audio input. It also has a headphone output. If an SVHS connector is plugged into the Side Jack panel, the Composite Video input is muted. The Audio inputs are designed so that if audio is plugged into only one input, the signal will be fed to both the Left and Right Channel lines.
PAGE 85
Microprocessor Figure 23 The Microprocessor, 7064, is located on the SSB. User control of the Microprocessor is accomplished via the Keyboard or Remote. In case of Overcurrent or a failure in the Horizontal sweep circuit, The PROT-UP line will go High turning transistor 7276 On, placing a Low on Pin 5 of the Keyboard line. The Microprocessor will then shut the set Off. Composite Video for Data capture, for Closed Caption or Text, is fed to the IC on Pins 32 and 31.
PAGE 86
Customer Control Interface Figure 24 The Keyboard line is a voltage level controlled input. With no buttons pressed, this line should read approximately 3.38 volts when the set is On. It will be approximately 0.2 volts higher when the set is in Standby. In the XXPT31 versions, the Keyboard Switches are located on the LSB. In the XXPT41 and above models, the Keyboard Switches are located on the Top Control panel for Volume Down, Volume Up, Channel Up, and Channel Down.
PAGE 87
SERVICE MODES All of the adjustments in the set are performed via the On-Screen Service mode. There are three different Service Modes. The SDM (Service Default Mode) allows Error Codes to be read through an On-Screen menu or from a blinking Power light. It also pre-sets certain conditions and disables certain functions. The next Service mode is the SAM (Service Adjustment Mode). This mode is used to align the set, adjust option settings, and read and clear the error buffer.
PAGE 88
Service Alignment Mode (SAM) Figure 25 The Service Alignment Mode is used to read Error Codes, Reset Error Codes, Set Option Codes, and perform Service Alignments. Pressing 0-6-2-5-9-6-Status on the remote control transmitter enters the SAM. To save the Error Codes, remove AC power to the set without turning it Off. When power is reapplied and the set is turned On, the SAM will still be active. Use the Cursor Up-Down keys to select a function in the menu.
PAGE 89
Customer Service Mode (CSM) The Customer Service Mode allows the Customer to read the Error codes upon instruction form the Technician. Pressing the Mute button on the Remote Control and any key on the set Keyboard at the same time can enter the Customer Service Mode. M-link Figure 26 The M-Link feature is on all sets above models XXPT41 and above. This feature allows external devices such as DVD players and VCRs to be controlled by the TV set.
PAGE 90
Wiring Diagrams
PAGE 91
PAGE 92
Block Diagrams
PAGE 93
PAGE 94
PAGE 95
PAGE 96
27H8(7592)
PAGE 97
27H8(7592)
PAGE 98
27H8(7592)
PAGE 99
27H8(7592)
PAGE 100
27H8(7592)
PAGE 101
27H8(7592)
PAGE 102
All Models (7592) - H8 Chassis - Circuit Board Location Guide
PAGE 103
All Models (7592) - LSP Panel: Power Supply - A1
PAGE 104
All Models (7592) - LSP Panel: Line Deflection - A2
PAGE 105
All Models (7592) - LSP Panel: Frame Deflection - A3
PAGE 106
All Models (7592) - LSP Panel: Tuner - A4
PAGE 107
All Models (7592) - LSP Panel: Cinch - A5
PAGE 108
All Models (7592) - LSP Panel: Audio - A6
PAGE 109
All Models (7592) - LSP Panel: Front Control / Rotation / Headphone - A7
PAGE 110
All Models (7592) - CRT Panel - B
PAGE 111
All Models (7592) - SSB Panel: IF, Video, Sync & Chroma - C1
PAGE 112
All Models (7592) - SSB Panel: Video Features - C2
PAGE 113
All Models (7592) - SSB Panel: Microcontroller - C3
PAGE 114
All Models (7592) - SSB Panel: Memory - C4
PAGE 115
All Models (7592) - SSB Panel: Audio Processing - C5
PAGE 116
All Models (7592) - SSB Panel: Audio Processing - C6
PAGE 117
All Models (7592) - SSB Panel: SSB Conector - C7
PAGE 118
All Models (7592) - Side Jack Panel - D, Top Control Panel - E
PAGE 119
All Models (7592) - Double Window Panel: Control - F1, Tuner Panel - F2
PAGE 120
All Models (7592) - Double Window Panel: I/O Processing - F3
PAGE 121
All Models (7592) - Double Window Panel: IF-Video-Sync - F4
PAGE 122
All Models (7592) - Double Window Panel: V Chip Processor - F5, NV ROM - F6
PAGE 123
All Models (7592) - DC Shift & DAF Panel - G
PAGE 124
All Models (7592) - M-Link Interface / Matrix Surround - I
PAGE 125
All Models (7592) - Front Interface Panel - J
PAGE 126
All Models (7592) - Guide Plus+ Panel - K1
PAGE 127
All Models (7592) - Guide Plus+ Panel - K2
PAGE 128
All Models (7592) - 2nd Front End PIP Panel - L1
PAGE 129
All Models (7592) - PIP Color - L2
PAGE 130
All Models (7592) - Front Interface & Headphone Panel - Q
PAGE 131
All Models (7592) - DAF Panel & Inner Pin Cushion Correction Panel - W
PAGE 132
All Models (7592) - [A] Large Signal Panel PCB (Top View)
PAGE 133
All Models (7592) - [A] Large Signal Panel PCB (Bottom View)
PAGE 134
All Models (7592) - [B] CRT Panel PCB (Top View)
PAGE 135
All Models (7592) - [B] CRT Panel PCB (Bottom View)
PAGE 136
All Models (7592) - [C] Small Signal Panel PCB (Top View)
PAGE 137
All Models (7592) - [C] Small Signal Panel PCB (Bottom View)
PAGE 138
All Models (7592) - [D] Side Jack Panel, [E] Top Control Panel (Top View)
PAGE 139
All Models (7592) - [D] Side Jack Panel, [E] Top Control Panel (Bottom View)
PAGE 140
All Models (7592) - [F] Double Window PIP Panel PCB (Top View)
PAGE 141
All Models (7592) - [F] Double Window PIP Panel PCB (Bottom View)
PAGE 142
All Models (7592) - [G] DC Shift & DAF Panel (Top View only)
PAGE 143
All Models (7592) - [I] M-Link Interface / Matrix Surround (Top View)
PAGE 144
All Models (7592) - [I] M-Link Interface / Matrix Surround (Bottom View)
PAGE 145
All Models (7592) - [J] Front Interface Panel PCB (Top View only)
PAGE 146
All Models (7592) - [K] Guide Plus+ Panel PCB (Top View only)
PAGE 147
All Models (7592) - [L] 2nd Front End PIP Panel PCB (Top View)
PAGE 148
All Models (7592) - [L] 2nd Front End PIP Panel PCB (Bottom View)
PAGE 149
All Models (7592) - [Q] Front Interface & Headphone PCB (Top View)
PAGE 150
All Models (7592) - [Q] Front Interface & Headphone PCB (Bottom View)
PAGE 151
All Models (7592) - [W] DAF Panel & Inner Pin Cushion Correction Panel PCB
PAGE 152
MAIN CABINET EXPLODED VIEW
PAGE 153
27PT31B121 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 154
27PT31B121 (continued) 2967 2968 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3410 3411 3412 3414 3417 3421 3423 3430 3434 3435 3436 3437 3438 3439 3440 3441 3442 3445 3446 3447 3448 3449 3450 3452 Cap, Cap, Cap, Cap, Cap, Res
PAGE 155
27PT31B121 (continued) 3966 3967 3968 3969 3970 3971 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 4272 4273 4274 4279 4281 4282 4284 4285 4286 4287 4288 4291 4292 4293 4294 4295 4296 4400 4402 Res, Res, Res, Res, Res, Res
PAGE 156
27PT31B121 (continued) 6461 6463 6464 6474 6474 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 7944 7950 7965 7967 7971 7987 7990 7991 7992 8111 8222 8450 9012 9015 9016 9017 9019 9020 9021 9023 9025 9026 9027 9028 9029 9032 9035 9036 9037 9038 9200 9201 9202 9203 Diode, Rect, BYD33D . . . .
PAGE 157
27PT31B121 (continued) 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9446 9464 9465 9466 9467 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9985 9986 9987 9990 9992 9994 9996 9998 CBA Jumper . . . Jumper . . . Jumper . . . Jumper . .
PAGE 158
27PT31B121 (continued) 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3054 3055 3056 3057 3058 3059 3061 3062 3064 3065 3066 3081 3082 3083 3084 3085 3086 3088 3092 3301 3302 3305 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 159
27PT31B121 (continued) 3606 3619 3621 3665 4008 4304 4308 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4431 4432 4433 4434 4435 4436 4451 4455 4465 4684 5040 5041 5042 5309 5332 5333 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7305 7307 7331 7368 7401 7405 7407 7412 7415 7421 7425 7442 7446 7630 7651 CBA Res, 27K, 5%, 1/16W, Metalized Glass .
PAGE 160
27PT41B121 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 161
27PT41B121 (continued) 2961 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3421 3423 3430 3434 3435 3436 3437 3438 3439 3440 3441 3442 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 162
27PT41B121 (continued) 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3971 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 4272 4273 4274 4279 4281 4282 4284 4285 4286 4287 4288 4291 Res, Res, Res, Res, Res, Res
PAGE 163
27PT41B121 (continued) 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6474 6474 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6920 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 7992 8111 8222 8450 9012 9015 9016 9017 9019 9020 9021 9023 9024 9026 9027 9028 9029 Diode, Signal. . . . . . . .
PAGE 164
27PT41B121 (continued) 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9446 9464 9465 9466 9467 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9984 9985 Jumper Jumper Jumper Jumper
PAGE 165
27PT41B121 (continued) 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3054 3055 3056 3057 3058 3059 3061 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 166
27PT41B121 (continued) 3472 3473 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4304 4308 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 4684 5040 5041 5042 5309 5332 5333 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7305 7307 7331 7368 7401 7405 7407 7412 7415 7421 7425 7442 7446 7630 7651 CBA Res, Zero ohm, "Chip" Jumper . . . . . Res, Zero ohm, "Chip" Jumper .
PAGE 167
27PT41B121 (continued) 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3956 3958 3960 3961 3962 3968 3969 3970 4803 4804 4805 4806 4807 4808 4809 4810 4812 4813 4814 4815 4817 4818 4819 4821 4901 5890 5891 5892 5902 6801 6890 7801 7803 7804 7805 7806 7807 7810 7813 7816 7817 7891 7910 7919 7920 9800 9801 9802 Res, 150 ohm, 5%, 1/10W, Met
PAGE 168
27PT41B121 (continued) 3288 3289 3291 3292 3293 3294 3295 3296 3297 4241 4243 4244 4245 4246 6291 6292 6293 6294 9237 9238 9239 CBA Res, 10 ohm, 5%, 1/6W, Carbon Film . Res, 1K8, 5%, 1/6W, Carbon Film. . . Res, 1K, 5%, 1/6W, Carbon Film . . . Res, 47K, 5%, 1/10W, Metalized Glass Res, 1K, 5%, 1/6W, Carbon Film . . . Res, 47K, 5%, 1/10W, Metalized Glass Res, 3K9, 5%, 1/6W, Carbon Film. . . Res, 10K, 5%, 1/10W, Metalized Glass Res, 10K, 5%, 1/10W, Metalized Glass Res, Zero ohm, "Chip" Jumper . . . .
PAGE 169
27PT71B121 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 170
27PT71B121 (continued) 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3421 3423 3430 3434 3435 3436 3437 3438 3439 3440 3441 3442 3445 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 171
27PT71B121 (continued) 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3971 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 4272 4273 4274 4279 4281 4282 4284 4285 4286 4287 4288 4291 4292 Res, Res, Res, Res, Res, Res
PAGE 172
27PT71B121 (continued) 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6474 6474 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 7992 8111 8222 8450 8460 9012 9015 9016 9017 9019 9020 9021 9023 9024 9026 9027 9028 9029 Diode, Signal. . . . . . . .
PAGE 173
27PT71B121 (continued) 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9446 9464 9465 9466 9467 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9984 9985 Jumper Jumper Jumper Jumper
PAGE 174
27PT71B121 (continued) 2424 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3054 3055 3056 3057 3058 3059 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 175
27PT71B121 (continued) 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 5040 5041 5042 5309 5332 5333 5334 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 7421 7425 7442 7446 7630 7651 CBA Res, Zero ohm, "Chip" Jumper . . . . . Res, 4K7, 5%, 1/16W, Metalized Glass .
PAGE 176
27PT71B121 (continued) 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3933 3934 3936 3937 3938 3939 3942 3943 3944 3945 3946 3947 3948 3949 3950 3951 3952 3953 3955 3956 3957 3958 3960 3961 3962 3964 3965 3968 3969 3970 3971 3972 4803 4804 4805 4807 4808 4809 Res, 15K, 5%, 1/10W, Metalized Glass .
PAGE 177
27PT71B121 (continued) 4701 4702 6751 6752 6753 6754 7751 7752 7753 7754 CBA Res, Zero ohm, "Chip" Jumper . Res, Zero ohm, "Chip" Jumper . Diode, Signal. . . . . . . . . Diode, Signal. . . . . . . . . Diode, Signal. . . . . . . . . Diode, Signal. . . . . . . . . Transistor, PNP, BC857B(COL) . Transistor, NPN, BC847B(COL) . Transistor, PNP, BC857B(COL) . Transistor, NPN, BC847B(COL) . M-Link Assembly (With Matrix). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 178
27PT81S125 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . . 0136 Spring . . . . . . . . . . . . . . . .
PAGE 179
27PT81S125 (continued) 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3272 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3421 3423 3430 3434 3435 3436 3437 3438 3439 3440 3441 3442 3445 3446 3447 3448 3449 3450 3452 3470 3471 3472 3473 3476 3477 3478 3479 3480 3481 3482 3483 3484 3485 Res, Res, Res, Res, Res, Res
PAGE 180
27PT81S125 (continued) 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 4272 4273 4274 4276 4279 4281 4282 4284 4285 4286 4287 4288 4291 4292 4293 4294 4295 4296 4400 4402 4403 4404 4405 4406 4407 4408 4410 4412 4502 4503 4702 4704 4706 4707 4708 4709 4710 Res, Res, Res, Res, Res, Res
PAGE 181
27PT81S125 (continued) 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 7992 8450 9012 9015 9016 9017 9019 9020 9021 9023 9024 9026 9027 9028 9029 9032 9035 9036 9037 9200 9201 9202 9203 9207 9208 9209 9210 9211 9212 9214 9215 9216 9217 9218 9219 9220 9221 9222 9226 9227 9228 9229 9231 Diode, Rect, BYD33D . . . .
PAGE 182
27PT81S125 (continued) 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9984 9985 9986 9987 9988 9990 9992 9993 9994 9996 9998 CBA Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper .
PAGE 183
27PT81S125 (continued) 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3054 3055 3056 3057 3058 3059 3061 3062 3064 3065 3066 3081 3082 3083 3084 3085 3086 3088 3092 3301 3302 3305 3307 3311 3312 3315 3316 3324 3329 3330 3331 3332 3333 3334 3335 3339 3340 3341 3342 3344 3345 3348 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 184
27PT81S125 (continued) 4451 4455 4465 5040 5041 5042 5309 5332 5333 5334 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 7421 7425 7442 7446 7630 7651 CBA Res, Zero ohm, "Chip" Jumper . . Res, Zero ohm, "Chip" Jumper . . Res, Zero ohm, "Chip" Jumper . . Coil, 4u7. . . . . . . . . . . . Coil, 4u7. . . . . . . . . . . . Coil, 4u7. . . . . . . . . . . . Coil, 6u8. . . . . . . . . . . . Coil, 6u8. . . . . . . . . . . .
PAGE 185
27PT81S125 (continued) 2806 2807 2808 2809 2810 2811 2812 2813 2814 2815 2816 2817 2818 2819 2820 2821 2822 2823 2824 2825 2826 2827 2828 2829 2830 2831 2832 2833 2834 2836 2837 2840 2841 2890 2891 2892 2893 2894 2895 2911 2915 2916 2917 2920 2921 2923 2924 2925 2926 2927 2928 2929 2930 2931 2932 2933 2934 2935 2936 2937 3801 3802 3805 3806 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 186
27PT81S125 (continued) 7804 7805 7806 7807 7810 7813 7816 7817 7891 7910 7914 7915 7916 7917 7918 7919 7920 9800 9801 9802 9803 9804 9805 9807 9808 9810 9811 9812 9813 9814 9815 9816 9817 9818 9820 9821 9822 9823 9824 9902 9903 9905 9907 9908 9912 9915 9921 9922 9923 CBA Transistor, NPN, BC847B(COL) . Transistor, NPN, BC847B(COL) . Transistor, NPN, BC847B(COL) . Transistor, NPN, BC847B(COL) . Transistor, NPN, BC847B(COL) . Transistor, NPN, BC847B(COL) . Transistor, NPN, BC847B(COL) .
PAGE 187
27PT81S125 (continued) AC18 AC19 AC20 AC25 AC26 Quick Use Guide. . Remote Transmitter Speaker, 16 ohm, 5 Power Button . . . Power Button Shaft . . . . . . . . Watt (2 . . . . . . . . . . . . . . Used) . . . . . . . . . . . . . . . . . . . . . 3135 3139 3139 3139 3139 015 128 128 124 124 21351 76191 76071 32921 32791 Large Signal Panel Large Signal Panel S = Safety Part Be sure to use exact replacement part.
PAGE 188
27PT91S125 - Manual no. 7592 Large Signal Panel 0114 Heatsink, Bridge Rectifier . . . . . . 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . . 0136 Spring . . . . . . . . . . . . . . . . 0137 Spring . . . . . . .
PAGE 189
27PT91S125 (continued) 2977 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3258 3259 3263 3264 3265 3266 3267 3268 3269 3271 3272 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3421 3423 3430 3434 3435 3436 3437 3438 3439 3440 3441 3442 3445 3446 3447 3448 3449 3450 3452 3470 3471 3472 3473 Cap, Res, Res, Res, Res, Res
PAGE 190
27PT91S125 (continued) 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4265 4268 4269 4270 4272 4273 4274 4276 4277 4279 4280 4281 4282 4284 4285 4286 4287 4288 4291 4292 4293 4294 4295 4296 4400 4402 4403 4404 4405 4406 4407 4408 4410 Res, Res, Res, Res, Res, Res
PAGE 191
27PT91S125 (continued) 6481 6505 6511 6512 6522 6701 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7265 7273 7274 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 7992 8450 8460 9012 9015 9016 9017 9019 9020 9021 9023 9024 9026 9027 9028 9029 9032 9035 9036 9037 9200 9207 9208 9209 9210 9211 9212 9214 9215 9216 9217 Zener Diode, 33 volt . . . .
PAGE 192
27PT91S125 (continued) 9430 9431 9432 9434 9437 9438 9439 9443 9445 9494 9495 9497 9600 9700 9702 9703 9704 9705 9706 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9984 9985 9986 9987 9988 9989 9990 9992 9993 9994 9996 9998 CBA Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper .
PAGE 193
27PT91S125 (continued) 2443 2444 2445 2446 2447 2449 2450 2451 2453 2457 2458 2461 2462 2463 2464 2601 2602 2606 2607 2610 2611 2612 2613 2614 2619 2620 2621 2622 2623 2624 2625 2628 2629 2631 2632 2633 2634 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3054 3055 3056 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 194
27PT91S125 (continued) 3429 3430 3431 3432 3434 3435 3436 3437 3438 3439 3443 3444 3452 3453 3466 3467 3468 3471 3472 3473 3474 3477 3478 3480 3481 3482 3483 3484 3485 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4301 4302 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4451 4455 4465 4640 4642 5040 5041 5042 5308 5309 5310 5332 5333 5334 5401 5421 5422 5425 5426 5435 5601 5602 5625 5665 6031 6302 6303 6412 6415 6417 6418 Res, 1K, 5%, 1/16W, Metalize
PAGE 195
27PT91S125 (continued) 3881 3882 3886 3888 3890 3893 3896 4801 5842 5860 5861 5862 5886 5888 5890 6831 6832 6833 6835 6837 6838 6861 6862 6867 6868 6869 6870 7830 7860 7861 7862 7863 7870 7870 9801 9802 9803 9821 9822 9823 9824 9840 9861 9877 CBA DAF Res, Zero ohm, "Chip" Jumper . . . . . Res, 220 ohm, 5%, 1/6W, Carbon Film. . Res, 560 ohm, 5%, 1/10W, Metalized Glas Res, 560 ohm, 5%, 1/10W, Metalized Glas Res, 560 ohm, 5%, 1/10W, Metalized Glas Jumper . . . . . . . . . . . . . . . . Jumper . . . . . . . .
PAGE 196
27PT91S125 (continued) 2874 2876 2877 2878 2891 2898 2899 3263 3264 3267 3268 3270 3301 3302 3305 3311 3312 3315 3316 3318 3321 3322 3324 3326 3327 3329 3330 3333 3334 3335 3336 3338 3339 3340 3341 3344 3346 3347 3348 3364 3365 3370 3371 3374 3381 3382 3383 3384 3385 3386 3387 3388 3389 3390 3401 3402 3403 3404 3405 3411 3412 3413 3414 3415 3416 3417 3418 3419 3422 3423 3424 3431 3432 3434 3436 3437 3438 3439 3451 3453 3456 3457 3458 3460 3461 3462 3501 3502 3503 3504 3506 3507 Res, Cap, Cap, Cap, Cap, Cap
PAGE 197
27PT91S125 (continued) 5501 5816 5818 5827 5834 5839 5848 5849 5851 5853 6412 6415 6436 6801 6802 7201 7301 7305 7307 7331 7337 7368 7385 7386 7401 7402 7403 7411 7412 7421 7422 7434 7435 7438 7501 7801 7802 7803 7804 7805 7806 7807 7808 7809 7810 7824 7828 7871 7874 7876 7891 7892 7893 7894 7895 CBA Coil, 6u8. . . . . . . . . . . Inductor, Fixed 100MHz 120ohm. Inductor, Fixed 100MHz 120ohm. Inductor, Fixed 100MHz 120ohm. Inductor, Fixed 100MHz 120ohm. Inductor, Fixed 100MHz 120ohm.
PAGE 198
27PT91S125 (continued) 2501 2502 2503 2504 2505 2506 2507 2508 2509 2511 2811 2812 2813 2814 2816 2817 2818 2819 2821 2822 2823 2824 2825 2826 2827 2828 2829 2831 2832 2833 2834 2836 2837 2838 2839 2841 2842 2843 2844 2846 2847 2848 2849 2851 2852 2853 2854 2856 2857 2861 2862 2863 2864 2866 2867 2868 2869 2871 2872 2873 2874 2876 2877 2878 2891 2898 2899 3100 3101 3102 3103 3104 3105 3106 3107 3108 3109 3110 3111 3112 3113 3114 3115 3116 3117 3118 3119 3120 3121 3121 3122 3123 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 199
27PT91S125 (continued) 4702 6751 6752 6753 6754 7751 7752 7753 7754 CBA Res, Zero ohm, "Chip" Jumper . Diode, Signal. . . . . . . . . Diode, Signal. . . . . . . . . Diode, Signal. . . . . . . . . Diode, Signal. . . . . . . . . Transistor, PNP, BC857B(COL) . Transistor, NPN, BC847B(COL) . Transistor, PNP, BC857B(COL) . Transistor, NPN, BC847B(COL) . M-Link Assembly (With Matrix). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 200
27RF70S125 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0121 Deflection Heatsink. . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 201
27RF70S125 (continued) 3272 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3421 3423 3430 3434 3435 3436 3437 3438 3439 3440 3441 3442 3445 3446 3447 3448 3449 3450 3452 3470 3471 3472 3473 3476 3477 3478 3479 3480 3481 3482 3483 3484 3485 3487 3488 3489 3490 3491 3501 3503 3504 3511 3512 3513 3521 3522 3523 3524 3526 3527 3528 3530 3701 3702 3704 3705 3706 3707 3708 3709 3710 3711 3712 3713 3715 3716 3717 3719 3720 3721 3722 Res, Res, Res, Res, Res, Res
PAGE 202
27RF70S125 (continued) 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 4272 4273 4274 4276 4279 4281 4282 4284 4285 4286 4287 4288 4291 4292 4293 4294 4295 4296 4400 4402 4403 4404 4405 4406 4407 4408 4410 4412 4502 4503 4702 4704 4706 4707 4708 4709 4710 4711 4712 4713 4714 4715 4716 4717 4718 4901 4902 4903 5201 5202 5203 5204 5261 5262 5406 5409 5411 5417 5417 5430 5431 5445 5446 5448 5475 5475 5521 5523 5524 5701 5702 5902 5912 5920 5924 Res, Zero ohm, "Chip" Jumper
PAGE 203
27RF70S125 (continued) 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 7992 9012 9015 9016 9017 9019 9020 9021 9023 9024 9026 9027 9028 9029 9032 9035 9036 9037 9040 9200 9201 9202 9203 9207 9208 9209 9210 9211 9212 9214 9215 9216 9217 9218 9219 9220 9221 9222 9226 9227 9228 9229 9231 9232 9233 9234 9235 9236 9238 9239 9241 9242 9243 9244 9245 9246 9248 9249 9250 9251 9252 9253 9254 9255 9256 9258 9259 9260 9261 9262 9263 9264 9265 9266 9267 9268 9269 9270 9271 9272 9273 Transistor, NPN, IC . . . .
PAGE 204
27RF70S125 (continued) 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9984 9985 9986 9987 9988 9990 9992 9993 9994 9996 9998 CBA Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Large Signal .
PAGE 205
27RF70S125 (continued) 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3054 3055 3056 3057 3058 3059 3061 3062 3064 3065 3066 3081 3082 3083 3084 3085 3086 3088 3092 3301 3302 3305 3307 3311 3312 3315 3316 3324 3326 3327 3328 3329 3330 3331 3332 3333 3334 3339 3340 3341 3342 3344 3345 3348 3349 3358 3361 3362 3363 3364 3365 3371 3372 3373 3374 3375 3376 3377 3378 3381 3382 3383 3384 3385 3387 3388 3393 3394 3397 3401 3402 3403 3404 3405 3411 3412 3413 3414 3415 3416 3417 Res, Res, Res, Res, Res, Res
PAGE 206
27RF70S125 (continued) 7407 7412 7415 7421 7425 7442 7446 7630 7651 CBA IC . . . . . . . . . . . . . . Transistor, NPN, BC847BS . . . Transistor, NPN, BC847BS . . . Transistor, NPN, BC847BW(COL). Transistor, NPN, BC847BW(COL). Transistor, NPN, BC847BW(COL). Transistor, NPN, BC847BW(COL). IC . . . . . . . . . . . . . . IC . . . . . . . . . . . . . . Small Signal Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 207
27RF70S125 (continued) 2892 2893 2894 2895 2911 2930 2931 2932 2933 2934 2935 2936 2937 2941 3801 3802 3805 3806 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3956 3958 3960 3961 3962 3968 3969 3970 4803 4804 4805 4806 4807 4808 4809 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 208
27RF70S125 (continued) 7752 7753 7754 CBA Transistor, NPN, BC847B(COL) . Transistor, PNP, BC857B(COL) . Transistor, NPN, BC847B(COL) . M-Link Assembly (With Matrix). . . . . . . . . . . . . . . . . 3198 3198 3198 3139 010 010 010 178 42030 42150 42030 89081 MATRIX ASSY (W/O MLINK)-GREY MATRIX ASSY (W/O MLINK)-GREY 0028 Matrix Bracket, W/O MLINK ASSY - GY. 0167 Cable Asm. . . . . . . . . . . . . . 0224 6 Pin Connector. . . . . . . . . . . 0245 4 Pin Connector. . . . . . . . . . .
PAGE 209
29LP602221 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 210
29LP602221 (continued) 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3421 3423 3430 3434 3435 3436 3437 3438 3439 3440 3441 3442 3445 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 211
29LP602221 (continued) 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3971 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 4272 4273 4274 4279 4281 4282 4284 4285 4286 4287 4288 4291 4292 Res, Res, Res, Res, Res, Res
PAGE 212
29LP602221 (continued) 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6474 6474 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 7992 8111 8222 8450 8460 9012 9015 9016 9017 9019 9020 9021 9023 9024 9026 9027 9028 9029 Diode, Signal. . . . . . . .
PAGE 213
29LP602221 (continued) 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9446 9464 9465 9466 9467 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9984 9985 Jumper Jumper Jumper Jumper
PAGE 214
29LP602221 (continued) 2424 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3054 3055 3056 3057 3058 3059 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 215
29LP602221 (continued) 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 5040 5041 5042 5309 5332 5333 5334 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 7421 7425 7442 7446 7630 7651 CBA Res, Zero ohm, "Chip" Jumper . . . . . Res, 4K7, 5%, 1/16W, Metalized Glass .
PAGE 216
29LP602221 (continued) 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3933 3934 3936 3937 3938 3939 3942 3943 3944 3945 3946 3947 3948 3949 3950 3951 3952 3953 3955 3956 3957 3958 3960 3961 3962 3964 3965 3968 3969 3970 3971 3972 4803 4804 4805 4807 4808 4809 Res, 15K, 5%, 1/10W, Metalized Glass .
PAGE 217
29LP602221 (continued) 4701 4702 6751 6752 6753 6754 7751 7752 7753 7754 CBA Res, Zero ohm, "Chip" Jumper . Res, Zero ohm, "Chip" Jumper . Diode, Signal. . . . . . . . . Diode, Signal. . . . . . . . . Diode, Signal. . . . . . . . . Diode, Signal. . . . . . . . . Transistor, PNP, BC857B(COL) . Transistor, NPN, BC847B(COL) . Transistor, PNP, BC857B(COL) . Transistor, NPN, BC847B(COL) . M-Link Assembly (With Matrix). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 218
32PT41B121 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 219
32PT41B121 (continued) 2941 2942 2943 2945 2961 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3422 3430 3435 3436 3437 3438 3439 3440 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 220
32PT41B121 (continued) 3911 3913 3917 3923 3924 3925 3926 3928 3931 3932 3942 3943 3944 3947 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 Positive Temperature Coefficient,
PAGE 221
32PT41B121 (continued) 6266 6267 6268 6271 6273 6274 6275 6276 6279 6413 6414 6419 6420 6439 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 Diode, Signal. . . . . . . .
PAGE 222
32PT41B121 (continued) 9280 9281 9283 9284 9285 9286 9287 9288 9289 9290 9291 9292 9293 9294 9295 9296 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 Jumper Jumper Jumper Jumper
PAGE 223
32PT41B121 (continued) 2401 2402 2403 2404 2405 2407 2408 2412 2413 2415 2417 2421 2422 2423 2424 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 224
32PT41B121 (continued) 3423 3424 3425 3426 3427 3428 3429 3430 3434 3437 3438 3466 3467 3468 3471 3472 3473 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4304 4308 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 4684 5040 5041 5042 5309 5332 5333 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7066 7301 7305 7307 7331 7368 7401 7405 7407 7412 7415 7421 Res, 100 ohm, 5%, 1/16W, Met
PAGE 225
32PT41B121 (continued) 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3956 3958 3960 3961 3962 3968 3969 3970 4803 4804 4805 4806 4807 4808 4809 4810 4812 4813 4814 4815 4817 4818 4819 4821 4901 5890 5891 5892 5902 6801 6890 7801 7803 Res, 1K5, 5%, 1/10W, Metaliz
PAGE 226
32PT41B121 (continued) 0240 1254 1255 1256 2286 2288 2292 2294 2296 2297 3285 3286 3287 3288 3289 3291 3292 3293 3294 3295 3296 3297 4241 4243 4244 4245 4246 6291 6292 6293 6294 9237 9238 9239 CBA 11 Pin Connector . . . . . . . . . . Socket, Phone. . . . . . . . . . . . Socket . . . . . . . . . . . . . . . Socket . . . . . . . . . . . . . . . Cap, 150p, ±10%, 50v, Ceramic. . . . Cap, 150p, ±10%, 50v, Ceramic. . . . Cap, 470p, ±10%, 50v, Ceramic. . . . Cap, 470p, ±10%, 50v, Ceramic. . . .
PAGE 227
32PT41B129 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 228
32PT41B129 (continued) 2050 2051 2053 2301 2302 2303 2306 2309 2311 2312 2313 2314 2316 2317 2319 2321 2322 2323 2324 2325 2326 2327 2328 2332 2333 2334 2335 2338 2342 2345 2348 2350 2354 2355 2356 2357 2372 2373 2374 2375 2376 2377 2380 2381 2382 2401 2402 2403 2404 2405 2407 2408 2412 2413 2415 2417 2421 2422 2423 2424 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 Cap, 100p, ±5%, 50v, Ceramic . .
PAGE 229
32PT41B129 (continued) 3340 3341 3342 3344 3345 3348 3349 3358 3361 3362 3363 3364 3365 3371 3372 3373 3374 3375 3376 3377 3378 3381 3382 3383 3384 3385 3387 3388 3393 3394 3397 3401 3402 3403 3404 3405 3411 3412 3413 3414 3415 3416 3417 3418 3419 3422 3423 3424 3425 3426 3427 3428 3429 3430 3434 3437 3438 3466 3467 3468 3471 3472 3473 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4304 4308 4309 4312 4313 4316 4317 4318 4319 4320 4401 Res, Res, Res, Res, Res, Res
PAGE 230
32PT41B129 (continued) 2812 2813 2814 2815 2816 2817 2818 2819 2820 2821 2822 2823 2824 2825 2826 2827 2828 2829 2830 2831 2832 2833 2834 2836 2837 2840 2841 2890 2891 2892 2893 2894 2895 2911 2930 2931 2932 2933 2934 2935 2936 2937 2941 3801 3802 3805 3806 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 231
32PT41B129 (continued) 9923 CBA Jumper . . . . . . . . . . . . . . . . PIP Panel. . . . . . . . . . . . . . . M-Link Assembly (With Matrix) M-Link Assembly (With Matrix) 0028 MLINK BRACKET-V0 . . . . . . . . . . . 0167 Cable Asm. . . . . . . . . . . . . . . 0224 6 Pin Connector. . . . . . . . . . . . 0245 4 Pin Connector. . . . . . . . . . . . 0249 6 Pin Connector. . . . . . . . . . . . 2752 Cap, 100n, ±10%, 16v, Ceramic. . . . . 2754 Cap, 10n, ±10%, 50v, Ceramic . . . . .
PAGE 232
32PT71B121 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 233
32PT71B121 (continued) 2939 2941 2942 2943 2945 2961 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3422 3430 3435 3436 3437 3438 3439 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 234
32PT71B121 (continued) 3902 3911 3913 3917 3923 3924 3925 3926 3928 3931 3932 3942 3943 3944 3947 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 Res, 2M2, 5%, 1/2W, Metalized Gla
PAGE 235
32PT71B121 (continued) 6208 6238 6266 6267 6268 6271 6273 6274 6275 6276 6279 6413 6414 6419 6420 6439 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 Zener Diode, 12 volt . . . .
PAGE 236
32PT71B121 (continued) 9278 9279 9280 9281 9283 9284 9285 9286 9287 9288 9289 9290 9291 9292 9293 9294 9295 9296 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 Jumper Jumper Jumper Jumper
PAGE 237
32PT71B121 (continued) 2380 2381 2382 2401 2402 2403 2404 2405 2407 2408 2412 2413 2415 2417 2421 2422 2423 2424 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 238
32PT71B121 (continued) 3423 3424 3425 3426 3427 3428 3429 3430 3434 3437 3438 3466 3467 3468 3471 3472 3473 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 5040 5041 5042 5309 5332 5333 5334 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 7421 Res, 100 ohm, 5%, 1/16W, Met
PAGE 239
32PT71B121 (continued) 2931 2932 2933 2934 2935 2936 2937 3801 3802 3805 3806 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3933 3934 3936 3937 3938 3939 3942 3943 3944 3945 3946 3947 3948 3949 3950 3951 3952 3953 3955 3956 Cap, 100n, ±10%, 16v, Ceramic. . . . .
PAGE 240
32PT71B121 (continued) CBA IR Blaster . . . . . . . . . . . . . . M-Link Assembly (With Matrix) M-Link Assembly (With Matrix) 0028 MLINK BRACKET-V0 . . . . . . . . . . . 0167 Cable Asm. . . . . . . . . . . . . . . 0224 6 Pin Connector. . . . . . . . . . . . 0245 4 Pin Connector. . . . . . . . . . . . 0249 6 Pin Connector. . . . . . . . . . . . 2752 Cap, 100n, ±10%, 16v, Ceramic. . . . . 2754 Cap, 10n, ±10%, 50v, Ceramic . . . . . 2755 Cap, 10n, ±10%, 50v, Ceramic . . . . .
PAGE 241
32PT71B129 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 242
32PT71B129 (continued) 2942 2943 2945 2961 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3422 3430 3435 3436 3437 3438 3439 3440 3441 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 243
32PT71B129 (continued) 3913 3917 3923 3924 3925 3926 3928 3931 3932 3942 3943 3944 3947 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 Res, Res, Res, Res, Res, Res
PAGE 244
32PT71B129 (continued) 6268 6271 6273 6274 6275 6276 6279 6413 6414 6419 6420 6439 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 Zener Diode, 8.2 volt. . . .
PAGE 245
32PT71B129 (continued) 9281 9283 9284 9285 9286 9287 9288 9289 9290 9291 9292 9293 9294 9295 9296 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 9972 Jumper Jumper Jumper Jumper
PAGE 246
32PT71B129 (continued) 2401 2402 2403 2404 2405 2407 2408 2412 2413 2415 2417 2421 2422 2423 2424 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 247
32PT71B129 (continued) 3426 3427 3428 3429 3430 3434 3437 3438 3466 3467 3468 3471 3472 3473 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 5040 5041 5042 5309 5332 5333 5334 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 7421 7425 7442 7446 Res, 820 ohm, 5%, 1/16W, Met
PAGE 248
32PT71B129 (continued) 2934 2935 2936 2937 3801 3802 3805 3806 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3933 3934 3936 3937 3938 3939 3942 3943 3944 3945 3946 3947 3948 3949 3950 3951 3952 3953 3955 3956 3957 3958 3960 Cap, 100n, ±10%, 16v, Ceramic. . . . .
PAGE 249
32PT71B129 (continued) 0028 0167 0224 0245 0249 2752 2754 2755 2756 2757 3751 3752 3754 3755 4701 4702 6751 6752 6753 6754 7751 7752 7753 7754 CBA MLINK BRACKET-V0 . . . . . . . . . . . Cable Asm. . . . . . . . . . . . . . . 6 Pin Connector. . . . . . . . . . . . 4 Pin Connector. . . . . . . . . . . . 6 Pin Connector. . . . . . . . . . . . Cap, 100n, ±10%, 16v, Ceramic. . . . . Cap, 10n, ±10%, 50v, Ceramic . . . . . Cap, 10n, ±10%, 50v, Ceramic . . . . . Cap, 1u, +80/-20%, 16v, Ceramic. . . .
PAGE 250
32PT81S121 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . 4835 310 57608 Large Signal Panel 0115 Trans Heatsink . . . . . . . . . . . . 3139 0116 Trans Heatsink . . . . . . . . . . . . 3139 0121 Deflection Heatsink. . . . . . . . . . 3139 0122 Sanken Heatsink. . . . . . . . . . . . 3139 0123 Audio Heatsink . . . . . . . . . . . . 3139 0124 Heatsink 5V, A10. . . . . . . . . . . 3139 0125 U-Cooling Plate. . . . . . . . . . . . 3139 0127 Fuse Holder. . . . . . . . . . . . .
PAGE 251
32PT81S121 (continued) 2963 2964 2966 2967 2968 2969 2970 2974 2977 3024 3025 3026 3027 3028 3029 3030 3031 3032 3033 3034 3035 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3272 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3430 3434 3435 3436 3437 3438 3439 3440 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 252
32PT81S121 (continued) 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4005 4010 4011 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 4272 4273 4274 4276 4279 4281 4282 4284 4285 4286 4287 4288 4291 Res, Res, Res, Res, Res, Res
PAGE 253
32PT81S121 (continued) 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7012 7013 7014 7015 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 7992 9012 9015 9016 9017 9019 9020 9021 9023 9024 9026 9027 9028 9029 Diode, Signal. . . . . . . .
PAGE 254
32PT81S121 (continued) 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9441 9442 9443 9445 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9984 9985 9986 9987 9988 9990 9992 9993 9994 Jumper Jumper Jumper Jumper
PAGE 255
32PT81S121 (continued) 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3054 3055 3056 3057 3058 3059 3061 3062 3064 3065 3066 3081 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 256
32PT81S121 (continued) 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 5040 5041 5042 5309 5332 5333 5334 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 7421 7425 7442 7446 7630 7651 CBA Res, 390 ohm, 5%, 1/16W, Metalized Glas Res, 390 ohm, 5%, 1/16W, Metalized Glas Res, 820 ohm, 5%, 1/16W, Metalized
PAGE 257
32PT81S121 (continued) CBA DAF CRT M-Board. . . . . . . . . . . . . . 3139 127 20831 SUB-ASSEMBLY DAF SUB-ASSEMBLY Double Window PIP Panel Double Window PIP Panel Guide Plus Panel Guide Plus Panel PIP Panel (2 Tuner) PIP Panel (2 Tuner) 0025 SHIELD 56P 8 . . . . . . . . . . . . . 0162 Cable Asm. . . . . . . . . . . . . . . 0166 Cable Asm. . . . . . . . . . . . . . . 0178 Wire Cable Asm, 3P/280/3P EHR 26OS BK 0200 5 Pin Connector. . . . . . . . . . . . 0201 10 Pin Connector . . . . . . . . . . .
PAGE 258
32PT81S121 (continued) 3969 3970 3971 3972 4803 4804 4805 4807 4808 4809 4810 4812 4813 4814 4815 4817 4818 4819 4821 5890 5891 5892 5901 5902 5903 5905 5906 6801 6890 7801 7803 7804 7805 7806 7807 7810 7813 7816 7817 7891 7910 7914 7915 7916 7917 7918 7919 7920 9800 9801 9802 9803 9804 9805 9807 9808 9810 9811 9812 9813 9814 9815 9816 9817 9818 9820 9821 9822 9823 9824 9902 9903 9905 9907 9908 9912 9915 9921 9922 9923 CBA Res, 330 ohm, 5%, 1/10W, Metalized Glas Res, 390 ohm, 5%, 1/10W, Metalized Glas Res,
PAGE 259
32PT81S121 (continued) AC16 AC17 AC18 AC19 AC20 AC25 AC26 Owner's Manual . . Owner's Manual for Quick Use Guide. . Remote Transmitter Speaker, 16 ohm, 5 Power Button Cover Power Button Shaft . . . . M-Link. . . . . . . . . Watt (2 . . . . . . . . . . . . . . . . . . . . used) . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 260
32PT81S127 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . 4835 310 57608 Large Signal Panel 0115 Trans Heatsink . . . . . . . . . . . . 3139 0116 Trans Heatsink . . . . . . . . . . . . 3139 0121 Deflection Heatsink. . . . . . . . . . 3139 0122 Sanken Heatsink. . . . . . . . . . . . 3139 0123 Audio Heatsink . . . . . . . . . . . . 3139 0124 Heatsink 5V, A10. . . . . . . . . . . 3139 0125 U-Cooling Plate. . . . . . . . . . . . 3139 0127 Fuse Holder. . . . . . . . . . . . .
PAGE 261
32PT81S127 (continued) 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3024 3025 3026 3027 3028 3029 3030 3031 3032 3033 3034 3035 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3272 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3421 3423 3430 3434 3435 3436 3437 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 262
32PT81S127 (continued) 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4005 4010 4011 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 4272 4273 4274 4276 4279 4281 4282 4284 4285 4286 Res, Res, Res, Res, Res, Res
PAGE 263
32PT81S127 (continued) 6420 6439 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7012 7013 7014 7015 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 7992 9012 9015 9016 9017 9019 9020 9021 9023 9024 9026 Diode, Rect, BYD33D . . . .
PAGE 264
32PT81S127 (continued) 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9441 9442 9443 9445 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9984 9985 9986 9987 9988 Jumper Jumper Jumper Jumper
PAGE 265
32PT81S127 (continued) 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3054 3055 3056 3057 3058 3059 3061 3062 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 266
32PT81S127 (continued) 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 5040 5041 5042 5309 5332 5333 5334 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 7421 7425 7442 7446 7630 7651 CBA Res, 10 ohm, 5%, 1/16W, Metalized Glass Res, 560 ohm, 5%, 1/10W, Metalized Glas Res, 1K, 5%, 1
PAGE 267
32PT81S127 (continued) 2892 2893 2894 2895 2911 2915 2916 2917 2920 2921 2923 2924 2925 2926 2927 2928 2929 2930 2931 2932 2933 2934 2935 2936 2937 3801 3802 3805 3806 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3933 3934 3936 3937 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 268
32PT81S127 (continued) 9821 9822 9823 9824 9902 9903 9905 9907 9908 9912 9915 9921 9922 9923 CBA Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . Jumper . . . PIP Panel (2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Tuner). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 269
32PT81S128 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0121 Deflection Heatsink. . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0152 Dipmate Cable Asm. . . . . . . . . . . 0153 Dipmate Cable Asm. . . . . . . . . . .
PAGE 270
32PT81S128 (continued) 2964 2966 2967 2969 2970 2974 2977 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3272 3273 3274 3276 3277 3278 3280 3281 3282 3283 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3421 3422 3423 3430 3434 3435 3436 3437 3438 3439 3440 3441 3442 3445 3446 3447 3448 3449 3452 3470 3471 3472 3473 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 271
32PT81S128 (continued) 3892 3901 3902 3905 3911 3913 3917 3923 3924 3925 3926 3928 3929 3931 3932 3942 3943 3944 3947 3957 3958 3959 3961 3962 3965 3966 3967 3969 3970 3977 3986 3987 3989 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4210 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4251 4252 4253 4255 4256 4257 4258 4259 4260 4261 4263 4268 4269 4270 Vage Dependent Resistor, DC, 1mA/ 50Vo
PAGE 272
32PT81S128 (continued) 6420 6439 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 S 6838 6904 6905 6915 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7860 7861 7862 7864 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 8222 9003 9012 9015 9016 9017 9019 9020 Diode, Rect, BYD33D . . .
PAGE 273
32PT81S128 (continued) 9294 9295 9296 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9431 9432 9434 9437 9438 9439 9441 9443 9466 9494 9495 9600 9700 9702 9703 9704 9705 9706 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9863 9877 9901 9902 9903 9909 9911 9912 9921 9922 9923 9933 9937 9948 9964 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 9984 9985 9986 9987 9988 Jumper Jumper Jumper Jumper
PAGE 274
32PT81S128 (continued) 2430 2431 2432 2435 2436 2437 2438 2443 2447 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2629 2631 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 3024 3030 3031 3034 3035 3042 3043 3044 3045 3046 3051 3052 3054 3055 3056 3057 3058 3059 3061 3062 3064 3065 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 275
32PT81S128 (continued) 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4023 4304 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4431 4434 4435 4455 4640 5040 5041 5042 5309 5332 5333 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 7421 7425 7442 7444 7446 7630 7651 CBA Res, 390 ohm, 5%, 1/16W, Metalized Glas Res, 390 ohm, 5%, 1/16W, Metalized Glas Res, 820 ohm, 5%, 1/16W, Metalized Glas Res,
PAGE 276
32PT81S128 (continued) 3856 3859 3860 3864 3866 3870 3871 3872 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3933 3934 3936 3937 3939 3943 3945 3946 3947 3948 3949 3950 3951 3952 3953 3955 3956 3957 3958 3960 3961 3962 3963 3964 3965 3968 3969 3970 3971 3972 4803 4804 4805 4807 4808 4809 4810 4812 4813 4814 4815 4819 4821 4822 5901 5903 6890 7801 7803 7804 7805 7806 7807 7810 7813 7816 7817 7910 7914 7915 7916 7917 7918 7919 7920 7920 CBA Res, 1K, 5%, 1/10W, Metalized Glass. .
PAGE 277
32PT81S128 (continued) 3853 3854 3855 3856 3857 3859 3860 3864 3866 3870 3871 3872 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3934 3936 3937 3939 3942 3943 3945 3946 3947 3948 3949 3950 3951 3952 3953 3955 3956 3957 3958 3960 3961 3962 3964 3965 3968 3969 3970 3971 3972 4803 4804 4805 4807 4808 4809 4812 4813 4817 4819 5891 5901 5902 5903 5906 6890 7801 7803 7804 7805 7806 7807 7810 7813 7816 7817 7910 7914 7915 7916 7917 7918 7919 7920 CBA Res, 3K3, 5%, 1/10W, Metalized Glass .
PAGE 278
32PT81S128 (continued) 1008 2001 3001 3003 3004 3008 CBA LED. . . . . . . . . . . . . . . . . Cap, 100u, ±20%, 25v, Electrolytic . Res, 470 ohm, 5%, 1/6W, Carbon Film. Res, 680 ohm, 5%, 1/6W, Carbon Film. Res, 1 ohm, 5%, 1/6W, Carbon Film. . Res, 4M7, 5%, 1/2W, Metalized Glass. Front Interface Panel. . . . . . . . 9322 3198 3198 3198 3198 2322 3139 050 025 011 011 011 242 178 99682 31010 04710 06810 01080 13475 65661 Top Control Panel Top Control Panel 0158 Wire Cable Asm., 3P-1340 . . . . . . .
PAGE 279
32PT91S121 - Manual no. 7592 Large Signal Panel 0114 Heatsink, Bridge Rectifier . . . . 0115 Trans Heatsink . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . 0121 Deflection Heatsink. . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . 0136 Spring . . . . . . . . . . . . . . 0137 Spring . . . . . . .
PAGE 280
32PT91S121 (continued) 2943 2945 2961 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3024 3025 3026 3027 3028 3029 3030 3031 3032 3033 3034 3035 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3258 3259 3263 3264 3265 3266 3267 3268 3269 3271 3272 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 281
32PT91S121 (continued) 3944 3947 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4005 4010 4011 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 4265 4268 4269 4270 4272 4273 4274 4276 4277 4279 4280 Res, Res, Res, Res, Res, Res
PAGE 282
32PT91S121 (continued) 6276 6279 6413 6414 6420 6439 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7012 7013 7014 7015 7224 7265 7273 7274 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 7971 7987 7990 7991 7992 9012 9015 9016 Diode, Signal. . . . . . . .
PAGE 283
32PT91S121 (continued) 9294 9295 9296 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9441 9442 9443 9445 9494 9495 9497 9600 9700 9702 9703 9704 9705 9706 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 9968 9970 9972 9973 9974 9975 9976 9977 9978 9979 9980 9981 9982 9983 Jumper Jumper Jumper Jumper
PAGE 284
32PT91S121 (continued) 2407 2408 2412 2413 2415 2417 2420 2421 2422 2423 2424 2425 2427 2428 2429 2430 2431 2432 2433 2434 2435 2437 2438 2439 2440 2441 2442 2443 2444 2445 2446 2447 2449 2450 2451 2453 2457 2458 2461 2462 2463 2464 2601 2602 2606 2607 2610 2611 2612 2613 2614 2619 2620 2621 2622 2623 2624 2625 2628 2629 2631 2632 2633 2634 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 3002 3003 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 285
32PT91S121 (continued) 3393 3394 3397 3401 3402 3403 3404 3405 3406 3407 3408 3411 3412 3413 3414 3415 3416 3417 3418 3419 3422 3423 3424 3425 3426 3427 3428 3429 3430 3431 3432 3434 3435 3436 3437 3438 3439 3443 3444 3452 3453 3466 3467 3468 3471 3472 3473 3474 3477 3478 3480 3481 3482 3483 3484 3485 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4301 4302 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4451 4455 4465 4640 Res, Res, Res, Res, Res, Res
PAGE 286
32PT91S121 (continued) 3834 3835 3836 3837 3838 3839 3840 3841 3842 3843 3845 3860 3861 3862 3863 3864 3865 3866 3869 3870 3871 3872 3873 3874 3875 3876 3878 3880 3881 3882 3886 3888 3890 3893 3896 4801 5842 5860 5861 5862 5886 5888 5890 6831 6832 6833 6835 6837 6838 6861 6862 6867 6868 6869 6870 7830 7860 7861 7862 7863 7870 7870 9801 9802 9803 9821 9822 9823 9824 9840 9876 9877 CBA Res, 1K, 20%, 1/2W, Carbon Film. . . . Res, 100 ohm, 5%, 1/6W, Carbon Film. . Res, 1K, 20%, 1/2W, Carbon Film. . . .
PAGE 287
32PT91S121 (continued) 2415 2431 2432 2434 2436 2501 2502 2503 2504 2505 2506 2507 2508 2509 2511 2811 2812 2813 2814 2816 2817 2818 2819 2821 2822 2823 2824 2825 2826 2827 2828 2829 2831 2832 2833 2834 2836 2837 2838 2839 2841 2842 2843 2844 2846 2847 2848 2849 2851 2852 2853 2854 2856 2857 2861 2862 2863 2864 2866 2867 2868 2869 2871 2872 2873 2874 2876 2877 2878 2891 2898 2899 3263 3264 3267 3268 3270 3301 3302 3305 3311 3312 3315 3316 3318 3321 3322 3324 3326 3327 3329 3330 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 288
32PT91S121 (continued) 3828 3829 3831 3832 3833 3834 3836 3837 3838 3839 3846 3852 3854 3856 3857 3858 3862 3863 3866 3868 3869 3871 3872 3873 3874 3876 3878 3879 3880 3881 3884 3886 3887 3888 3889 3890 3891 3892 3893 3894 3895 3896 3897 3898 4301 4306 4309 4310 4311 4312 4313 4315 4438 4827 4828 4831 5261 5309 5332 5333 5334 5349 5350 5351 5401 5501 5816 5818 5827 5834 5839 5848 5849 5851 5853 6412 6415 6436 6801 6802 7201 7301 7305 7307 7331 7337 7368 7385 7386 7401 7402 7403 Res, 220 ohm, 5%, 1/16W, Met
PAGE 289
32PT91S121 (continued) 2204 2207 2209 2211 2261 2262 2265 2269 2301 2302 2303 2306 2309 2311 2312 2313 2314 2316 2317 2319 2321 2322 2324 2327 2328 2331 2332 2333 2334 2335 2336 2338 2342 2345 2348 2351 2354 2355 2356 2357 2372 2373 2374 2375 2376 2377 2380 2385 2386 2390 2391 2392 2393 2401 2402 2403 2404 2405 2411 2412 2415 2431 2432 2434 2436 2501 2502 2503 2504 2505 2506 2507 2508 2509 2511 2811 2812 2813 2814 2816 2817 2818 2819 2821 2822 2823 2824 2825 2826 2827 2828 2829 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 290
32PT91S121 (continued) 3155 3202 3203 3204 3207 3263 3264 3267 3268 3270 4100 5102 5104 5106 5120 5201 6100 7005 7100 7101 7102 7103 7104 7106 7107 7108 7109 7110 7153 7200 7201 7202 7203 7204 7205 CBA CBA Res, 10K, 5%, 1/10W, Metalized Glass . Res, 27K, 5%, 1/10W, Metalized Glass . Res, 150 ohm, 5%, 1/10W, Metalized Glas Res, 1K, 5%, 1/10W, Metalized Glass. . Res, 15K, 5%, 1/10W, Metalized Glass . Res, 2K2, 5%, 1/10W, Metalized Glass . Res, 10K, 5%, 1/10W, Metalized Glass .
PAGE 291
32RF50S127 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0173 Cable Assm . . . . . . . . . . 0285 Cable Assm . . . . . . . . . . 0321 4 Pin Connector. . . . . . . . 5417 Coil, 33u. . . . . . . . . . . 5431 Transformer, S.L.O.T., Power . 5475 Coil, 450u . . . . . . . . . . 6447 Diode, Rect, BYW76-RAS15/10 . 6448 Diode, Rect, BYW76-RAS15/10 . 6474 Diode, Rect, BYW76-RAS15/10 . 7470 Field Effect transistor, Power . . . . . . . . . . . . . . . . . . . .
PAGE 292
32RF50S127 (continued) 2447 2450 2462 2471 2473 2474 2478 2484 2485 2490 2492 2501 2503 2505 2506 2521 2522 2523 2524 2531 2532 2533 2534 2536 2701 2702 2703 2704 2705 2706 2707 2708 2709 2711 2712 2713 2714 2715 2716 2717 2718 2719 2720 2722 2723 2726 2727 2728 2729 2730 2731 2732 2733 2734 2735 2736 2902 2908 2909 2915 2919 2921 2922 2925 2927 2929 2932 2936 2938 2939 2941 2942 2943 2945 2961 2962 2963 2964 2966 2967 2968 2970 2974 2977 3024 3025 3026 3027 3028 Cap, 470u, ±20%, 16v, Electrolytic . .
PAGE 293
32RF50S127 (continued) S S S S S S 3476 3477 3478 3479 3480 3481 3482 3483 3484 3485 3487 3489 3490 3491 3501 3503 3504 3511 3512 3513 3521 3522 3523 3524 3526 3527 3528 3530 3701 3702 3704 3705 3706 3707 3708 3709 3710 3711 3712 3713 3715 3716 3717 3719 3720 3721 3722 3723 3724 3725 3727 3728 3730 3731 3732 3733 3734 3735 3736 3737 3901 3902 3911 3913 3917 3923 3924 3925 3926 3928 3931 3932 3942 3943 3944 3947 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 Res, 4K7, 5
PAGE 294
32RF50S127 (continued) 4408 4410 4412 4702 4704 4706 4707 4708 4709 4710 4711 4712 4713 4714 4715 4716 4717 4718 4901 4902 4903 5012 5201 5202 5203 5204 5261 5262 5406 5409 5411 5417 5430 5445 5446 5448 5475 5521 5523 5524 5902 5912 5920 5924 5936 5939 5941 5961 5971 6010 6201 6202 6203 6204 6205 6206 6207 6208 6238 6266 6267 6268 6271 6273 6274 6275 6276 6279 6413 6414 6419 6420 6439 6440 6442 6445 6447 6448 6461 6463 6464 6468 6472 6474 6480 6481 6505 6511 6512 6522 6701 6915 Res, Zero ohm, "Chip" Jumper
PAGE 295
32RF50S127 (continued) 9222 9226 9227 9228 9229 9230 9231 9232 9233 9234 9235 9236 9238 9239 9241 9242 9243 9244 9245 9246 9248 9249 9250 9251 9252 9253 9254 9255 9256 9258 9259 9260 9261 9262 9263 9264 9265 9266 9267 9268 9269 9270 9271 9272 9273 9274 9275 9276 9277 9278 9279 9280 9281 9283 9284 9285 9286 9287 9288 9289 9290 9291 9292 9293 9294 9295 9296 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 Jumper Jumper Jumper Jumper
PAGE 296
32RF50S127 (continued) S S S S S S 2867 2868 2869 2870 2871 2872 2873 2874 2877 3831 3832 3833 3834 3835 3836 3837 3838 3839 3840 3841 3842 3843 3845 3860 3861 3862 3863 3864 3865 3866 3869 3870 3871 3872 3873 3874 3875 3876 3877 3878 3880 3881 3882 3886 3888 3890 3893 3896 4801 5842 5860 5861 5862 6831 6832 6833 6835 6837 6838 6861 6862 6867 6868 6869 7830 7860 7861 7862 7863 9801 9802 9803 9821 9822 9823 9824 9840 9876 9877 Cap, 680p, ±5%, 50v, Ceramic . . . . . Cap, 100p, ±5%, 50v, Ceramic . . . . .
PAGE 297
33LP803221 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 298
33LP803221 (continued) 2939 2941 2942 2943 2945 2961 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3422 3430 3435 3436 3437 3438 3439 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 299
33LP803221 (continued) 3902 3911 3913 3917 3923 3924 3925 3926 3928 3931 3932 3942 3943 3944 3947 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 4263 Res, 2M2, 5%, 1/2W, Metalized Gla
PAGE 300
33LP803221 (continued) 6208 6238 6266 6267 6268 6271 6273 6274 6275 6276 6279 6413 6414 6419 6420 6439 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 7944 7950 7965 7967 7968 Zener Diode, 12 volt . . . .
PAGE 301
33LP803221 (continued) 9278 9279 9280 9281 9283 9284 9285 9286 9287 9288 9289 9290 9291 9292 9293 9294 9295 9296 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 9966 Jumper Jumper Jumper Jumper
PAGE 302
33LP803221 (continued) 2380 2381 2382 2401 2402 2403 2404 2405 2407 2408 2412 2413 2415 2417 2421 2422 2423 2424 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 3023 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 303
33LP803221 (continued) 3423 3424 3425 3426 3427 3428 3429 3430 3434 3437 3438 3466 3467 3468 3471 3472 3473 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 5040 5041 5042 5309 5332 5333 5334 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 7421 Res, 100 ohm, 5%, 1/16W, Met
PAGE 304
33LP803221 (continued) 2931 2932 2933 2934 2935 2936 2937 3801 3802 3805 3806 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3933 3934 3936 3937 3938 3939 3942 3943 3944 3945 3946 3947 3948 3949 3950 3951 3952 3953 3955 3956 Cap, 100n, ±10%, 16v, Ceramic. . . . .
PAGE 305
33LP803221 (continued) CBA IR Blaster . . . . . . . . . . . . . . M-Link Assembly (With Matrix) M-Link Assembly (With Matrix) 0028 MLINK BRACKET-V0 . . . . . . . . . . . 0167 Cable Asm. . . . . . . . . . . . . . . 0224 6 Pin Connector. . . . . . . . . . . . 0245 4 Pin Connector. . . . . . . . . . . . 0249 6 Pin Connector. . . . . . . . . . . . 2752 Cap, 100n, ±10%, 16v, Ceramic. . . . . 2754 Cap, 10n, ±10%, 50v, Ceramic . . . . . 2755 Cap, 10n, ±10%, 50v, Ceramic . . . . .
PAGE 306
36PT41B129 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . 4835 310 57608 Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 2422 0115 Trans Heatsink . . . . . . . . . . . . 3139 0116 Trans Heatsink . . . . . . . . . . . . 3139 0122 Sanken Heatsink. . . . . . . . . . . . 3139 0123 Audio Heatsink . . . . . . . . . . . . 3139 0124 Heatsink 5V, A10. . . . . . . . . . . 3139 0125 U-Cooling Plate. . . . . . . . . . . . 3139 0127 Fuse Holder. . . . . . . . . . . . .
PAGE 307
36PT41B129 (continued) 2929 2932 2936 2938 2939 2941 2942 2943 2945 2961 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3272 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3422 3430 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 308
36PT41B129 (continued) 3843 3845 3892 3901 3902 3911 3913 3917 3923 3924 3925 3926 3928 3931 3932 3942 3943 3944 3947 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 Res, 1K5, 20%, 1/2W, Carbon Film . . .
PAGE 309
36PT41B129 (continued) 6203 6204 6205 6206 6207 6208 6238 6266 6267 6268 6271 6273 6274 6275 6276 6279 6413 6414 6419 6420 6439 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 Zener Diode, 12 volt . . . .
PAGE 310
36PT41B129 (continued) 9273 9274 9275 9276 9277 9278 9279 9280 9281 9283 9284 9285 9286 9287 9288 9289 9290 9291 9292 9293 9294 9295 9296 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 Jumper Jumper Jumper Jumper
PAGE 311
36PT41B129 (continued) 2374 2375 2376 2377 2380 2381 2382 2401 2402 2403 2404 2405 2407 2408 2412 2413 2415 2417 2421 2422 2423 2424 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 312
36PT41B129 (continued) 3414 3415 3416 3417 3418 3419 3422 3423 3424 3425 3426 3427 3428 3429 3430 3434 3437 3438 3466 3467 3468 3471 3472 3473 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4304 4308 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 4684 5040 5041 5042 5309 5332 5333 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7305 7307 Res, 1K5, 5%, 1/16W, Metaliz
PAGE 313
36PT41B129 (continued) 2935 2936 2937 2941 3801 3802 3805 3806 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3956 3958 3960 3961 3962 3968 3969 3970 4803 4804 4805 4806 4807 4808 4809 4810 4812 4813 4814 4815 4817 4818 4819 4821 4901 Cap, Res, Cap, Cap, Res, Res
PAGE 314
36PT41B129 (continued) 0028 0167 0224 0245 2754 2755 CBA Matrix Bracket, W/O MLINK ASSY - GY. Cable Asm. . . . . . . . . . . . . . 6 Pin Connector. . . . . . . . . . . 4 Pin Connector. . . . . . . . . . . Cap, 10n, ±10%, 50v, Ceramic . . . . Cap, 10n, ±10%, 50v, Ceramic . . . . Matrix Assembly, (W/O MLINK)-GREY. . . . . . . . . 3139 3139 2422 2422 3198 3198 3139 137 110 025 015 017 017 137 98781 38951 10738 19364 01030 01030 24331 Side Jack Panel Side Jack Panel 0240 11 Pin Connector . . . . . . . . .
PAGE 315
36PT71B129 - Manual no. 7592 Small Signal Panel 7064 IC Micro, 1US1, v4.45, SAA5647 . . . Large Signal Panel 0084 CRT socket for conventional CRT 27/32/3 0115 Trans Heatsink . . . . . . . . . . . . 0116 Trans Heatsink . . . . . . . . . . . . 0122 Sanken Heatsink. . . . . . . . . . . . 0123 Audio Heatsink . . . . . . . . . . . . 0124 Heatsink 5V, A10. . . . . . . . . . . 0125 U-Cooling Plate. . . . . . . . . . . . 0127 Fuse Holder. . . . . . . . . . . . . . 0130 Insulating Plate . . . . . . . . . . .
PAGE 316
36PT71B129 (continued) 2939 2941 2942 2943 2945 2961 2962 2963 2964 2966 2967 2968 2969 2970 2974 2977 3002 3003 3004 3007 3021 3022 3023 3037 3038 3039 3040 3201 3202 3203 3204 3206 3207 3208 3209 3211 3212 3216 3217 3218 3219 3223 3224 3225 3226 3227 3233 3234 3238 3239 3241 3242 3243 3244 3247 3248 3249 3255 3256 3257 3263 3264 3267 3268 3271 3272 3273 3274 3276 3277 3278 3280 3281 3282 3283 3286 3401 3402 3403 3405 3409 3410 3411 3412 3414 3417 3422 3430 3435 3436 3437 3438 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 317
36PT71B129 (continued) 3901 3902 3911 3913 3917 3923 3924 3925 3926 3928 3931 3932 3942 3943 3944 3947 3957 3958 3959 3961 3962 3963 3965 3966 3967 3968 3969 3970 3977 3978 3979 3986 3987 3989 3991 3992 3993 3994 3996 3997 4012 4013 4201 4202 4203 4204 4206 4207 4208 4209 4212 4213 4215 4216 4217 4219 4220 4221 4222 4223 4224 4225 4226 4227 4228 4231 4232 4233 4234 4236 4240 4241 4242 4243 4244 4245 4246 4247 4248 4249 4250 4252 4253 4254 4255 4256 4257 4258 4259 4260 4261 Res, 4M7, 5%, 1/2W, Metalized Gla
PAGE 318
36PT71B129 (continued) 6207 6208 6238 6266 6267 6268 6271 6273 6274 6275 6276 6279 6413 6414 6419 6420 6439 6440 6442 6445 6447 6447 6448 6448 6461 6463 6464 6468 6472 6474 6474 6480 6481 6505 6511 6512 6522 6701 6831 6832 6833 6835 6915 6916 6921 6926 6928 6929 6932 6938 6941 6942 6961 6966 6971 6973 6977 6986 6991 7224 7273 7276 7277 7280 7408 7410 7440 7464 7467 7470 7478 7480 7481 7501 7513 7701 7702 7703 7704 7710 7711 7712 7830 7921 7922 7929 7932 7942 7944 7950 7965 7967 Zener Diode, 12 volt . . . .
PAGE 319
36PT71B129 (continued) 9277 9278 9279 9280 9281 9283 9284 9285 9286 9287 9288 9289 9290 9291 9292 9293 9294 9295 9296 9401 9402 9403 9404 9406 9407 9408 9411 9412 9413 9414 9415 9417 9418 9420 9421 9423 9424 9425 9427 9428 9429 9430 9431 9432 9434 9437 9438 9439 9443 9445 9494 9495 9497 9600 9700 9702 9704 9705 9707 9708 9709 9710 9711 9712 9713 9714 9715 9716 9717 9718 9801 9840 9877 9901 9902 9903 9904 9905 9907 9909 9910 9911 9912 9913 9921 9922 9923 9933 9937 9939 9948 9964 Jumper Jumper Jumper Jumper
PAGE 320
36PT71B129 (continued) 2377 2380 2381 2382 2401 2402 2403 2404 2405 2407 2408 2412 2413 2415 2417 2421 2422 2423 2424 2425 2427 2428 2429 2430 2431 2432 2435 2437 2438 2439 2440 2453 2457 2458 2461 2462 2463 2601 2602 2606 2607 2612 2613 2619 2620 2621 2623 2624 2625 2628 2629 2635 2636 2637 2638 2639 2640 2641 2642 2655 2657 2661 2662 2663 2664 2665 2666 2667 2675 2676 2678 2679 2682 2683 2684 2685 2686 2687 3002 3003 3004 3007 3008 3009 3013 3014 3015 3017 3018 3019 3021 3022 Cap, Cap, Cap, Cap, Cap, Cap
PAGE 321
36PT71B129 (continued) 3422 3423 3424 3425 3426 3427 3428 3429 3430 3434 3437 3438 3466 3467 3468 3471 3472 3473 3474 3477 3478 3483 3484 3488 3489 3490 3491 3492 3493 3601 3602 3606 3619 3621 3665 4008 4306 4307 4309 4312 4313 4316 4317 4318 4319 4320 4401 4402 4403 4410 4411 4434 4435 4436 4451 4455 4465 5040 5041 5042 5309 5332 5333 5334 5401 5421 5422 5425 5426 5601 5602 5625 5665 6031 6302 6303 6412 6415 6605 7053 7063 7064 7066 7301 7307 7331 7368 7401 7405 7407 7412 7415 Res, 470 ohm, 5%, 1/16W, Met
PAGE 322
36PT71B129 (continued) 2930 2931 2932 2933 2934 2935 2936 2937 3801 3802 3805 3806 3807 3812 3813 3814 3815 3816 3817 3818 3819 3820 3821 3822 3823 3824 3825 3826 3827 3828 3829 3830 3831 3832 3833 3834 3836 3839 3840 3844 3845 3849 3850 3853 3854 3855 3856 3857 3858 3859 3860 3864 3866 3870 3871 3872 3890 3914 3915 3916 3917 3918 3919 3920 3921 3922 3923 3924 3925 3926 3927 3933 3934 3936 3937 3938 3939 3942 3943 3944 3945 3946 3947 3948 3949 3950 3951 3952 3953 3955 Cap, 100n, ±10%, 16v, Ceramic. . . . .
PAGE 323
36PT71B129 (continued) CBA IR Blaster . . . . . . . . . . . . . . M-Link Assembly (With Matrix) M-Link Assembly (With Matrix) 0028 MLINK BRACKET-V0 . . . . . . . . . . . 0167 Cable Asm. . . . . . . . . . . . . . . 0224 6 Pin Connector. . . . . . . . . . . . 0245 4 Pin Connector. . . . . . . . . . . . 0249 6 Pin Connector. . . . . . . . . . . . 2752 Cap, 100n, ±10%, 16v, Ceramic. . . . . 2754 Cap, 10n, ±10%, 50v, Ceramic . . . . . 2755 Cap, 10n, ±10%, 50v, Ceramic . . . . .