OPERATOR'S MANUAL
Table Of Contents
- How to Use This Manual
- Safety Signals
- Vehicle Safety
- How to Find What You Want
- A Special Word About Repairs
- Shop Manuals
- Preventive Maintenance Section
- Additional Sources of Information
- Start–Up
- Instruments and Controls
- Introduction
- Warning Lights and Buzzer
- Self Test
- Speedometer and Odometer
- Tachometer
- Coolant (Water) Temperature Gauge
- Engine Oil Pressure Gauge
- Dual Air Pressure Gauge (Air Reservoir)
- Fuel Gauge
- Voltmeter (option)
- Transmission Temperature Gauge (option)
- Air Filter Restriction Indicator (option)
- Headlight Switch
- Daytime Running Lights (option)
- Panel Lights
- ID and Clearance Lights
- Windshield Wipers/Washer
- Ignition Key Switch
- Parking Brake
- Cruise Control Switch
- Hand Throttle Control
- Heating and Air Conditioning
- Accessories
- Seats
- Steering Column and Mirrors
- Operating the Engine
- Operating the Transmission
- Using the Brake System
- Operating the Rear/Drive Axle
- More Driving Tips and Techniques
- Vehicle Recovery and Spring Brakes
- Shut–Down
- Introduction
- Maintenance Schedule and Lubrication
- Engine Maintenance
- Cooling System
- Brake System
- Air System
- Tires and Wheels
- Heater and Air Conditioner
- Electrical System
- Cab Maintenance
- Transmission and Clutch
- Steering and Driveline
- Front Axle and Suspension
- Rear Axle and Suspension
- Frame and Fifth Wheel
- Noise and Emission Control
- Consumer Information and Vehicle Identification
Preventive Maintenance Maintenance Schedule and Lubrication
Model 330 PB1318 3/01
– 129 –
Radius Rods / Torque Arms
Chassis Frame – Cracks or Breaks
Spring Shackles and Hanger Brackets No Service Required
Spring Pins No Service Required
King Pin Wear
Steer Axle Wheel Bearing - End Play Adjustment
and Inspection
350,000 Miles With LMS Outer Ends
• No Leak – No Service
Front Hub Lubricant Level
Spring Leaves
U–Bolt and Suspension Fastener Torque
Tighten U-bolts after the first 500 miles
(800 km). Rear suspension fasteners:
retorque after first 2,000 miles (3218 km).
Leaks:
Coolant
Engine Oil
Power Steering
Fuel
Transmission
Axles
Inner and Outer Hub Seals
Engine and Transmission Mounts
Drivelines – U–joints and Slip Yokes
Rear Axle Lubricant Level
Rear Axle Lubricant Flush & Refill
C4 At 250,000 Miles
Rear Axle Breathers – Clear
Tractor Protection Valve Breakaway Test
Table 3 Maintenance Schedule
INTERVAL COMMENTS
OPERATION \ FREQUENCY
7,500 mi
12,000 km
15,000 mi
24,000 km
60,000 mi
96,000 km