operators_manual
Table Of Contents
- Contents
- Engine Operation
- Safety - Introduction
- Emergency - What To Do If
- Operating Instructions
- Engine Maintenance
- Maintenance Requirements
- Maintenance Schedule
- Engine Specifications
- Engine Lubricating Oil Recommendations and Specifications
- Engine Oil Specifications
- Engine Lubrication and Filter Intervals
- Cooling System Maintenance
- Engine Coolant Specifications
- Extended Life Coolant
- Fuel Recommendations
- Warranty and the Use of Biodiesel Fuel
- Recommendations to Avoid Fuel Gelling
- Maintenance Procedures
- Engine Oil Level
- Engine Oil Filter
- Crankcase Ventilation (CCV) Module Maintenance
- Fuel Filter
- Cooling System
- Drive Belts
- Engine Belt Checks
- Fan Belt Tensioner
- Engine Fan
- Poly V-belt and Fan Drive Belt Removal
- Poly V-belt and Fan Drive Belt Installation
- Poly V-belt, Alternator, Air-Conditioning Compressor Drive and Coolant Pump Drive Removal
- Poly V-belt, Alternator, Air-Conditioning Compressor Drive and Coolant Pump Drive Install
- Aftertreatment System
- Air System
- Air Intake System
- Turbocharger
- Exhaust System
- Charging - Cranking System
- Crankshaft - Vibration Damper
- Engine Mounting Bolts
- Engine Valves
- Engine Identification
- Engine Warranty
- Index
4. Fuel Filter
5. Air Compressor
6. Starter
7.
Power Steering Pump
8. Low Pressure Fuel Pump
9. A/C Compressor
10. Alternator
EPA Label
EPA label location and label information.
The EPA label provides important facts
about the engine. This label is located on
top of the engine valve cover or on the
mixer manifold. The engine EP
A label must
not be changed unless approved by
PACCAR.
EPA Label Location
The EPA label provides many details
regarding the engine. Some facts that are
found on the EPA label include the
following:
• Fuel rate
•
Idle speed
• Maximum rated speed
• Valve lash
• Maximum power rating
• Date of manufacture
• Engine Displacement
EP
A Label
XXX.X
X.XX
X.XX
X.XX
X.XX
XXXX
XXX - XXX
XXX/XXX
ENGINE MAINTENANCE - Engine Identification
82 Y53-1166-1G1 (08/2018)
2