operators_manual
Table Of Contents
- Contents
- Safety
- Applies To
- Using this Manual
- Safety Alerts
- Illustrations
- General Safety Instructions
- Data Recorder
- Environmental Protection Agency
- A Special Word About Repairs
- Additional Sources of Information
- Cab Access
- How to Access the Upper Bunk
- Deckplate Access
- How to open the hood
- Seat
- What to do before starting the vehicle
- Vehicle Loading
- Visual inspection while approaching the vehicle
- Daily Checks
- Weekly Checks
- Emergency
- Roadside Assistance
- Low Air Alarm
- Stop Engine Lamp
- Low Oil Pressure Lamp
- Engine is Overheating
- How to inspect and replace a fuse
- Where are the Fuses Located?
- How to Jump Start a Battery
- How to Recover a Vehicle
- Manually Release the Parking Brake
- What is a Recovery Hitch?
- How to use a Recovery Hitch
- How to Prepare the Axles for Towing
- How to Manually Lock a Differential
- Recovery Hitch Capacities
- What are the Best Practices for Recovery Rigging?
- Returning to Service After Recovering
- What to do if the Vehicle is Stuck in Sand, Mud, Snow or Ice
- Towing the Vehicle
- Controls
- Instrument Cluster
- How to use the Menu Control Switch
- Driver Information Display
- Odometer/Trip Odometer
- Outside Air Temperature
- Clock
- Active Warnings
- Cruise Control
- Header
- Menu Control Switch Cue
- Main Content Area
- Blank Screen
- Tire Pressure Monitoring System
- Virtual Gauges
- Ignition Timer
- Fuel Economy
- Trip Information
- Truck Information
- Warnings and Faults
- Settings
- Guide to the Warning Symbols
- Axle, Stability Control
- Axle, Traction Control
- Brakes, Anti-Lock Brake System
- Brake, Park Brake
- Brakes, Low Air
- Brake, Service Brake
- Brakes, Trailer Anti-Lock Brake System
- Differential, Inter Axle Lock
- Dump Truck, Body Up
- Dump Truck, Gate
- Dump Truck, Trailer Body Up
- Diesel Particulate Filter (DPF) Warning Lamp
- Emissions, High Exhaust System Temperature
- Emissions, Malfunction Indicator Lamp
- Engine, Check Engine
- Engine, Engine Fan
- Engine, Engine Block Heater
- Engine, Low Coolant Level
- Engine, Overspeed Air Shutdown
- Engine, Retarder (Brake)
- Engine, Stop Engine
- Engine Wait-To-Start Lamp
- Fuel Water In Fuel (WIF)
- Lights, High Beam
- Lane Departure Warning (LDW)
- Power Take-off (PTO) Pump Mode
- Power Take-off (PTO)
- Refrigerator
- Suspension Dump
- Seat Belt Fasten
- Tire Inflation (TPMS)
- Transmission, Auxiliary
- Transmission, Check
- Transmission, Oil Temperature High
- Transmission, Retarder
- Transmission, Service Transmission (Allison only)
- Turn Signal, Left
- Turn Signal, Right
- Optional Gauges
- Axle, Pusher Air Pressure
- Axle, Tag Air Pressure
- Fuel Filter Restriction
- Air Filter Restriction Indicator or Gauge
- Engine, Oil Pressure
- Engine, Oil Temperature
- Manifold Pressure Gauge
- Fuel Pressure Gauge
- Transmission Temperature Gauge
- Drive Axle Temperature Gauge (Forward and Rear)
- Suspension Load Air Pressure, #1, #2
- Tractor Brake Application Air Pressure
- Trailer Brake Application Air Pressure
- Trailer Air Tank Air Pressure
- Transfer Case Oil Temperature
- Transmission Oil Temperature, Auxiliary
- Transmission Retarder Oil Temperature
- Dash Switches
- Axle, Diff-Lock - Dual
- Axle, Diff-Lock - Forward Rear
- Axle, Diff-Lock - Steer
- Axle, Diff-Lock - Rear Rear
- Axle, Diff-Lock - Single Rear
- Axle, Inter-Axle Differential Locked (Tandem)
- Axle, Differential Lock - Tridrive
- Axle, Two Speed
- Back Up Alarm Mute
- Batteries, Low Voltage Disconnect (LVD)
- Brakes, ABS Off-Road
- Brakes, Parking Brake Valve
- Brake, Trailer Hand
- Cab Dimmer Switch
- Dump Truck Gate
- Engine, Cruise Control On/Off
- Engine, Cruise Control Set/Resume
- Engine, Fan Override
- Engine, Heater
- Engine, Remote Throttle
- Engine, Overspeed Air Shutdown (Manual)
- Engine, Overspeed Air Shutdown (Test)
- Engine, Under Hood Air Intake
- Exhaust, Diesel Particulate Filter (DPF) Regeneration
- Fifth Wheel Slide
- Fuel Heater
- Generic Air, Accessory
- Generic, Spare SPARE
- Ignition Key Switch
- Lights, Auxiliary
- Lights, Beacon
- Lights, Daytime Running (Override)
- Lights, Dome
- Lights, Exterior Lights Self Test
- Lights, Flood
- Lights, Flood (Spare)
- Lights, Fog
- Lights, Hazard
- Lights, Headlight
- Lights, Marker/Clearance
- Lights, Marker/Clearance/Trailer
- Lights, Park Light
- Lights, Spot
- Mud and Snow Traction Control
- Pintle Hook
- Power Take-off (PTO)
- Power Take-off (PTO), Forward
- Power Take-off (PTO), Rear
- Suspension, Axle, Pusher
- Suspension, Axle, Tag
- Suspension, Dump
- Suspension, Air Retention
- Suspension, Third Axle Lift
- Trailer Air Supply
- Trailer, Axle (3rd Axle) Lift
- Trailer, Axle Lift Forward
- Trailer, Axle Lift Rear
- Trailer, Belly Dump
- Trailer, Dump Gate
- Trailer, Belly Dump Gate Center
- Trailer, Belly Dump Gate Front
- Trailer, Belly Dump Gate Rear
- Trailer, Hotline
- Trailer, Suspension Air Dump
- Transmission, Transfer Case
- Transmission, Transfer Case 2 Speed
- Winch Clutch
- Steering Column Controls
- Controls on the Right Hand of the Steering Column
- Controls on the Right Hand of the Steering Column
- Steering Wheel Controls (Optional)
- City Horn
- Door Mounted Controls
- Ignition Key Switch
- What is the Exterior Lights Self Test
- How to use the Exterior Light Self Test Switch
- Heating and Air Conditioning
- Sleeper Alarm Clock
- Cab Accessories
- Sleeper Control Panel
- Driving
- Starting and Operating
- Starting and Warming Up
- Engine Operations
- Stationary Power Take Off Operation
- Engine Fan Control
- Using a Winterfront
- Engine Control Display
- What is Exhaust Aftertreatment
- Engine Brake Operation
- Engine Brake Operation for a Vehicle with Automated Transmission
- Cruise Control
- Adaptive Cruise Control (Optional)
- Predictive Cruise Control (Optional)
- Air Filter Restriction Indicator
- Transmission
- Brakes
- Axle and Suspension
- Aftertreatment System
- Driving Tips and Techniques
- What to Consider when using a Sleeper Bunk
- Stopping the Vehicle
- Maintenance
- Maintenance Schedule
- New Vehicle Maintenance Schedule
- Lubricants
- Checking Oil Level
- Inspect Power Steering Fluid
- What is the Air System?
- Air Dryer Maintenance
- Air Tanks
- How to Check for Air System Leaks
- What is an Air Compressor?
- Brake System
- Cab Maintenance
- Safety Restraint System - Inspection
- Cooling System Maintenance
- Windshield Wiper/Washer
- Electrical System
- Aftertreatment System Power Requirements
- What is Low Voltage Disconnect?
- How to Replace Headlamp Bulb
- Vehicle Light Bulb specifications
- Aiming Headlights
- Fuses, Circuit Breakers and Relays
- Altering the Electrical System
- Batteries
- Under Cab Battery Access
- In Cab Battery Access
- Cranking Battery Specification
- Removing Batteries
- Installing Batteries
- Replace Battery Box Cover
- Slow Battery Charging
- Alternator
- Remote Keyless Entry
- Engine Maintenance
- Fuel System
- Frame
- Front Axle and Suspension
- Heater and Air Conditioner Maintenance
- Noise and Emission Control
- Rear Axle and Suspension
- Steering System
- Driveline
- Tires
- Wheels
- Transmission Maintenance
- Hydraulic Clutch
- Specification Reference Charts
- Information
- Index
