OPERATOR'S MANUAL
Table Of Contents
- How to Use This Manual
- Safety Signals
- Vehicle Safety
- How to Find What You Want
- A Special Word About Repairs
- Shop Manuals
- Preventive Maintenance Section
- Additional Sources of Information
- Start–Up
- Instruments and Controls
- Introduction
- Warning Lights and Buzzer
- Self Test
- Speedometer and Odometer
- Tachometer
- Coolant (Water) Temperature Gauge
- Engine Oil Pressure Gauge
- Dual Air Pressure Gauge (Air Reservoir)
- Fuel Gauge
- Voltmeter (option)
- Transmission Temperature Gauge (option)
- Air Filter Restriction Indicator (option)
- Headlight Switch
- Daytime Running Lights (option)
- Panel Lights
- ID and Clearance Lights
- Windshield Wipers/Washer
- Ignition Key Switch
- Parking Brake
- Cruise Control Switch
- Hand Throttle Control
- Heating and Air Conditioning
- Accessories
- Seats
- Steering Column and Mirrors
- Operating the Engine
- Operating the Transmission
- Using the Brake System
- Operating the Rear/Drive Axle
- More Driving Tips and Techniques
- Vehicle Recovery and Spring Brakes
- Shut–Down
- Introduction
- Maintenance Schedule and Lubrication
- Engine Maintenance
- Cooling System
- Brake System
- Air System
- Tires and Wheels
- Heater and Air Conditioner
- Electrical System
- Cab Maintenance
- Transmission and Clutch
- Steering and Driveline
- Front Axle and Suspension
- Rear Axle and Suspension
- Frame and Fifth Wheel
- Noise and Emission Control
- Consumer Information and Vehicle Identification
Maintenance Schedule and Lubrication Preventive Maintenance
– 138 –
PB1318 3/01 Model 330
Cam Brake Camshaft Splines; Disc Brake
Shaft Splines and Slide Pin Retainers; Brake
Clevis Pins
Antiseize type grease, Rockwell specification 0-637.
Brake Camshaft Bushings EP Chassis grease, lithium 12-hydroxystearate base, NLGI 2.
CAUTION: Do not contaminate brake linings with grease.
Steering Shaft Grease Fittings EP chassis grease, lithium 12-hydroxystearate base, NLGI 2.
Brake Treadle Hinge and Roller Engine oil
Lock Cylinders Lock lubricant.
Door Hinges Not required — Teflon bushings
Door Latches & Striker Plates. Polyethylene grease stick.
Door Weatherstrip Silicone lubricant.
Other Items Use manufacturer’s manuals.
Table 5 Recommended Lubrication Types
COMPONENTS RECOMMENDED LUBRICANT
Deviations from the above list of lubricants should be based on specifications published in the component manufacturer's manuals or otherwise
approved by the manufacturer.