operators_manual
Table Of Contents
- Engine Operation
- Safety - Introduction
- Emergency - What To Do If
- Operating Instructions
- Engine Warning Lamps
- Stop Engine Lamp
- Engine, Check Engine
- Malfunction Indicator Lamp
- Diesel Particulate Filter (DPF) Warning Lamp
- High Exhaust System Temperature (HEST) Warning Lamp
- Diesel Exhaust Fluid (DEF) Lamp
- Engine Wait-To-Start Lamp
- Engine Braking System
- Driving
- Normal Starting Procedure
- Cold Weather Starting
- Starting Procedure After Extended Shutdown or Oil Change
- Operating the Engine
- Engine Operating Range
- Extended Idling
- Engine Shutdown
- Electromagnetic Interference
- Operating on Level and Dry Pavement
- Operating on Grades and Dry Pavement
- Tips for Operation on Slick Roads
- Engine Maintenance
- Maintenance Requirements
- Maintenance Schedule Intervals
- Preventative Maintenance Schedule
- Engine Specifications
- Engine Lubricating Oil Recommendations and Specifications
- Engine Oil Capacities and Pressures
- Engine Lubrication and Filter Intervals
- Cooling System Maintenance
- Engine Coolant Specifications
- Extended Life Coolant
- Fuel Recommendations
- Warranty and the Use of Biodiesel Fuel
- Recommendations to Avoid Fuel Gelling
- Diesel Exhaust Fluid Recommendations and Specifications
- Maintenance Procedures
- Engine Identification
- Engine Warranty
- Index
NOTE
A Maintenance Monitor feature is
available through the engine's ECM.
This feature can be enabled by a PAC-
CAR Authorized Repair Location.
CAUTION
Extending the oil and filter change in-
terval beyond the recommendations
will decrease the engine life due to
factors such as corrosion, deposits,
and wear. Engine oil filters capture dirt
and remove deposits from the oil to
prolong the life of internal moving com-
ponents. Follow the oil and filter
change intervals as recommended in
this section of the manual. Failure to
comply may result in equipment or
property damage.
Vehicles Average
Speed
Miles Kilometers Hours Months
Typical
Application(s)
Below 5 mph 1,500 2,400 500 6 Shuttle or Transit
bus
5 to 10 mph 4,000 6,450 500 6 Shuttle or Transit
bus, Refuse truck,
Cement mixer,
Dump truck, Feedlot
truck, Yard spotter
10 to 15 mph 6,000 9,650 500 6
15 to 20 mph 8,500 13,700 500 6 Cement mixer,
Dump truck, Truck
crane, Fire truck/
Emergency vehicle,
School bus, Delivery
truck
20 to 25 mph 10,500 16,900 500 6
ENGINE MAINTENANCE - Engine Lubrication and Filter Intervals
Y53-1185-1E1 (04/16/18) 47
2