operators_manual
Table Of Contents
- Safety
- Applies To
- Using this Manual
- Safety Alerts
- Illustrations
- General Safety Instructions
- Data Recorder
- Environmental Protection Agency
- A Special Word About Repairs
- Additional Sources of Information
- Cab Access
- Cab Tilting
- Standard Seat
- What to do before starting the vehicle
- Vehicle Loading
- Visual inspection while approaching the vehicle
- Weekly Checks
- Daily Checks
- Emergency
- Roadside Assistance
- How to Recover a Vehicle
- Manually Release the Parking Brake
- What is a Recovery Hitch?
- How to use a Recovery Hitch
- How to Prepare the Axles for Towing
- How to Manually Lock a Differential
- Recovery Hitch Capacities
- What are the Best Practices for Recovery Rigging?
- Returning to Service After Recovering
- What to do if the Vehicle is Stuck in Sand, Mud, Snow or Ice
- Towing the Vehicle
- Controls
- Getting to Know the Dash
- Gauges in the Center Cluster
- Left Hand Accessories Overhead
- Right Hand Accessories Overhead for Dual Sit Steer Applications
- Guide to the Warning Symbols
- Axle, Traction Control
- Axle, Stability Control
- Axle, Front Driven
- Axle, Oil Temperature (Forward or Rear)
- Brakes, Anti-Lock Brake System
- Brake, Park Brake
- Brakes, Trailer Anti-Lock Brake System
- Emissions, High Exhaust System Temperature
- Emissions, Malfunction Indicator Lamp
- Emissions, Engine Derate
- Diesel Particulate Filter (DPF) Warning Lamp
- Diesel Exhaust Fluid (DEF) Lamp
- Fifth Wheel Slide, Unlocked
- Engine, Check Engine
- Engine, Low Coolant Level
- Engine, Coolant Temperature
- Engine, Oil Temperature
- Engine, Oil Pressure
- Voltmeter
- Engine, Overspeed Air Shutdown
- Engine, Retarder (Brake)
- Engine, Stop Engine
- Engine, Wait To Start
- Engine, Air Filter Restriction
- Fuel Filter Restriction
- Fuel Water In Fuel (WIF)
- Lights, High Beam
- Suspension Dump
- Seat Belt Fasten
- Tire Inflation (TPMS)
- Transmission, Check
- Transmission, Neutral
- Transmission, Oil Temperature High
- Turn Signal, Left
- Turn Signal, Right
- Introduction
- Speedometer
- Tachometer
- Engine - Coolant Temperature
- Fuel Level
- Engine, Oil Pressure
- Diesel Exhaust Fluid (DEF)
- Vehicle Air Pressure
- Driver Information Display
- Information Display
- Virtual Gauges
- Engine Speed RPM Detail
- Ignition Timer
- Trip Information
- Truck Information
- Diagnostic Display
- Transmission Display
- Active Warnings
- Clock
- Settings
- Menu Control Switch
- Switches in the Center Console
- Dual Station Switch
- Steering Column Controls
- How to Use the Turn Signal
- How to Turn on High Beams
- How to Momentarily Flash High Beams
- How to Flash Marker and Clearance Lights
- Operate the Windshield Wipers
- How to Spray Windshield Washer Fluid
- Trailer Brake Hand Valve
- Heating and Air Conditioning
- Air Conditioner Control Panel
- How to Manually Control the Air Conditioner for the Cab
- Dash Switches
- Axle, Diff-Lock - Dual
- Axle, Diff-Lock - Forward Rear
- Axle, Diff-Lock - Steer
- Axle, Diff-Lock - Rear Rear
- Axle, Diff-Lock - Single Rear
- Axle, Inter-Axle Differential Locked (Tandem)
- Axle, Differential Lock - Tridrive
- Axle, Two Speed
- Batteries, Low Voltage Disconnect (LVD)
- Brakes, ABS Off-Road
- Brakes, Parking Brake Valve
- Cab Dimmer Switch
- Dump Truck Gate
- Engine, Brake On/Off
- Engine, Cruise Control On/Off
- Engine, Cruise Control Set/Resume
- Engine, Fan Override
- Engine, Heater
- Engine, Remote Throttle
- Engine, Overspeed Air Shutdown (Manual)
- Engine, Overspeed Air Shutdown (Test)
- Engine, Under Hood Air Intake
- Exhaust, Diesel Particulate Filter (DPF) Regeneration
- Fifth Wheel Slide
- Fuel Heater
- Generic Air, Accessory
- Generic, Spare SPARE
- Ignition Key Switch
- Lights, Auxiliary
- Lights, Beacon
- Lights, Daytime Running (Override)
- Lights, Dome
- Lights, Flood
- Lights, Flood (Spare)
- Lights, Fog
- Lights, Hazard
- Lights, Headlight
- Lights, Marker/Clearance
- Lights, Marker/Clearance/Trailer
- Lights, Park Light
- Lights, Spot
- Mud and Snow Traction Control
- Pintle Hook
- Power Take-off (PTO)
- Power Take-off (PTO), Forward
- Power Take-off (PTO), Rear
- Suspension, Axle, Pusher
- Suspension, Axle, Tag
- Suspension, Dump
- Suspension, Air Retention
- Suspension, Third Axle Lift
- Trailer Air Supply
- Trailer, Axle (3rd Axle) Lift
- Trailer, Axle Lift Forward
- Trailer, Axle Lift Rear
- Trailer, Belly Dump
- Trailer, Dump Gate
- Trailer, Belly Dump Gate Center
- Trailer, Belly Dump Gate Front
- Trailer, Belly Dump Gate Rear
- Trailer, Hotline
- Trailer, Suspension Air Dump
- Transmission, Transfer Case
- Transmission, Transfer Case 2 Speed
- Winch Clutch
- Driving
- Starting and Operating
- How to Use Engine Start Switch on Right Hand Drive
- Starting and Warming Up
- Engine Operations
- Transmission
- Brakes
- Axle and Suspension
- Aftertreatment System
- Dual Steer Operation
- Driving Tips and Techniques
- Stopping the Vehicle
- Maintenance
- Maintenance Schedule
- New Vehicle Maintenance Schedule
- Lubricants
- Checking Oil Level
- Inspect Power Steering Fluid
- What is the Air System?
- What is an Air Dryer?
- Air Tanks
- How to Check for Air System Leaks
- What is an Air Compressor?
- Brake System
- Cab Maintenance
- Cooling System Maintenance
- Safety Restraint System - Inspection
- Windshield Wiper/Washer
- Electrical System
- Engine Maintenance
- Fuel System
- Frame
- Front Axle and Suspension
- Heater and Air Conditioner Maintenance
- Noise and Emission Control
- Rear Axle and Suspension
- Steering System
- Driveline
- Tires
- Wheels
- Transmission Maintenance
- Mechanical Clutch
- Specification Reference Charts
- Information
- Index
suitable reinforcing plates to ensure
that the insulators will remain in
position.
Exhaust System
• Check for exhaust leaks, which
would indicate a leaking manifold
gasket; replace gasket if necessary.
• Check cap screws for tightness,
including those at the flanges. Refer
to the engine manufacturer's service
manual for proper tightening
sequence and torque values.
Joints and Clamps
• Check for leaks, and tighten as
necessary. Check for deterioration
or dents in pipes and clamps which
could allow exhaust to escape.
• Replace any serviceable joints,
flexible pipes and gaskets at the
service intervals.
Selective Catalysts Reduction (SCR)
• Check SCR canister filter, clamps
and mounting brackets. Tighten if
necessary. Inspect SCR canister for
signs of rust or corrosion.
Exhaust Piping
• Check exhaust piping for rust,
corrosion, or damage. Replace
deteriorated piping before holes
appear. If piping is perforated at any
point, temporary patching or lagging
is acceptable until you can have
permanent repairs made. On
turbocharged engines, check joints
at flanges and mounting brackets
for tightness.
Diesel Particulate Filter (DPF)
• Check diesel particulate filter (DPF),
clamps, and mounting brackets.
Tighten if necessary. Inspect diesel
particulate filter (DPF) for signs of
rust or corrosion.
• Check internal baffling. You can do
this by listening for rattling sounds
while tapping on the diesel
particulate filter (DPF) with a rubber
mallet or revving the engine up and
down through its normal operating
range.
Diesel Exhaust Fluid Tank (See
Aftertreatment System manual.)
Exhaust Tail Pipe
Engine Fan and Shroud
Hood Insulation Blanket
Inner Fenders Shields and Cab Skirts
Rear Axle and Suspension
Maintenance requirements for rear axle
suspension.
Your vehicle's suspension, by design,
requires a minimal amount of maintenance.
However, suspensions in over-the-road
operations require periodic inspection to
ensure trouble-free performance.
WARNING!
Do not work on the vehicle without the park-
ing brake set and wheels blocked securely.
If the vehicle is not secured to prevent un-
controlled vehicle movement, it could roll
and may result in death, personal injury,
equipment or property damage.
MAINTENANCE - Rear Axle and Suspension
Y53-6096-1A1 (01/17) 201
5










