operators_manual
Table Of Contents
- Engine Operation
- Safety - Introduction
- Emergency - What To Do If
- Operating Instructions
- Engine Warning Lamps
- Stop Engine Lamp
- Engine, Check Engine
- Malfunction Indicator Lamp
- Diesel Particulate Filter (DPF) Warning Lamp
- High Exhaust System Temperature (HEST) Warning Lamp
- Diesel Exhaust Fluid (DEF) Lamp
- Engine Wait-To-Start Lamp
- Engine Braking System
- Driving
- Normal Starting Procedure
- Cold Weather Starting
- Starting Procedure After Extended Shutdown or Oil Change
- Operating the Engine
- Engine Operating Range
- Extended Idling
- Engine Shutdown
- Electromagnetic Interference
- Operating on Level and Dry Pavement
- Operating on Grades and Dry Pavement
- Tips for Operation on Slick Roads
- Engine Maintenance
- Maintenance Requirements
- Maintenance Schedule Intervals
- Preventative Maintenance Schedule
- Engine Specifications
- Engine Lubricating Oil Recommendations and Specifications
- Engine Oil Capacities and Pressures
- Engine Lubrication and Filter Intervals
- Cooling System Maintenance
- Engine Coolant Specifications
- Extended Life Coolant
- Fuel Recommendations
- Warranty and the Use of Biodiesel Fuel
- Recommendations to Avoid Fuel Gelling
- Fuel Filter Interval
- Diesel Exhaust Fluid Recommendations and Specifications
- Maintenance Procedures
- Engine Identification
- Engine Warranty
- Index
• DEF tank and lines
• DEF tank heater coolant control
valve
• DEF temperature sensors
• Diesel Exhaust Fluid (DEF) dosing
unit (Pump)
• Diesel oxidation catalyst
• Diesel particulate filter (except for
ash maintenance)
• Diesel particulate filter differential
pressure sensor EGR
• Exhaust gas piping from
turbocharger out to the last
aftertreatment device
• NOx sensors
• SCR catalyst
Air Handling Component
• Ambient air temperature sensor
• Charge air cooler and associated
plumbing
• Exhaust gas pressure sensor
• Exhaust manifold
• Grid heater
• Intake manifold
• Intake manifold temperature/pressure
sensor
• Throttle actuator/valve
• Turbocharger actuator
• Turbocharger assembly
• Turbocharger compressor intake
pressure/temperature sensor
• Turbocharger speed sensor
Base Engine System Component
• Camshaft
• Camshaft valve lobe
• Clean idle sticker
• Coolant temperature sensor
• Crankcase breather
• Engine oil pressure sensor
• Engine speed, position sensor, cam
position sensor
• Exhaust valve
Electronic Control System
Component
• DEF lamp
• Engine control module
• Engine control module calibration
• OBD connector
• On Board Diagnostic (OBD)
Malfunction Indicator Lamp (MIL)
• Wiring harness circuits connected at
both ends to emissions warrantable
components
Exhaust Gas Recirculation (EGR)
System Component
• EGR cooler
• EGR differential pressure sensor
• EGR mixer/venturi
• EGR temperature sensor
• EGR valve
Fueling System
• Fuel injectors
• Fuel lines
• Fuel pressure sensor
• Fuel pump
• Fuel pump actuator
• Secondary fuel pressure/temperature
sensor
Replacement Parts
State of California emissions statement on
replacement parts.
PACCAR recommends that any service
parts used for maintenance, repair or
replacement of emission control systems
be new or genuine PACCAR approved
rebuilt parts and assemblies, and that the
engine be serviced by an authorized
PACCAR engine dealer or an authorized
ENGINE WARRANTY - United States and Canada Engine Warranty
Y53-1183-1E1 (04/16/18) 87
3